Team C Jekyll TR02EVO Manual
  1. Manuals
  2. Brands
  3. Team C Manuals
  4. Motorized Toy Car
  5. Jekyll TR02EVO
  6. Manual

Team C Jekyll TR02EVO Manual

1:10 scale 2wd electric buggy
Hide thumbs Also See for Jekyll TR02EVO:
Table of Contents

Advertisement

Quick Links

1:10 SCALE 2WD ELECTRIC BUGGY
TR02EVO CHASSIS

Advertisement

Table of Contents
loading

Related Manuals for Team C Jekyll TR02EVO

Summary of Contents for Team C Jekyll TR02EVO

  • Page 1 1:10 SCALE 2WD ELECTRIC BUGGY TR02EVO CHASSIS...
  • Page 2 Notice Thank you for purchasing this Jekyll Offroad Buggy by Team C. This manual shows instructions and tips to built and maintain your Jekyll. Please take some time to read through to get familiar with the shown steps. We continually improve our products, due to that, actual parts my be different to the illustrations.

  • Page 3: Transmitter Preparation

    Transmitter Preparation Power Switch 27MHzTransmitter Crystal （TX） Antenna Transmitter crystal(TX) Receiver crystal(RX) Extend the antenna to the maximum Length for best performance The crystal can be replaced to change frequencies. Note : You must also change receiver crystals! Do not use AM crystals Battery Level Indicator Good Batteries Straight (neutral)

  • Page 4: Tools Required

    Transmitter Preparation A new Ni-MH battery must be charged before it is used.Refer to the charger instruction manual for charging. Set up the radio control system as indicated below。 Motor Battery 馬達 Electronic Speed Controller DIGITAL PROPORTIONAL RADIO CONTROL SYSTEM Switch Transmitter 發送機...
  • Page 5 Front Suspension T02056 T02056 T02104 T02125 T02037 T02056 2.3 E-ring T02056 ………………………………4 T02056 T02104 T02056 3x34.5 Hinge pin front inner T02056 ………………………………2 T02056 Front Suspension T02059 T02126 T02008 T02083 M3x15 Screw T02109 ……………4 T02059 Ball stud - long T02083 ……………………2 Assemble in the specified order Assemble left and right sides the same way...
  • Page 6 Front Suspension T02082(3x10) T02082(3x8) T02082(3x10) T02128 T02144 T02082 M3x8 Screw ………………2 T02082(3x10) T02082 M3x10 Screw ………………6 T02082(3x10) Front Suspension T02054 2.3 E-ring T02054 3x27.5 Hinge pin front outer ……………8 …………4 <Right> T02042 4.0 E-ring T02060 Ball stud - short ……………………4 …………2 T02042 2x9.8 Shaft T02079 5x10x4...
  • Page 7 Front Suspension T02082(3x10) T02082(3x8) T02082(3x10) T02128 T02144 T02082 M3x8 Screw ………………2 T02082(3x10) T02082 M3x10 Screw ………………6 T02082(3x10) Front Suspension T02054 2.3 E-ring T02054 3x27.5 Hinge pin front outer ……………8 …………4 <Right> T02042 4.0 E-ring T02060 Ball stud - short ……………………4 …………2 T02042 2x9.8 Shaft T02079 5x10x4...
  • Page 8 Front Suspension T02112 Front Upper(Right) approx.38mm T02045 T02112 Front Upper (Left) T02112 4.8mm Ball End(Long) approx.38mm …………8 Steering Tip T02045 3x54 Turnbuckle approx.34mm ………4 Front Suspension Front Suspension T02082(M3x22) T02117 T02082(M3x22) T02117 T02082 M3x10 Screw T02082 M3x22 Screw T02117 5mm Plastic Ball stud T02129 ……2 ………4...

  • Page 9: Differential Gear

    Differential Gear T02049(17x23x1) T02077(5x8x2.5) T02046 T02050(2.6x6x3) T02007(M2.5) T02078(10x15x4) T02007 T02047 T02078(10x15x4) T02046 T02007(2.5x25) T02049(17x23x1) T02077(5x8x2.5) T02004 T02048(2.37) T02049 17x23x1 Washer T02007 M2.5x25 Screw T02077 5x8x2.5 Contain oil ball bearing ……………2 ……1 ……………2 T02078 10x15x4 Contain oil ball T02007 M2.5 Nylon Nut T02048 2.37mm Ball bearing ……………1...

