Page 1
OPERATION AND MAINTENANCE MANUAL with parts catalogue Doosan purchased Bobcat Company from Ingersoll-Rand Company in 2007. Any reference to Ingersoll-Rand Company or use of trademarks, service marks, logos, or other proprietary identifying marks belonging to Ingersoll-Rand Company in this manual is historical or nominative in nature, and is not meant to suggest a current affiliation between C.P.N.
Page 3
P101 OPERATION AND MAINTENANCE MANUAL with parts catalogue C.P.N. : 89253462 DATE : JANUARY 2000...
Page 5
P110 OPERATION AND MAINTENANCE MANUAL with parts catalogue C.P.N. : 89253470 DATE : JANUARY 2000...
Page 7
P130/HP95 OPERATION AND MAINTENANCE MANUAL with parts catalogue C.P.N. : 89253488 DATE : JANUARY 2000...
Page 9
P150 OPERATION AND MAINTENANCE MANUAL with parts catalogue C.P.N. : 89253496 DATE : JANUARY 2000...
Page 11
P180/HP140 OPERATION AND MAINTENANCE MANUAL with parts catalogue C.P.N. : 89253504 DATE : JANUARY 2000...
Page 13
P90 P101 P110 P130 HP95 P150 P180 HP140 OPERATION AND MAINTENANCE MANUAL SERIAL No: 210000 –> This manual contains important safety information P101 SERIAL No: 210000 –> and must be made available to personnel who operate and P110 SERIAL No: 312200 –>...
Page 15
DECLARE THAT, UNDER OUR SOLE RESPONSIBILITY FOR MANUFACTURE AND SUPPLY, THE PRODUCT(S) P90 P101 P110 P130 HP95 P150 P180 HP140 TO WHICH THIS DECLARATION RELATES, IS (ARE) IN CONFORMITY WITH THE PROVISIONS OF THE ABOVE DIRECTIVES USING THE FOLLOWING PRINCIPAL STANDARDS.
Page 17
Is not approved by Ingersoll–Rand, b) May impair the safety of users and other persons, and 3. Submissions of proof that maintenance intervals have been c) May prejudice any claims made against Ingersoll–Rand. followed. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 18
Ingersoll–Rand branch or distributor. Where climatic conditions dictate that the other Ingersoll–Rand Compressor Fluids (XHP505 or Performance 500) must be used, the extended warranty will apply if the above conditions are met. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 19
WARNING – Before connecting the tow bar WARNING – For operating temperature WARNING – Flammable liquid. or commencing to tow consult the below 0_C, consult the operation and operation and maintenance manual. maintenance manual. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 20
Do not open the service valve before the Do not exceed the trailer speed limit. No naked lights. airhose is attached. Use fork lift truck from this side only. Emergency stop. Tie down point P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 21
On (power). Off (power). Read the Operation and Maintenance manual When parking use prop stand, handrake and before operation or maintenance of this Contains asbestos. wheel chocks. machine is undertaken. Compressor oil filling P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 22
When using compressed air always use appropriate personal protective equipment. All pressure containing parts, especially flexible hoses and their couplings, must be regularly inspected, be free from defects and be replaced according to the Manual instructions. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 23
When raising towing eye, set rear joint first, then front joint. set engine electrical system. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 24
Ensure that the effective cable length is as short as possible, whilst an accidental separation of the towing vehicle from the trailer. still allowing enough slackness for the trailer to articulate without the handbrake being applied. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 25
GENERAL INFORMATION P90/P101 FIXED HEIGHT RUNNING GEAR Unbraked version (M&E) P90/P101 FIXED HEIGHT RUNNING GEAR Braked version (M&E) P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 26
GENERAL INFORMATION P90/P101 VARIABLE HEIGHT RUNNING GEAR Unbraked version (M&E) P90/P101 VARIABLE HEIGHT RUNNING GEAR Braked version (M&E) P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 27
GENERAL INFORMATION P110/P130/HP95 FIXED HEIGHT RUNNING GEAR Braked version (M&E) P110/P130/HP95 VARIABLE HEIGHT RUNNING GEAR Braked version (M&E) P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 28
GENERAL INFORMATION P110WDG/P130WDG/ HP95WDG/P150 FIXED HEIGHT RUNNING GEAR Braked version (M&E) P110WDG/P130WDG/ HP95WDG/P150 VARIABLE HEIGHT RUNNING GEAR Braked version (M&E) P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 29
GENERAL INFORMATION P180/HP140 FIXED HEIGHT RUNNING GEAR Braked version (M&E) P180/HP140 VARIABLE HEIGHT RUNNING GEAR Braked version (M&E) P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 30
–1 Speed at full load. 2900 revs min To start the compressor in ambient temperatures below –10_C, the (P90, P101, P130 & HP95) cold start kit option will be required. In addition, to start the compressor in ambient temperatures –1 Speed at full load.
