All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by CS 0770 BU CD Customer Service...
江南家电维修论坛会员专用! http://bbs.520101.com EN 2 TPT1.1HA LA Technical Specifications, Connections, and Chassis Overview 1. Technical Specifications, Connections, and Chassis Overview : (1920 × 1080)p, 2Fh Index of this chapter: : 640 × 480 @ 1.1 Technical Specifications Supported computer formats 1.2 Connections 60, 72, 75, 85 Hz : 800 ×...
Page 3
江南家电维修论坛会员专用! http://bbs.520101.com Technical Specifications, Connections, and Chassis Overview TPT1.1HA LA EN 3 AV3 HDMI: Digital Video - In, Digital Audio - In Monitor Out Mini Jack: Video CVBS - Out, Audio - Out - Audio R 0.5 VRMS / 10 kohm - Gnd CVBS - Video CVBS 1 VPP / 75 ohm...
Page 4
江南家电维修论坛会员专用! http://bbs.520101.com EN 4 TPT1.1HA LA Technical Specifications, Connections, and Chassis Overview Chassis Overview KEYBOARD CONTROL PANEL TV & SCALER BOARD DISPLAY SUPPLY PANEL i-BOARD KEYBOARD CONTROL PANEL SIDE I/O PANEL IR & LED PANEL H_17010_055.eps 200907 Figure 1-4 PWB / CBA locations...
• Be careful during measurements in the high voltage • Use only lead-free soldering tin Philips SAC305 with order section. code 0622 149 00106. If lead-free solder paste is required, • Never replace modules or other components while the unit please contact the manufacturer of your soldering is switched “on”.
2006 week 17). The 6 last digits contain the reduce heat. serial number. • Mix of lead-free soldering tin/parts with leaded soldering tin/parts is possible but PHILIPS recommends strongly to MADE IN BELGIUM MODEL 32PF9968/10 avoid mixed regimes. If this cannot be avoided, carefully 220-240V 50/60Hz clear the solder-joint from old tin and re-solder with new tin.
江南家电维修论坛会员专用! http://bbs.520101.com Mechanical Instructions TPT1.1HA LA EN 7 4. Mechanical Instructions Index of this chapter: 4.1 Cable Dressing Notes: 4.2 Service Positions • Figures below can deviate slightly from the actual situation, 4.3 Assy/Panel Removal due to the different set executions. 4.4 Set Re-assembly •...
Page 8
江南家电维修论坛会员专用! http://bbs.520101.com EN 8 TPT1.1HA LA Mechanical Instructions Assy/Panel Removal 4.3.3 IR and LED Panel removal Refer to figure “IR and LEDl Panel removal” for details. 4.3.1 Stand and Back Cover removal 1. Disconnect the connector [1] from the panel. 2.
Page 9
江南家电维修论坛会员专用! http://bbs.520101.com Mechanical Instructions TPT1.1HA LA EN 9 4.3.5 Keyboard Control Panel removal Refer to figure “Keyboard Control Panel removal” for details. 1. Disconnect the connector [1] from the panel. 2. Gently release the panel clips in the indicated direction. 3.
Page 10
江南家电维修论坛会员专用! http://bbs.520101.com EN 10 TPT1.1HA LA Mechanical Instructions 4.3.7 SSB and PSU cover removal Refer to figure “SSB and PSU Cover removal” for details. 1. Remove the fixation screws [1]. 2. Take of the cover. H_17010_101.eps 190907 Figure 4-9 SSB and PSU Cover removal...
Page 11
江南家电维修论坛会员专用! http://bbs.520101.com Mechanical Instructions TPT1.1HA LA EN 11 4.3.8 Subframe removal Refer to figure “Subframe removal” for details. 1. Unplug the LVDS connector [1]. Caution: be careful, as this is a very fragile connector! 2. Disconnect the connectors [2] from the panels and speakers.
Page 12
江南家电维修论坛会员专用! http://bbs.520101.com EN 12 TPT1.1HA LA Mechanical Instructions 4.3.9 PSU removal Refer to figure “PSU removal” for details. 1. Unplug the connectors [1]. 2. Remove the fixation screw [2] from the bottom side of the connector plate. 3. Remove the fixation screws [3]. 4.
