Summary of Contents for Mitsubishi Lancer Evolution IX 2005
Page 1
Service Manual Electrical Wiring Diagrams...
Page 2
If you have any opinions, requests or queries regarding this manual, please write them down on the “Servicing Comment Form” on the last page, and fax them to us. March 2005 Mitsubishi Motor Corporation This manual is printed on recycled paper.
Page 3
The component parts of the SRS airbag system or seatbelt pre-tensioner system, and parts relating to these systems, must always be inspected and serviced by a Mitsubishi dealer. Service personnel must read the relevant service manuals (particularly, Section 52B – SRS Airbags) carefully and thoroughly, before inspecting or servicing the component parts of the SRS airbag system or seatbelt pre- tensioner system, and parts relating to these systems.
SECTION 3 CIRCUIT DIAGRAMS CONTENTS J/B ............3-4 Meters Needle meters..........3-68 Remaining fuel warning light, oil pressure J/C ............3-6 warning light, brake warning light, seatbelt warning light ........3-70 Central Junction........3-11 Door Opening / Closing Control Power Supply ........3-18 Power windows ..........3-72 Central door locking Starting System ........3-23 (vehicle without keyless entry)......3-78...
Page 5
Equipment Sunroof ............3-154 Ignition key reminder buzzer......3-157 ABS..............3-122 Intercooler water spray ........3-158 ACD (vehicle without AYC) ......3-130 Engine immobilizer system ......3-160 ACD, AYC ............3-138 Security alarm ..........3-162 SRS airbags, seatbelt pre-tensioners Spare connector for fog lamp ......3-167 (vehicle without front passenger airbag)..3-148 Generic spare connectors......3-168 SRS airbags, seatbelt pre-tensioners (vehicle with front passenger airbag).....3-152...
CIRCUIT DIAGRAMS - J/B Power window relay Generic fuse Fuel pump relay 2 Fuel pump relay 1 Demister Blower relay relay Dummy connector Water spray relay Dummy connector Note : The connector numbers correspond to the layout diagrams, and to the instrument panel and respective circuit diagrams. J/B side connector...
Page 8
CIRCUIT DIAGRAMS - J/B Rear side Front side To instrument panel To instrument panel Power window relay Blower relay Fuel pump relay 1 Demister relay Intercooler water spray relay Fuel pump relay 2 Generic fuses Dummy connector Dummy connector To floor harness (RH) To roof harness Note : The triangle symbols in the J/B and relay boxes show the positions that coincide with the triangle marks engraved on the relays.
CIRCUIT DIAGRAMS - J/C Note : In the actual vehicle, any of the terminals connected inside the J/C may be used. Therefore the terminal numbers indicated on the circuit • Windscreen • Fog lamps diagrams may not correspond to the terminal sequence in the vehicle. washer/wiper •...
Page 10
CIRCUIT DIAGRAMS - J/C • Windscreen • Fog lamps washer / wiper • Full auto A/C • Turn signal • Headlights • Windscreen washer / lights, hazard • Headlight wiper lights levelling • Electric stowable • Tail lights, system remote control door position lights, •...
Page 12
CIRCUIT DIAGRAMS - J/C Electric stowable remote control Spare audio door mirrors connector Generic Fog lamps fuse • Spare • Fog lamps connector for • Spare Generic fog lamps connector for fuse fog lamps Clock Generic spare connector Diagnosis connector •...
CIRCUIT DIAGRAMS - CENTRAL JUNCTION 3-11 CENTRAL JUNCTION Fusible Links (relay box inside engine compartment and fuse box connected directly to battery) Relay box in engine compartment Front of vehicle Fuse box connected directly to battery Front of vehicle...
Page 17
3-14 CIRCUIT DIAGRAMS - CENTRAL JUNCTION Central relays (relay box inside engine compartment) Relay box inside engine compartment Front of vehicle Front of vehicle Note : The triangle symbols engraved in the J/B and relay box indicate the position which coincide with the triangle marks engraved on the relays.
Page 18
CIRCUIT DIAGRAMS - CENTRAL JUNCTION 3-15 Dedicated Fuses (relay box in engine compartment and fuse box installed in J/B)
Page 19
3-16 CIRCUIT DIAGRAMS - CENTRAL JUNCTION...
