Table Of Contents; Introduction; Preparing For The New Installation; Table Of Contents - State Water Heaters 184748-001 Instruction Manual

Thank You for purchasing this water heater. Properly installed and
maintained, it should give you years of trouble free service.
Abbreviations Found In This Instruction Manual:
• ANSI - American National Standards Institute
• ASME - American Society of Mechanical Engineers
• GAMA - Gas Appliance Manufacturers Association
• NEC - National Electrical Code
• NFPA - National Fire Protection Association
• UL - Underwriters Laboratories Inc.
PREPARING FOR THE INSTALLATION
1. Read the "General Safety" section of this manual first and then the
entire manual carefully. If you don't follow the safety rules, the
water heater will not operate properly. It could cause DEATH,
SERIOUS BODILY INJURY AND/OR PROPERTY DAMAGE.
This manual contains instructions for the installation, operation, and
maintenance of the electric water heater. It also contains warnings
throughout the manual that you must read and be aware of. All
warnings and all instructions are essential to the proper operation of
the water heater and your safety. Since we cannot put everything
on the first few pages, READ THE ENTIRE MANUAL BEFORE
ATTEMPTING TO INSTALL OR OPERATE THE WATER HEATER.
This appliance has been Listed as complying with U.L. Standard for
Safety UL 174.
SAFE INSTALLATION, USE AND SERVICE ....................... 2
GENERAL SAFETY ............................................................... 3
INTRODUCTION .................................................................. 4
Preparing for the New Installation .................................. 4
TABLE OF CONTENTS ........................................................ 4
TYPICAL INSTALLATION ...................................................... 5
MIXING VALVE USAGE ......................................................... 6
LOCATING THE NEW WATER HEATER ............................. 7
Facts to Consider About Location ................................... 7
Insulation Blankets ........................................................... 7
INSTALLING THE NEW WATER HEATER .......................... 7
Water Piping .................................................................. 7-8
Water Piping Pressure Test ............................................. 8
Temperature-Pressure Relief Valve ........................... 8-9
Filling the Water Heater ................................................... 9
T & P Valve and Pipe Insulation (Selected Models) .. 10
WIRING DIAGRAMS ........................................................... 11
WIRING ............................................................................... 12
TEMPERATURE REGULATION ......................................... 13
Temperature Adjustment ............................................... 13

INTRODUCTION

2. The installation must conform with these instructions and the local
3. If after reading this manual you have any questions or do not
4. Carefully plan the place where you are going to put the water heater.
5. For California installation this water heater must be braced, anchored,
6. Massachusetts Code requires this water heater to be installed in

TABLE OF CONTENTS

FOR YOUR INFORMATION ................................................ 14
PERIODIC MAINTENANCE ............................................... 15
LEAKAGE CHECKPOINTS ................................................ 19
TROUBLESHOOTING GUIDELINES ................................ 20
REPAIR PARTS LIST .......................................................... 21
NOTES .......................................................................... 22-23
WARRANTY ................................................................... Insert
4
code authority having jurisdiction and the requirements of the power
company. In the absence of code requirements follow the current
edition of the NEC, National Electrical Code, NFPA-70 which may be
ordered from: National Fire Protection Association, 1 Batterymarch
Park, Quincy, MA 02269.
understand any portion of the instructions, call the local utility or the
manufacturer whose name appears on the rating plate.
INSTALLATION OR SERVICE OF THIS WATER HEATER REQUIRES
ABILITY EQUIVALENT TO THAT OF A LICENSED TRADESMAN IN
THE FIELD INVOLVED. PLUMBING AND ELECTRICAL WORK ARE
REQUIRED.
Examine the location to ensure the water heater complies with the
"Facts to Consider About the Location" section in this manual.
or strapped to avoid falling or moving during an earthquake. See
instructions for correct installation procedures. Instructions may be
obtained from California Office of the State Architect, 400 P Street,
Sacramento, CA 95814.
accordance with Massachusetts 248-CMR 2.00: State Plumbing Code
and 248-CMR 5.00.
Thermal Expansion ........................................................ 14
Strange Sounds ............................................................ 14
Operational Conditions .................................................. 14
Smelly Water ................................................................ 14
"Air" in Hot Water Faucets ........................................... 14
High Water Temperature Shut Off System ................. 14
Anode Rod Inspection .................................................... 15
Temperature-Pressure Relief Valve Operation ........... 15
Draining ........................................................................... 15
Thermostat Removal/Replacement ....................... 15-16
Element Cleaning/Replacement ............................. 16-18
Drain Valve Washer Replacement ................................ 18
Service ............................................................................. 18