Page 13
江南家电维修论坛会员专用! http://bbs.520101.com Mechanical Instructions TPT1.1HA LA EN 13 4.3.10 Small Signal Board (SSB) 1. Unplug the LVDS connector [1]. Caution: be careful, as this is a very fragile connector! 2. Unplug the connectors [2]. Caution: it is mandatory to remount all different screws at their 3.
Page 14
江南家电维修论坛会员专用! http://bbs.520101.com EN 14 TPT1.1HA LA Mechanical Instructions 4.3.11 LCD Panel Important: Be sure to work in a dust free environment during the following activities. In addition, the use of (fabric) hand gloves is advised. H_17010_007.eps 180907 Figure 4-13 LCD panel removal 1.
江南家电维修论坛会员专用! http://bbs.520101.com Service Modes, Error Codes, and Fault Finding TPT1.1HA LA EN 15 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: 2. Displays the production code. 5.1 Service Modes 3. Displays the software version in from the main processor 5.2 Repair Flow Chart 4.
Page 16
江南家电维修论坛会员专用! http://bbs.520101.com EN 16 TPT1.1HA LA Service Modes, Error Codes, and Fault Finding 5.1.4 Hotel Mode Before the hotel mode can be activated, the set needs to be switched into normal consumer mode first. Use an ITV setup remote control (type: RC2573/01, 12NC: 3139 228 88782) and key in the code “024995”...
Page 17
江南家电维修论坛会员专用! http://bbs.520101.com Service Modes, Error Codes, and Fault Finding TPT1.1HA LA EN 17 Repair Flow Chart 1.No work/LED is off Check if power switch is Replace Power switch normal Check IR board CN001 pin1=0V,pin2=3.7V, Check IR board pin3=3V,pin4=2.85V ,pin5=5V,pin6 =3.3V Check scaler board U102 pin1=14V,pin4=1.22V, pin7=16V,pin8=5V,...
Page 18
江南家电维修论坛会员专用! http://bbs.520101.com EN 18 TPT1.1HA LA Service Modes, Error Codes, and Fault Finding 2. No raster/picture too Check Inverter board Check Scaler board CN852,pin1=16V, pin5=0.9V,pin6 Check Inverter board Check U811,Q821 U811 pin2=5V,Q821 pin=5,6=16V Check scaler board H_17010_021.eps 180907 Figure 5-6 No Raster flowchart...
Page 19
江南家电维修论坛会员专用! http://bbs.520101.com Service Modes, Error Codes, and Fault Finding TPT1.1HA LA EN 19 3. No picture/LED is green Check scaler board U102 Check power pin1=14V,pin4=1.22V, pin7=16V,pin8 Check circuit around Check if each regulator and working voltage eliminate short and U152,pin2=3.3V open situation pin3=5V Check if clock...
Page 20
江南家电维修论坛会员专用! http://bbs.520101.com EN 20 TPT1.1HA LA Service Modes, Error Codes, and Fault Finding 4. No TV sound Check if tuner TU201 pin11 Replace TU201 output IF signal Check U301 5. No earphone sound Check Eliminate short and open U760 pin15=3.3V situation Check U760 pin20=HPOUTL...
Page 21
江南家电维修论坛会员专用! http://bbs.520101.com Service Modes, Error Codes, and Fault Finding TPT1.1HA LA EN 21 7. LED and function key poor Check circuit around control board and cable between control board and scaler board 8. No HDMI picture Change U701 writen Invalid Enter CSM mode HDCP KEY to check item 6...
Page 22
5.3.1 Compair Service Tool Introduction ComPair (Computer Aided Repair) is a Service tool for Philips Consumer Electronics products. and offers the following: 1. ComPair helps you to quickly get an understanding on how to repair the chassis in a short and effective way.
江南家电维修论坛会员专用! http://bbs.520101.com Block Diagrams, Test Point Overviews, and Waveforms TPT1.1HA LA 6. Block Diagrams, Test Point Overviews, and Waveforms Wiring Diagram H_17010_051.eps 190907...