Page 31
(P180 & HP140) Maximum horizontal towing force. 865 kgf Fuel tank capacity 42 litres Maximum vertical coupling load (P90, P101, P110, P130 & HP95) (nose weight). 75 kgf Fuel tank capacity 70 litres (P150, P180 & HP140) VARIABLE HEIGHT RUNNING GEAR Braked version (M&E)
Page 32
165 R13 –2 Tyre pressure. 2,9 bar (42 lbf in WHEELS AND TYRES Further information may be obtained by request through (P150) Ingersoll–Rand customer services department. Number of wheels. 2 x 4 P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 33
Ensure that the correct fork lift truck slots or marked lifting / tie down pressure then it is recommended that safety retaining wires are points are used whenever the machine is lifted or transported. used on the hoses. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 34
7. CAUTION: Do not operate the machine with the canopy/doors in Any warnings necessary have been suitably displayed (where the open position as this may cause overheating and operators to be applicable). exposed to high noise levels. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 35
Should any of the safety shut-down conditions occur, the unit will stop. These are: STOPPING THE MACHINE Close the service valve. Low engine oil pressure P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 36
When the machine is to be permanently decommissioned or dismantled, it is important to ensure that all hazard risks are either eliminated or notified to the recipient of the machine. In particular:– P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 37
Refer to the Engine Manufacturer’s and grease the linkages. Check the water Manual . towing eye bolts under the bellows separator. cover (If applicable). Earth leakage Test the operation of the device. circuit breaker (WDG)(Socket panel). P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 38
At twelve month intervals, test the air discharge temperature switch machine to run. by removing it from the machine and immersing in a bath of heated oil. The switch should operate at 120_C. Replace the switch. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 39
Replace the drop–tube and reconnect all hoses and tubes to the element by turning it in a counter–clockwise direction. separator tank cover plate. Inspection Replace the compressor oil (refer to LUBRICATION later in this Examine the filter element. section). P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 40
VENTILATION chafing. Any suspect parts should be replaced before the machine is Always check that the air inlets and outlets are clear of debris etc. put back into service. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 41
CAUTION: Check the wheel nut torque 20 miles (30 kilometres) after refitting the wheels (Refer to the TORQUE SETTING TABLE later in Adjust nuts B and lock with the equaliser C parallel to the axle. this section) . P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 42
Wheel bearings should be packed with grease every 6 months. The or has suffered long shutdown periods, then more frequent service type of grease used should conform to specification MIL–G–10924. intervals will be required. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 43
Separator tank to frame 18–22 24–30 Euro–Loc adaptor to separator tank 58–67 78–91 Service pipe (–20jic) 106–133 143–180 Exhaust flange to manifold 17–21 23–28 Sight glass 40–50 54–68 Wheel nuts 50–80 67–109 P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 45
Yellow Relay, safety shut-down Relay, start inhibit Relay, oil temperature switch (engine) Relay, low fuel Key–switch Solenoid, fuel Solenoid, load Air temperature switch (airend) Air temperature switch (discharge) Oil temperature switch (engine) P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 46
ELECTRICAL SYSTEM Plug Black Light (right hand) Green Fog light Pink Light (left hand) Brown Orange Purple Grey Blue White Yellow P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 47
PIPING AND INSTRUMENTATION SYSTEM Air discharge Oil cooler Minimum pressure valve Oil filter Pressure gauge Thermostatic valve Separator tank Safety valve Compressor Engine Air/oil P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 48
Perforated Replace the separator element. discharge Faulty Check the regulation system. separator air. regulator element. valve. Pressure in Check the minimum pressure valve the system is or sonic orifice. too low. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 49
Replace the safety valve if faulty. to load when solenoid. electrical circuit by feeling for DO NOT ATTEMPT A REPAIR. the load movement whilst depressing the button is load button. pressed. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 50
FAULT FINDING on the cold start harness/wiring FAULT CAUSE REMEDY Engine fails Cold start Replace the relay. No oil flow. Incorrect Reverse nylon tube relay faulty. to start. connection. connections to the lubricator. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 51
30 minute rating: 4 kVA @ 0.8 PF 5 kVA @ unity PF Maximum starting load: 100 Amperes Maximum continuous rating: 36,4 Amperes Insulation class: Shaft input @ full load: 5 kW P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 52
Brushes position. The engine speed cylinder would then respond via the Inspect the brushes periodically for wear and replace if required. pressure regulator valve according to the air demand. P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 54
Voltmeter Green Circuit breaker 16A with earth leakage protection Pink Control fuse 5A Brown Contactor 16A Orange Socket outlet 16A Purple Socket outlet 16A Switch, compressor/generator Grey Valve, solenoid Blue White Yellow P90 P101 P110 P130 HP95 P150 P180 HP140...
Page 55
(Refer to section 4 General Information ). Drive belt is Re–tension the drive belt. not tensioned correctly. Drive pulley is Check the drive pulley and tighten loose on the as required. drive shaft. P90 P101 P110 P130 HP95 P150 P180 HP140...
Need help?
Do you have a question about the P90 and is the answer not in the manual?
Questions and answers
Hi I need a p90 or p130 preferably..how much is the total cost