Page 20
CIRCUIT DIAGRAMS 3-17 Relay box in engine compartment Front of vehicle Fuse box installed in J/B...
Page 21
CIRCUIT DIAGRAMS - POWER DISTRIBUTION 3-18 POWER DISTRIBUTION Battery Fusible links Charging • Full auto A/C • ACD (vehicle • Manual A/C w/out AYC) • Cooling • ACD, AYC Dedicated fuses • Full auto A/C Engine control • ABS • Full auto •...
Page 22
CIRCUIT DIAGRAMS - POWER DISTRIBUTION 3-19 Headlight Headlight Tail light relay LO relay HI relay Front ECU • Engine • Security • Fog lamps Headlights Headlights Headlights Headlights Tail lights, position immobiliser alarm • Spare lights, licence Headlight system • Horn connector plate lights, levelling...
3-20 CIRCUIT DIAGRAMS - POWER DISTRIBUTION Power distribution (continued) Fusible link Dedicated fuse Ignition switch Intercooler water spray • Engine control • Starting system Ignition • SRS airbags, Engine control • ABS • Turn signal lights, seatbelt pre- • ACD (vehicle hazard lights tensioners w/out AYC)
Page 24
CIRCUIT DIAGRAMS - POWER DISTRIBUTION 3-21 • ABS Windscreen Cigarette light, Electric stowable • Rear washer / • Spare audio ashtray • ACD (vehicle washer / wiper remote control wiper connector illumination lights w/out AYC) door mirrors • Clock • Cabin lights, •...
Page 25
3-22 CIRCUIT DIAGRAMS - POWER DISTRIBUTION Power distribution (continued) Fusible Fusible link link Dedicated fuse Sunroof • Sunroof * Heater • ACD (vehicle w/out • ABS • Power * Full auto A/C AYC) • ACD (vehicle w/out windows • ACD, AYC * Manual A/C AYC) •...
3-28 CIRCUIT DIAGRAMS - ENGINE CONTROL SYSTEM ENGINE CONTROL SYSTEM Battery Dedicated fuse Ignition Engine control relay Engine ECU Power supply...
Page 32
CIRCUIT DIAGRAMS - ENGINE CONTROL SYSTEM 3-29 Ignition switch (IG1) Fuel Fuel pump pump relay 2 relay 1 • Windscreen washer / wiper Combination • Turn signal lights, meter hazard lights • Tail lights, position lights, licence plate lights, lighting monitor warning buzzer •...
Page 33
3-30 CIRCUIT DIAGRAMS - ENGINE CONTROL SYSTEM Engine control system (continued) Engine control relay J/C (6) (Engine control relay) Intake cam Exhaust cam position position Air flow sensor sensor sensor Intake temp. sensor Air pressure sensor Engine • ACD (vehicle w/out AYC) •...
Page 34
CIRCUIT DIAGRAMS - ENGINE CONTROL SYSTEM 3-31 J/C (6) Engine (Engine control relay) control relay Register (for injectors) Oil feed control valve Crank angle sensor Injector Injector Injector Injector Engine control relay Manifold absolute pressure Knock sensor sensor O 2 sensor...
Page 35
3-32 CIRCUIT DIAGRAMS - ENGINE CONTROL SYSTEM Engine control system (continued) Ignition switch (ST) Engine control relay Idle speed control Waste gate servo Fuel Starter solenoid pressure relay valve 1 solenoid valve Engine ECU Engine speed detection connector Power steering fluid pressure switch...
Page 36
CIRCUIT DIAGRAMS - ENGINE CONTROL SYSTEM 3-33 Engine control relay Intercooler water spray Waste gate Secondary Waste solenoid air control gate valve 2 solenoid solenoid valve valve • ACD, AYC • Full auto A/C • Heater • ACD (vehicle • Manual A/C •...
Page 37
3-34 CIRCUIT DIAGRAMS - ENGINE CONTROL SYSTEM Engine control system (continued) Engine ECU Fusible link generic fuse Engine immobiliser system Vehicle speed sensor Diagnosis connector Diagnosis connector Front side Front side...