  • Page 10: Motor Mounts

    <Left> Transmission T02121 T02079 T02052 T02041 <Right> T02079 T02121 T02079 5x10x4 Contain oil ball Bearing T02051 …………………4 T02051 5x16.8 idler gear shaft T02079 ……………………1 T02003 T02041 5x8x6.7 Top shaft spacer T02079 …………………1 T02082(3x25) Motor mounts Screw Cement T02082(3x25) Screw Cement T02082(3x12) T02082 M3x12 Screw T02082 M3x25 Screw...
  • Page 11 Main Gear T02134 T02038 T02119 T02038 T02134 approx.18mm T02040 T02084 Rear Damper Tower T02130 T02082(M3x22) T02082(M3x10) T02082(M3x22) T02082 M3x10 Screw T02117 ………………4 T02082 M3x22 Screw T02117 ……2 T02117 5mm Plastic Ball stud ………………………2 T02108...

  • Page 12: Rear Bulkhead

    Rear Bulkhead T02082 T02082 T02127 T02059 T02059 Ball stud - long T02082 M3x10 Screw ……………2 …………4 Rear Chassis T02125 T02009 T02083 M3x8 Screw T02083 T02083 …………2...

  • Page 13: Rear Suspension

    Rear Suspension T02125 T02055 3x48 Hinge pin Rear inner T02105 ……2 T02055 T02083 M3x8 Screw T02083 ………………………………2 Rear Suspension T02083 M3x10 Screw T02083 …………2 T02083 Assemble left and right sides the same way...
  • Page 14 Rear Transmission T02082 T02082 M3x10 Screw ……………2 T02083 M3x8 Screw ……………2 T02083 Rear Shock Tower & Rear Fender T02082(3x10) T02082 M3x8 Screw …………2 T02082 M3x10 Screw …………4 T02082(3x8) Screws which were semi tightened in P9 T02083(3x8) T02109 Assemble in the specified order...
  • Page 15 Rear Suspension <Left> <Right> T02135 T02124 T02079 T02060 T02079 T02115 TU0254 T02060 Ball stud - short …………………2 T02079 5x10x4 Contain oil ball bearing T02115 2x9.8 Shaft …………………2 ……………4 Rear Suspension T02057 T02124 T02057 T02057 2.3 E-ring …………………………4 T02057 T02057 3x30.5 Hinge pin Rear outer T02124 3.1x6x1 Plastic Washer ………………………2 …………2...
  • Page 16 Rear Suspension Right Upper T02112 4.8mm Ball End(Long) approx.35mm …………………………4 T02112 T02045 T02112 T02045 3x54 Turnbuckle …………………………2 Rear Suspension Main Chassis T02083(3x10) T02083 M3x8 Screw …………2 T02108 T02083 M3x10 Screw …………2 T02108 T02108 T02083(3x10) T02108 T02083(3x8) Assemble as many times as specified True-to -scale diagram...
  • Page 17 Front Rear Shock Absorber T02138 / T02139 2.3 E-ring Put a little oil T02067 …………………………8 T02066 T02069 T02068 9.9x2.5 Shock Piston Put a little oil T02069(2.8x1.9) T02069 …………………4 T02139 T02069(3x1mm) T02069(2.8x1.9) T02138 T02069(2.8x1.9) T02069(3x1mm) T02069 2.8x1.9 O-ring T02067 T02068 T02069(2.8x1.9) …………………8 T02068 T02066...
  • Page 18 Front Shock Absorber T02140 Short for adjusting the spring tension T02140 Compress the spring and install T02066 Long T02114 T02067 T02072(Long) T02071(Short) T02140 3mm adjuster ring …………4 T02114 Rear Front Suspension T02084 T02082 Short T02082 M3x15 Screw T02084 M3 Nylon Nut …………2 ……2 Assemble as many times as specified...
