Hatco FlAV-R-SAVOR FSD Series Installation And Operating Manual
Humidified holding and display cabinets
Hide thumbs
Also See for FlAV-R-SAVOR FSD Series:
- Installation and operating manual (96 pages) ,
- Original instructions manual (48 pages)
Table of Contents
Advertisement
Humidified Holding and Display Cabinets
Installation and operating Manual
register your unit online!
See IMPORTANT OWNER INFORMATION section for details.
Do not operate this equipment unless you have
read and understood the contents of this manual!
Failure to follow the instructions contained in this
manual may result in serious injury or death. This
manual contains important safety information
concerning the maintenance, use, and operation
of this product. If you're unable to understand the
contents of this manual, please bring it to the
attention of your supervisor. Keep this manual in
a safe location for future reference.
FlAv-r-SAvor
FSD and FSDT Series
I&W #07.05.005.00
®
No opere este equipo al menos que haya leído y
comprendido el contenido de este manual!
Cualquier falla en el seguimiento de las
instrucciones contenidas en este manual puede
resultar en un serio lesión o muerte. Este manual
contiene importante información sobre seguridad
concerniente al mantenimiento, uso y operación
de este producto. Si usted no puede entender el
contenido de este manual por favor pregunte a su
supervisor. Almacenar este manual en una
localización segura para la referencia futura.
© 2010 Hatco Corporation
Advertisement
Table of Contents
Related Manuals for Hatco FlAV-R-SAVOR FSD Series
Summary of Contents for Hatco FlAV-R-SAVOR FSD Series
- Page 1 Si usted no puede entender el contenido de este manual por favor pregunte a su attention of your supervisor. Keep this manual in supervisor. Almacenar este manual en una a safe location for future reference. localización segura para la referencia futura. © 2010 Hatco Corporation...
-
Page 2: Table Of Contents
Hours: Central Standard Time (C.S.T.) purchase date of the unit in the spaces below. Please have this (Summer Hours: June to September – information available when calling Hatco for service assistance. 8:00 to 5:00 C.S.T. Model No. ____________________________________... -
Page 3: Important Safety Information
This unit is for holding pre-heated food product only. waterproof. Do not operate if unit has been submerged Hatco is not responsible for the actual food product or saturated with water. serving temperature. It is the responsibility of the user to •... -
Page 4: Model Description
MoDEl DESCrIPTIoN All Models FSD-1X and FSDT-1X Models Flav-R-Savor Humidified Holding and Display Cabinets come The FSD-1X is a single door model with a stationary rack that ® in either brushed aluminum or painted Designer colors. All units holds five display trays. feature a digital temperature controller, air heating system, The FSDT-1X is a single door model with a stationary rack like fluorescent lamps, tempered glass side panels, and a tempered... -
Page 5: Specifications
NOTE: The specification label is located on the ceiling sheet CEE 7/7 Schuko AS-3112 inside the unit. See label for serial number and verification of unit electrical information. Figure 5. Plug Configurations NOTE: Receptacle not supplied by Hatco. Form No. FSDM-0810... -
Page 6: Electrical Rating Chart - Fsd Models
SPECIFICATIoNS Electrical rating Chart — FSD Models Model voltage Hertz Watts Amps Plug Configuration Shipping Weight FSD-1 1440 12.0 NEMA 5-15P 113 lbs. (51 kg) (with humidity) 50/60 1440 CEE 7/7 Schuko 113 lbs. (51 kg) 50/60 1440 BS 1363 113 lbs. - Page 7 SPECIFICATIoNS Electrical rating Chart — FSDT Models Model voltage Hertz Watts Amps Plug Configuration Shipping Weight FSDT-1 1440 12.0 NEMA 5-15P 120 lbs. (54 kg) (with humidity) 50/60 1440 CEE 7/7 Schuko 120 lbs. (54 kg) 50/60 1440 BS 1363 120 lbs.
