3) Draining the Main drive lithium-ion battery
Step 1. After 14 days have elapsed, remove the vehicle from the water.
Step 2. Remove the under cover (2 pieces) from bottom of vehicle. (See illustration below.)
- Use Socket wrench (size 10mm) for loosing of fixing bolt.
- Use Flat head screwdriver for removing of fixing clip.
Step 3. Drill drain holes in the marked locations on the bottom of the Main drive lithium-ion
battery (See "Drain hole locations on Main drive lithium-ion battery" on next page). Then,
drain water from the Main drive lithium-ion battery.
The drained water from the Main drive lithium-ion battery should be collected in a
container.
Step 4. Drained water from the pool and the Main drive lithium-ion battery shall be properly
disposed of as an industrial waste according to state and/or local regulations.
WARNING:
Always wear eye protection (safety glasses) to protect from sharp flying chips and drain water
for your eyes safety.
Do not use an electric operated drill to make holes in the Main drive lithium-ion battery as
water coming down may enter the drill, cause a short, and electrocute the operator. Instead,
use a battery operated drill and wear rubber insulating gloves.
If there is a danger that the drainage in the Main drive lithium-ion battery is touch the work
clothes and the skin, wear the solvent resistant protective equipment and perform the
operation.
CAUTION:
Process the drained water from the pool or the Main drive lithium-ion battery according to the rules
of local governments etc. as industrial waste properly. Since the drained water is an aqueous
solution containing a small amount (1 to several ppm) of metals such as P (Phosphorus) and Li
(Lithium) etc., advise industrial waste disposer for proper disposal.
22