Page 38
CIRCUIT DIAGRAMS - ENGINE CONTROL SYSTEM 3-35 Note: • Windscreen washer / (Fuel pump relay 2) wiper • Needle meters • Electric stowable remote control door mirrors • Generic spare connector • Cabin lights, boot compartment lights, ignition key cylinder illumination light, door ajar indicator light Fuel pump...
3-54 CIRCUIT DIAGRAMS - LIGHTING Fog lamps Battery Dedicated fuse Front ECU Fog lamp Tail light relay relay Dedicated fuse Tail lights, position lights, licence plate lights, lighting monitor warning buzzer Fog lamps Combination meter Fog lamp switch...
Page 58
3-55 Ignition Ignition switch (IG1) switch (IG2) Generic fuse Power supply • Full auto • Intercooler • ABS water spray • ACD, AYC • Cooling • Full auto • ACD (vehicle w/out AYC) • SRS airbags, seatbelt pre- • Cooling tensioners •...
Page 59
3-56 CIRCUIT DIAGRAMS - LIGHTING Fog lamps (cont’d) Fusible link Generic fuse Power supply Diagnosis connector Front side J/B side connector...
3-72 CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL DOOR OPENING / CLOSING CONTROL Power Windows Fusible link Ignition switch (IG1) Keyless entry transmitter Keyless entry receiver Power supply Diagnosis connector Door switch (front : RH) J/B side connector...
Page 76
CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL 3-73 Fusible link Power window sub-switch (Front : LH) Power window relay Hall IC Hall IC Power window motor (front : LH) Front side...
Page 77
3-74 CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL Power windows (cont’d) Power window relay (Front :RH) Power window main switch Lock switch (Front : LH) Power window motor (front : RH) Hall IC Hall IC...
Page 78
CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL 3-75 Power window sub-switch Power window relay (Rear : RH) Power window sub-switch (rear : LH) (Rear : LH) Power window motor (rear : LH) Hall IC Hall IC...
Page 79
3-76 CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL Power windows (cont’d) Power window Power window main switch relay Power window sub-switch (rear : RH) Power window motor (rear : RH) Hall IC Hall IC...
Page 80
CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL 3-77 <Notes>...
3-78 CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL Central door locking (vehicle w/out keyless entry) Ignition switch (IG1) Fusible link Power supply Door lock actuator (front : RH) Diagnosis connector J/B side connector...
Page 82
CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL 3-79 Door lock Door lock Door lock actuator actuator actuator (front : LH) (rear : RH) (rear : LH) Front side...
3-80 CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL Central door locking (vehicle with keyless entry) Ignition switch (IG1) Fusible link Power supply Key reminder switch (ON when key forgotten) Diagnosis connector Door lock actuator (front : RH) J/B side connector...
Page 84
CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL 3-81 Keyless entry transmitter Keyless entry receiver Door lock actuator Door lock actuator Door lock actuator (rear : LH) (rear : RH) (front : LH) Front side...
Page 85
3-82 CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL Central door locking (vehicle with keyless entry) (cont’d) Battery Dedicated fuse Turn signal light Turn signal light relay : RH relay : LH Headlight Rear Rear ASSY combination combination Side turn signal (turn : LH) light light...
Page 86
CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL 3-83 Headlight Combination Side turn ASSY meter signal light (turn : RH) (RH)
Page 87
3-84 CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL Central door locking (wavelength with keyless entry) (cont’d) Front cabin Rear cabin light light (vehicle w/out sunroof) J/B side connector...
Page 88
CIRCUIT DIAGRAMS - DOOR OPENING / CLOSING CONTROL 3-85 Door switch Door switch Door switch Door switch (rear : RH) (front : RH) (front : LH) (rear : LH)
3-86 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL TEMPERATURE CONTROL Heater Ignition switch (IG2) Fusible link Blower relay Blower switch Intercooler water spray Register Blower motor...
Page 90
CIRCUIT DIAGRAMS - TEMPERATURE CONTROL 3-87 Blower Front ECU Generic fuse switch (tail light relay) Generic fuse Dedicated fuse Tail lights, position lights, licence plate Internal / External lights, lighting air switching monitor warning damper motor buzzer Dummy terminals Heater control unit Heater control panel ILL...