-
Page 8: Installation
INSTAllATIoN General • Glass Side Panels — The cabinets have tempered glass side panels that are protected during shipping using Flav-R-Savor Humidified Holding and Display Cabinets are ® foam sheets along the glass edges and tape to hold the shipped with most components installed and ready for panels securely. -
Page 9: Reversing The Access Door
INSTAllATIoN reversing the Access Door 5. Remove the screws from the striker plates on the non-hinge side of the cabinet. Flav-R-Savor Humidified Holding and Display Cabinet access door(s) may be hinged on either the left or right side for 6. Install the striker plates on the opposite side of the cabinet convenience. -
Page 10: Relocating The Proximity Switch
INSTAllATIoN relocating the Proximity Switch 5. Remove the screw and nut from the new mounting hole. Secure the proximity switch to the mounting hole with the (rotating rack Models only—FSD-1, FSDT-1, screw and nut. Make sure to maintain proper switch FSD-2, FSDT-2) orientation when tightening the hardware. -
Page 11: Operation
oPErATIoN General *IMPORTANT NOTE* When using distilled water, add one teaspoon of salt to the Use the following procedures to operate the Flav-R-Savor ® water reservoir during the initial water fill only. This will ensure Humidified Holding and Display Cabinets. proper operation of the water level sensors. -
Page 12: Setting The Humidity Level
oPErATIoN Setting the Humidity level 4. After the desired humidity level is set, wait 15 seconds without pushing any keys for the CABINET TEMPERATURE 1. Press the HUMIDITy key to enter humidity mode (“hSP” will display to return automatically to operational mode. appear on the CABINET TEMPERATURE display). -
Page 13: Maintenance
Hatco equipment. Bottom This unit has no “user-serviceable” parts. If service is Point required on this unit, contact an Authorized Hatco Service Agent or contact the Hatco Service Department at 800-558-0607 or 414-671-6350; fax 800-690-2966; or International fax 414-671-3976. Figure 11. Removing Motorized Display Racks... -
Page 14: Draining The Water Reservoir
MAINTENANCE Draining the Water reservoir removing lime and Mineral Deposits The water reservoir in humidified units must be drained prior to Use the following procedure for periodic cleaning and de-liming moving the cabinet as well as during the “Removing Lime and of the water reservoir in humidified units. -
Page 15: Troubleshooting Guide
Contact an Authorized Hatco Service Agent or inside cabinet. Hatco for assistance. Incorrect voltage supplied to heating element. Contact an Authorized Hatco Service Agent or Hatco for assistance. Blower motor is not working. Contact an Authorized Hatco Service Agent or Hatco for assistance. -
Page 16: Options And Accessories
oPTIoNS AND ACCESSorIES 4″ (102 mm) Adjustable legs Merchandising Display Sign Holders The 4″ (102 mm) adjustable legs are used to add additional Merchandising Display Sign Holders are available in heights of height to the unit. 3-1/4″ (83 mm) and 7-1/2″ (191 mm). The sign holders include a metal holder and an acrylic window. - Page 17 oPTIoNS AND ACCESSorIES Display racks for FSD Display racks for FSDT Several display racks are available to “customize” FSD models Several display racks are available to “customize” FSDT to specific foodservice operations. models to specific foodservice operations. 4-Tier Circle Rack* 5-Tier Circle Rack* Rack Openings: Rack Openings:...
- Page 18 oPTIoNS AND ACCESSorIES Mechanical Thermostat Control Panel The Mechanical Thermostat Control Panel is an alternative to the digital control panel and features separate dials for controlling temperature and humidity. This is a factory-installed option and is not available for retrofit. HUMIDITY HUMIDITY CYCLE Indicator Control...
-
Page 19: Limited Warranty
Hatco’s written instructions or Without limiting the generality of the foregoing, SUCH 18 months from the date of shipment from Hatco. Buyer must WARRANTIES DO NOT COVER: Coated incandescent light establish the Product’s purchase date by returning Hatco’s... -
Page 20: Hatco Authorized Parts Distributors
HATCo AUTHorIzED PArTS DISTrIBUTorS AlABAMA IoWA NEW yorK TEXAS Jones McLeod Appl. Svc. Electric Motor Service Co. Acme American Repairs, Inc. GCS Service Birmingham 205-251-0159 Davenport 319-323-1823 Brooklyn 718-456-6544 Fort Worth 800-433-1804 Goodwin Tucker Group Alpro Service Co. Armstrong Repair Service...
Need help?
Do you have a question about the FlAV-R-SAVOR FSD Series and is the answer not in the manual?
Questions and answers