SUPERSEDES: NEW
Plant ID No. 001-5012
DESCRIPTION:
®
The 00e
series 0018e
circulator is a variable speed wet rotor circulator with an ECM, permanent magnet
TM
motor. Operating modes include infinitely variable fixed speed, constant pressure, proportional pressure,
and activeADAPT
self-adjusting proportional pressure
TM
0018e
ECM Circulator Mobile App using Bluetooth
TM
high-efficiency motor reduces power consumption by up to 85% compared to equivalent AC permanent split
capacitor circulators.
APPLICATION:
• Maximum operating pressure: 125 psi (8.6 bar)
• Maximum water temperature: 230°F (110ºC)
• Electrical specifications:
Voltage: 110-120V, 50/60 Hz, single phase
Maximum operating power: 44W
Maximum amp rating: 0.54
• Equipped with a cast iron casing and should be used for closed loop systems only
• Not suitable for open loop potable water or chilled water systems
• Taco circulator pumps are for indoor use only – employer uniquement a l'interieur
• Acceptable for use with water or maximum of 50% water/glycol solution
FEATURES:
• 3 operating modes in dial activation:
- Proportional pressure ( TRV - Panel Radiator ), variable speed - 2 variable pressure
differential settings (Med or High)
- Constant pressure ( ZV - Zone Valve ), variable speed - 2 constant pressure
differential settings (Med or High)
- Fixed speed ( ZONE CIRC - zoning with circulators ) - infinitely adjustable MIN/MAX settings
• 4 operating modes in 0018e
- Fixed Speed - infinitely adjustable MIN/MAX settings
- Constant Pressure - variable speed - 9 constant pressure differential settings
- Proportional Pressure - variable speed - 9 variable pressure differential settings
- activeADAPT
to system conditions
• Multi-color LED display showing operating mode and error code diagnostics
• Use with a Taco ZVC Zone Valve Control or SR Switching Relay for ON/OFF operation
• Nut capture feature on flanges for easier fit up
• Dual electrical knockouts and 6" stranded wire leads for easy wiring
• Double insulated - no ground-wire required
• Whisper quiet operation
• BIO Barrier
®
protects the pump from system contaminants
• SureStart
- automatic unblocking and air purging mode
®
• Optional 2-way flange model for easy fit-up to any flange orientation
• Integral Flow Check (IFC
) included - Field installed
®
INSTALLATION:
WARNING: Do not use in swimming pool or spa areas. Pump has not been investigated for these applications.
AVERTISSEMENT: Ne pas utiliser dans une piscine ou un spa. La pompe n'a pas été étudiée pour ces applications.
CAUTION: The addition of petroleum based fluids or certain chemical additives to systems using TACO equipment voids the warranty. Consult factory for fluid
compatibility.
ATTENTION: L'ajout de liquides à base de pétrole ou de certains additifs chimiques à des systèmes utilisant un équipement TACO annule la garantie. Consultez
le fabricant pour connaître la compatibilité de liquides.
CAUTION: Installations at elevations over 5000 feet must have higher fill pressure of 20 psi minimum to prevent pump cavitation and flashing. Premature failure
may result. Adjust expansion tank pressure to equal fill pressure. A larger size expansion tank may be required.
ATTENTION: Des installations à des altitudes de plus de 1600 mètres doivent présenter une pression de remplissage plus élevée de 20 psi au minimum afin
d'éviter toute cavitation ou flashing de la pompe. Une défaillance prématurée peut en résulter. Réglez la pression du réservoir d'expansion de façon qu'elle soit
égale à la pression de remplissage. Un réservoir d'expansion d'une taille supérieure peut être nécessaire.
Instruction Sheet
0018e
ECM High-Efficiency Circulator
TM
Featuring Bluetooth
Adjust the operating mode with the dial or the Taco
.
®
connectivity on your smartphone or tablet. The ECM
Mobile App activation:
TM
- Designed for constant circulation systems. Automatically adjusts
TM
Communication
®
102-557
EFFECTIVE: March 22, 2019
Figure 1:
Standard flange model: 0018e-F2
Part #: VR1816-HY2-FC2A01
Optional 2-way flange model: 0018e-F4
Part #: VR1816-HY2-4C2A01
1