Page 91
3-88 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL Heater (cont’d) Generic Heater control unit Battery fuse Dedicated fuse Dummy compressor connector relay Dummy connector Engine ECU...
3-90 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL Manual Air-Conditioning Ignition switch (IG2) Fusible link Blower relay Blower switch Intercooler water spray Register Blower motor...
Page 94
CIRCUIT DIAGRAMS - TEMPERATURE CONTROL 3-91 Generic fuse Register Front ECU (tail light relay) Generic fuse Air thermo sensor Dedicated fuse Tail lights, position lights, licence plate lights, lighting Internal / External monitor warning air switching damper buzzer motor A/C switch, internal/external air damper motor, ILL Demister...
Page 95
3-92 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL Manual Air-Conditioning (cont’d) Fusible link Engine control relay Radiator fan control relay Radiator fan controller Smoothing circuit Radiator fan Input signal Field-effect motor processor transistor circuit Drive circuit Current Temperature detection detection...
Page 96
CIRCUIT DIAGRAMS - TEMPERATURE CONTROL 3-93 J/C (2) Battery Generic fuse Dedicated fuse • Windscreen washer / wiper Condenser Condenser • Turn signal lights, fan relay (LO) fan relay (HI) hazard lights • Tail lights, position lights, licence plate lights, lighting monitor warning buzzer •...
Page 97
3-94 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL Manual Air-Conditioning (cont’d) J/C (2) Radiator fan controller Generic fuse Battery Dedicated fuse Low pressure Dual OFF : 196 kPa pressure ON : 221 kPa compressor switch relay High pressure OFF: 3138 kPa ON : 2550 kPa A/C compressor Coolant temperature...
3-96 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL Fully automatic air-conditioning Fusible link Ignition switch (IG2) Blower relay Intercooler water spray Blower pulse controller Back-up power supply...
Page 100
CIRCUIT DIAGRAMS - TEMPERATURE CONTROL 3-97 Front ECU (tail light relay) Dedicated fuse External air temperature sensor Tail lights, position lights, licence plate lights, lighting monitor warning buzzer Demister, door mirror heating elements Cabin temperature sensor...
Page 101
3-98 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL Fully automatic air-conditioning (cont’d) Engine control relay Fusible link Radiator fan control relay Radiator fan controller Smoothing circuit Radiator fan motor Input signal Field-effect processor transistor circuit Drive circuit Temperature Current detector detector...
Page 102
CIRCUIT DIAGRAMS - TEMPERATURE CONTROL 3-99 Generic fuse Battery Dedicated fuse • Windscreen Condenser washer / wiper Condenser fan relay (LO) fan relay (HI) • Turn signal lights, hazard lights • Tail lights, position lights, licence plate lights, lighting monitor warning buzzer •...
Page 103
3-100 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL Fully automatic air-conditioning (cont’d) Heater water Air mixing door Air thermo sensor temperature motor & sensor potentiometer Cabin temp. External air temp. sensor sensor Dedicated IC Dedicated IC Generic fuse Internal / External air switching damper motor...
Page 104
CIRCUIT DIAGRAMS - TEMPERATURE CONTROL 3-101 Fusible link Blower switching damper motor & potentiometer Dedicated IC Diagnosis connector Sunlight sensor Front side...
Page 105
3-102 CIRCUIT DIAGRAMS - TEMPERATURE CONTROL Fully automatic air-conditioning (cont’d) Radiator fan Generic Battery controller fuse Dedicated fuse Low pressure Dual compressor pressure : 196 kPa relay switch : 221 kPa High pressure : 3138 kPa : 2550 kPa A/C compressor Coolant temperature switch...
3-114 CIRCUIT DIAGRAMS - VISION / SAFETY Electric stowable remote control door mirrors Ignition switch (ACC) Fusible link Ignition switch (IG1) Power supply Door mirror Door mirror stow relay return relay Remote control door mirror (LH) Up/down Left/right Return / Stow motor motor motor...
Page 118
CIRCUIT DIAGRAMS - VISION / SAFETY 3-115 Remote control mirror switch right down left Stow or return Left/right switch Remote control door mirror (RH) Up/down Left/right Return / stow motor motor motor J/B side connector...