  • Page 19 Rear Suspension T02084 Long T02082 T02084 M3 Nylon Nut T02082 M3x15 Screw ……2 …………2 Motor T02120 Motor T02081 T02083 T02082 T02083 M3x8 Screw T02141 T02082 M3x5 Screw ………2 ………2 T02081 3x7x0.8 Washer T02141 M3x3 Screw …………2 …………1 Assemble left and rear sides the same way Assemble in the specified order...
  • Page 20 Steering Servo T02081 T02082 Select for your servo T02136 T02111 T02113 T02081 Steering Servo-H(24T) Steering Servo-S(23T) T02082 T02110(25T) T02082(2.6x8) Sanwa servo T02111 T02116 Steering Servo T02083 T02113 4.8 Ball End(Short) T02081 3x7x0.8 Washer T02136 Ball stud - silvery ……………2 …………………1 ………………4 T02083 M3x8 Screw T02116 1.5 Servo spacer...
  • Page 21 If using loose battery cells Battery Please put the battery panel conversely T02086 T02022 T02086 T02022 Battery Battery T02086 Small clip …………2 Rear Front Wheels T02074 T02075 T02075(Sponge) T02074(Sponge) T02032 T02033 After fitting wheels to tyres,apply instant glue as shown Assemble as many times as specified Assemble in the specified order Must be purchased separately...
  • Page 22 Body Mounting Body Mounting TR4036 T02086 T02118 T02146 T02108 T02086 +3 deg 3° 3° -3 deg T02084 T02086 Small clip ……………5 T02084 M4 Flanged Nylon Nut T02084 ……………4 Drill holes with the specified diameter Cut off shaded portion Assemble as many times as specified...
  • Page 24 Parts list for Jekyll off-road buggy-1 TR4036 T02144 T02146 TU0254 12mm Hex Hub-4mm Wing Body Main Chassis 4PCS 1pcs 1pcs 1PCS T02119 T02120 T02003 T02004 Gear Cover Button 1PCS Gear Cover 52T Gear 28T Spur Gear 80T Spur Gear 1PCS 1PCS 1PCS 1PCS...
  • Page 25 Parts list for Jekyll off-road buggy-2 T02106 T02107 T02108 T02109 Servo saver upper Rear body mount 1PCS 2PCS Servo saver lower 1PCS Wing angie shim Steering Rack Servo saver - L 2PCS Front bumper Motor guard 1PCS 1PCS Wing bracket Battery column 1PCS 1PCS 2PCS...
  • Page 26 Parts list for Jekyll off-road buggy-3 T02048 T02049 T02050 T02051 2.37mm Ball 2.6x6x3 Stop push ball bearing 17x23x1 Washer idler gear shaft 12PCS 2PCS 1PCS 1PCS T02141 T02054 T02055 T02052 2.3 E-ring 4PCS 3x27.5 Hinge pin front outer Pinion Gear 21T 3x48 Hinge pin Rear inner 3x3 Screw Gear 20T...
  • Page 27 Parts list for Jekyll off-road buggy-4 T02074 T02072 T02073 T02075 Rear Shock Absorber Spring 2PCS Diaphragm Front-tyre Rear-Sponge Front-Sponge Rear-tyre 4PCS 2PCS 2PCS 2PCS 2PCS T02077 T02078 T02079 T02080 3x6x2.5 Ball Bearing 5x8x2.5 Contain oil ball bearing 5x10x4 Contain oil ball bearing 10x15x4 Contain oil ball bearing 6PCS 4PCS...
  • Page 28 Jekyll Upgrade Parts Tu0220 Tu0221 Tu0222 Tu0219 M3x3 C-Type-Holder C-Type-Holder C-Type-Holder C-Type-Holder Rear arm mount F/R 1Set Front arm mount 1Set 25 Degree - L 25 Degree - R 30 Degree - L 30 Degree - R Tu0224 Tu0225 Tu0226 Tu0228 2x5 Screw 4pcs...
  • Page 29 HOBBYPRO COMPANY LTD. Flat C-D, 5/F., Speedy Ind. BLDG., 114 How Ming Street, Kwun Tong, KLN., Hong Kong. Team C Headquarter www.teamcracing.net Team C America www.teamcamerica.com Team C Europe www.teamceurope.com...

Table of Contents