江南家电维修论坛会员专用! http://bbs.520101.com Block Diagrams, Test Point Overviews, and Waveforms TPT1.1HA LA Waveforms TV & Scaler Board (Part 1) 3 C P U_RESE T (U4103 Pin 2) 4 E_ P AG E(U4101 Pin 7) 1 DDCW P _P C(U1102 Pin 7) 2 +5V_ T uner(U1201 Pin 3) 5 10MHz (X4101 Pin 1) 6 28.322MHz (X4201 Pin 1)
江南家电维修论坛会员专用! http://bbs.520101.com Alignments TPT1.1HA LA EN 61 8. Alignments Index of this chapter: correct x, y coordinates (see table “White D alignment values”). Tolerance: dx: ± 0.004, dy: ± 0.004. 8.1 General Alignment Conditions 8.2 Hardware Alignments • Repeat this step for the other colour Temperatures that 8.3 Software Alignments need to be aligned.
Page 62
江南家电维修论坛会员专用! http://bbs.520101.com EN 62 TPT1.1HA LA Alignments 8.4.2 Comp Mode Adjustment White-D adjustment General set-up:Equipment: Quantum Data Pattern Generator 801GD or 802G or 802R; Apply 1080i/50Hz and the pattern TVBAR100 is shown in figure 1.Alignment method:Initial Set-up: Set Smart picture as “Personal”...
(RS232 and RJ45 interface). CVBS and Y/C input, a TXT decoder, and a built-in dual 8/ Smart Box is the interface for a PHILIPS Smart Card (NEXT 10-bit LVDS transmitter. It uses Trident SVP-PX66 as scaler card, DVB-T card, etc.). It is an option item for the customer.
Page 64
江南家电维修论坛会员专用! http://bbs.520101.com EN 64 TPT1.1HA LA Circuit Descriptions, Abbreviation List, and IC Data Sheets H_17360_016.eps 060907 Figure 9-2 Scaler board (audio section) block diagram...
Committee LATAM LATin AMerica C-FRONT Chrominance front input LC04 Philips chassis name for LCD TV 2004 Circuit Board Assembly (or PWB) project Constant Level: audio output to Liquid Crystal Display connect with an external amplifier Light Emitting Diode...
Page 66
Sound right SCART2 out SNDS-VL-OUT Surround sound left variable level out SNDS-VR-OUT Surround sound right variable level out SOPS Self Oscillating Power Supply S/PDIF Sony Philips Digital InterFace SRAM Static RAM STBY Stand-by SVHS Super Video Home System Sub Woofer / SoftWare...
江南家电维修论坛会员专用! http://bbs.520101.com Circuit Descriptions, Abbreviation List, and IC Data Sheets TPT1.1HA LA EN 67 IC Data Sheets This section shows the internal block diagrams and pin layouts of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs). 9.4.1 Diagram B1A, CS4344/5/6/8 Block Diagram...
Page 68
江南家电维修论坛会员专用! http://bbs.520101.com EN 68 TPT1.1HA LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4.2 Diagram B2A, M16C/62P Block Diagram Port P0 Port P1 Port P2 Port P3 Port P4 Port P5 Port P6 <V ports> <V ports> Internal peripheral functions System clock generator A-D converter (10 bits...
Page 69
江南家电维修论坛会员专用! http://bbs.520101.com Circuit Descriptions, Abbreviation List, and IC Data Sheets TPT1.1HA LA EN 69 9.4.3 Diagram B3A, MSP 34x0G Block Diagram Pin Configuration H_17010_054.eps 190907 Figure 9-5 Internal block diagram and pin configuration...
Page 70
江南家电维修论坛会员专用! http://bbs.520101.com EN 70 TPT1.1HA LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.4.4 Diagram B4A, SSTP39VF088 Block Diagram SuperFlash X-Decoder Memory Memory Address Buffer & Latches Address Y-Decoder I/O Buffers and Data Latches Control Logic DQ 7 - DQ 0 Pin Configuration V SS Standard Pinout...
Page 71
江南家电维修论坛会员专用! http://bbs.520101.com Circuit Descriptions, Abbreviation List, and IC Data Sheets TPT1.1HA LA EN 71 9.4.5 Diagram B5A, SVP_PX66LX66 Block Diagram SVP™PX66 DDR/SDR 32 bit DDR 3 CVBS UMAC CRTC Noise Memory Control 2 Chroma Reduction 10bit Gama PCLK/H/V Panel PC RGB x 1 LCD Over 3D Video Timing...
江南家电维修论坛会员专用! http://bbs.520101.com Revision List TPT1.1HA LA EN 77 11. Revision List Manual xxxx xxx xxxx.0 • First release. Manual xxxx xxx xxxx.1 • Chapter 10: 32HF7445/97 spare parts added...