Page 119
3-116 CIRCUIT DIAGRAMS - VISION / SAFETY Electric stowable remote control door mirrors (cont.) Engine control generic fuse • ABS Vehicle speed • ACD, AYC sensor • ACD (vehicle w/out AYC) • SRS airbags, seatbelt pre-tensioners • Intercooler water spray •...
Page 120
CIRCUIT DIAGRAMS - VISION / SAFETY 3-117 generic fuse Keyless entry transmitter Keyless entry receiver Diagnosis connector Front side J/B side connector...
Page 147
3-144 CIRCUIT DIAGRAMS - EQUIPMENT ACD, AYC (cont’d) Fusible link Electric pump relay Pressure Hydraulic sensor Electric unit ASSY pump Hydraulic unit ASSY...
3-152 CIRCUIT DIAGRAMS - EQUIPMENT SRS airbags, seatbelt pre-tensioners (vehicle with front passenger airbag) Fusible Combination meter link Ignition switch (IG1) • Windscreen washer / wiper • Electric stowable remote control • Engine control door mirrors • Needle meters • Fog lamps •...
Page 157
3-154 CIRCUIT DIAGRAMS - EQUIPMENT Sunroofs Fusible Ignition switch (IG2) link Dedicated fuse Control circuit hall IC hall IC Sunroof motor ASSY...
CIRCUIT DIAGRAMS - EQUIPMENT 3-157 Ignition key reminder buzzer Fusible link Ignition switch (IG1) Buzzer Key reminder switch (ON if key forgotten) Diagnosis connector Door switch (front : RH) Front side J/B side connector...
Page 162
CIRCUIT DIAGRAMS - EQUIPMENT 3-159 Front ECU Input signals (tail light relay) • Air flow sensor • Vehicle speed sensor • Coolant temperature sensor • Throttle position sensor Dedicated fuse Engine ECU Tail lights, position lights, licence plate lights, lighting monitor warning buzzer Tail lights, position lights, licence plate...
Page 163
3-160 CIRCUIT DIAGRAMS - EQUIPMENT Engine Immobiliser System Battery Dedicated fuse • Engine control • Ignition Engine control relay Engine control Power supply Engine Front side...
3-162 CIRCUIT DIAGRAMS - EQUIPMENT Security Alarm Fusible link Ignition switch (IG1) Power supply Key reminder switch (ON if key forgotten) Diagnosis connector Front side...
Page 166
CIRCUIT DIAGRAMS - EQUIPMENT 3-163 Keyless entry transmitter Keyless entry receiver Door switch Door switch Door switch Door switch (rear : LH) (rear : RH) (front : RH) (front : LH) J/B side connector...
Page 167
3-164 CIRCUIT DIAGRAMS - EQUIPMENT Security Alarm (cont’d) Battery Dedicated fuse Turn signal light Turn signal light relay : RH relay : LH Rear Headlight Rear combination Side turn signal combination ASSY light (turn : RH) light (LH) light (turn : LH) (turn : LH) J/B side connector...
Page 168
CIRCUIT DIAGRAMS - EQUIPMENT 3-165 Horn relay Buzzer Combination Headlight Side turn meter ASSY signal light (turn : RH) (RH)
CIRCUIT DIAGRAMS - EQUIPMENT 3-167 Spare connector for fog lamps Battery Dedicated fuse Spare connector for fog lamp relay Spare connector for fog lamp switch Combination meter Front ECU Spare connector for fog lamps...
LAYOUT DIAGRAMS - ENGINE COMPARTMENT ENGINE COMPARTMENT Connector Symbol Front harness (RH) A-01 (2-grey) Side turn signal lamp (RH) A-13X (11) Front ECU A-02 (2-grey) Brake fluid level switch A-14 (2-black) Junction between front harness (LH) and A-04 (2-grey) Side turn signal lamp (LH) control harness A-05 (2-black)
1-10 LAYOUT DIAGRAMS - INSTRUMENT PANEL INSTRUMENT PANEL Front passenger side Connector Symbol A/C harness Instrument panel harness Tweeter sub-harness Front harness (LH) Front door harness (LH) Control harness Floor harness (LH) C-01 (4) Register (vehicle with heater, manual C-10 (6) Motor and potentiometer for blower A/C) switching damper (vehicle with fully...
Page 182
LAYOUT DIAGRAMS - INSTRUMENT PANEL 1-11 C-22 (25) Instrument panel harness / Control C-34 (16) Control harness / Front harness (LH) harness junction junction C-23 (33) J/C (6) C-37 (22-yellow) 4WD-ECU C-28 (2) Blower motor (vehicle with heater, manual C-38 (26-yellow) 4WD-ECU A/C) C-43 (1-grey) Control harness / Floor harness (LH)
Page 183
1-12 LAYOUT DIAGRAMS - INSTRUMENT PANEL Instrument Panel (cont’d) Connector Symbol Driver’s side Instrument panel harness C-101 (1) Roof antenna C-112 (11-black) Remote control mirror switch C-103 (14) Spare audio connector C-113 (6) Instrument panel harness / Roof harness C-104 (5) Sunlight sensor (vehicle with full auto junction A/C)
1-18 LAYOUT DIAGRAMS - DOORS DOORS Connector Symbol Front doors (Passenger side) (Driver side) Front door Front door harness (RH) harness (LH) E-01 Remote control door mirror (RH) E-07 Remote control door mirror (LH) E-02 (14) Power window main switch E-08 Front door speaker (LH) E-03...
Page 190
LAYOUT DIAGRAMS - DOORS 1-19 Rear doors (Passenger side) (Driver side) Rear door Rear door harness (LH) harness (RH) E-101 (6-grey) Power window motor (rear : RH) E-104 (6-grey) Power window motor (rear : LH) E-102 (8) Power window sub-switch (rear : RH) E-105 (8) Power window sub-switch (rear : LH) E-103 (6-black)
PART INSTALLATION POSITIONS - SENSORS SENSORS Note : The * symbol indicates that the sensor is also fitted on the right-hand side of the vehicle.
Page 194
PART INSTALLATION POSITIONS - SENSORS Manifold absolute pressure sensor Air temp. sensor Inlet manifold Knock sensor connector Knock sensor Vehicle speed sensor Throttle position sensor Transmission case Air flow sensor Crank angle sensor Crank angle sensor connector...
Page 195
INDIVIDUAL PART INSTALLATION POSITIONS - ECU O2 sensor O 2 sensor connector ntake cam position sensor Ext. air temp. sensor Exhaust cam position sensor (Vehicle not fitted with front passenger airbag) Front impact sensor Coolant temperature sensor Steer sensor Sunlight sensor Heater water temperature sensor Air thermo sensor...
Page 196
PART INSTALLATION POSITIONS - SENSOR Parking brake lever Pressure sensor Later G sensor Front/rear G sensor Hydraulic pressure unit ASSY Front ABS sensor connector Front ABS sensor Rear ABS sensor Rear ABS sensor connector Parking brake cable...
PART INSTALLATION POSITIONS - ECU Note : • The *1 symbol indicates that the ECU is also fitted on the right-hand side. • The *2 symbol indicates that the ECU is also fitted at the rear door (LH, RH).
Page 198
PART INSTALLATION POSITIONS - ECU Front ECU Radiator fan controller Headlamp ASSY (with built-in discharge ECU) Radiator ASSY Column switch (column ECU built into wiper switch) Immobiliser Engine ECU Blower unit Blower pulse controller...
Page 199
PART INSTALLATION POSITIONS - ECU Glove box Sunroof motor ASSY Power window main (built-in ECU) switch (built-in ECU) Power window main switch (built-in ECU)
PART INSTALLATION POSITIONS - RELAY RELAYS M3020000400514 Fuel pump relay 3 Electric pump relay Hydraulic unit A/C compressor relay Compressor fan relay (HI) Engine control relay Compressor fan relay (LO) Horn relay Ignition coil relay Fog lamp relay Radiator fan control relay Starter relay...
PART INSTALLATION POSITIONS - EARTHS 2-15 EARTHS Note : These earth numbers are the same as those used in the circuit diagrams. Accelerator earth Wiper arm blade ASSY Diagnosis connector...
Page 207
2-16 PART INSTALLATION POSITIONS - EARTHS Sunroof motor ASSY Engine ECU Exhaust cam position sensor...
Page 208
PART INSTALLATION POSITIONS - EARTHS 2-17...
Page 209
SECTION 4 INDEX CONTENTS Index listed in connector Index listed in number order ..........4-2 part name order ........4-10...
Page 210
INDEX INDEX CONNECTOR NO. LIST CONNECTOR NO. LIST CONNECTOR NO. LIST...
Page 211
INDEX INDEX CONNECTOR NO. LIST CONNECTOR NO. LIST...
Page 212
INDEX INDEX CONNECTOR NO. LIST CONNECTOR NO. LIST...
Page 213
INDEX INDEX CONNECTOR NO. LIST CONNECTOR NO. LIST...
Page 214
INDEX INDEX 4-10 4-11 PART NAME LIST PART NAME LIST PART NAME LIST...
Page 215
INDEX INDEX 4-12 4-13 PART NAME LIST PART NAME LIST...
Page 216
INDEX INDEX 4-14 4-15 PART NAME LIST PART NAME LIST...
Page 217
INDEX INDEX 4-16 4-17 PART NAME LIST PART NAME LIST RJAK503019-242...
Page 218
SECTION 0 General Information CONTENTS Vehicle Identification ......0-2 How to Read the Wiring Diagrams..0-2 Composition and Contents of Wiring Diagrams..0-2 How to Read Layout Diagrams........0-3 Implementation Code ......0-2 How to Read Circuit Diagrams ........0-4 Connector and Earth Markings ........0-6 Wire Colour Codes .............0-9 Abbreviation Symbols ..........0-9...
GENERAL INFORMATION - VEHICLE IDENTIFICATION VEHICLE IDENTIFICATION Note : The [ ] symbol indicates a new model; the [ ] symbol indicates an existing model; and the [x] symbol indicates a discontinued model. Implementation Code GH-CT9A ; CT9A-0400001 How to Read the Wiring Diagrams Composition and Contents of Wiring Diagrams This manual contains wiring layout diagrams, individual part installation positions, circuit diagrams and an index.
Page 220
GENERAL INFORMATION - HOW TO READ THE WIRING DIAGRAMS Reading Layout Diagrams The wiring layout diagrams give a clear and simple illustration of the connector positions and the routing of the wiring harnesses at different points in the actual vehicle. Indicates connector number.
Page 221
GENERAL INFORMATION - HOW TO READ THE WIRING DIAGRAMS Reading Circuit Diagrams These diagrams show the circuits for each system, from the fuse or fusible link to the earth. In principle, the power supply is shown at the top and the earth at the bottom, to make it easier to understand the flow of current in the circuit. The circuit diagrams show a state where none of the switches, etc.
Page 222
GENERAL INFORMATION - HOW TO READ THE WIRING DIAGRAMS ndicates a wiring connector inside a device, Indicates input / output to which is not shown in the layout diagrams. and from control unit Example : (direction of current flow). Indicates a connector Indicates that these are the same intermediate connector.
GENERAL INFORMATION - HOW TO READ THE WIRING DIAGRAMS Connector / Earth Markings The circuits contain a large number of connectors and earths, and the following system has been adopted for depicting connectors and earths in the circuit diagrams. Fusible link Ignition switch Solenoid valve...
Page 224
GENERAL INFORMATION - HOW TO READ THE WIRING DIAGRAMS Item Connector / Earth Symbol Details Terminals and Different terminal symbols are Male Male connector connectors used to indicate male terminals, terminal which are inserted into another terminal, and female terminals, which receive other terminal.
Page 225
SUMMARY - OVERVIEW OF CIRCUIT DIAGRAMS Direct connection type Harness connection type Intermediate connector Vehicle body earth Device earth Earth in control unit...
GENERAL INFORMATION - HOW TO READ THE WIRING DIAGRAMS Wire Colour Codes M3000011000154 The different wire colours are indicated by the following letter codes. Example If a cable has two colours, the first colour code indicates the standard colour (the basic colour of the cable coating), and the second colour code indicates the marking colour.
Page 227
0-10 GENERAL INFORMATION - HOW TO READ THE WIRING DIAGRAMS 2. Abbreviations used in internal circuits of combination meter 3. Abbreviations used in switch and relay circuits...
Page 228
GENERAL INFORMATION - HOW TO READ THE WIRING DIAGRAMS 0-11 4. Other abbreviations...