Reliance FXM920 Installation And Operating Instrucitons

Reliance FXM920 Installation And Operating Instrucitons

Low voltage control chair

Advertisement

Quick Links

INSTALLATION AND

OPERATING INSTRUCTIONS

OWNERS MANUAL
MODEL FXM920
LOW VOLTAGE CONTROL CHAIR

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the FXM920 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Reliance FXM920

  • Page 1: Operating Instructions

    INSTALLATION AND OPERATING INSTRUCTIONS OWNERS MANUAL MODEL FXM920 LOW VOLTAGE CONTROL CHAIR...
  • Page 2 For your future reference, mark the serial number in the space provided. QUALITY MANAGEMENT SYSTEM REGISTERED TO ISO 9001:2000 ISO 13485:2003 M ADE IN AME R I C A Reliance® Medical Products • 3535 Kings Mills Road • Mason, Ohio 45040-2303 • 1-800-735-0357 • www.reliance-medical.com...
  • Page 3: Table Of Contents

    Chair Top Assembly..........16 TECHNICAL SPECIFICATIONS........6 Chair Base Assembly..........20 2. INSTALLATION............7 Lift Assembly............22 2.1. Unpacking.............7 #26 Headrest Assembly........24 Chair..............7 Wiring Diagram - FXM920 .........28 2.2. Assembly............7 LIMITED WARRANTY..........31 Headrest...............7 Power Receptacle..........7 3. OPERATION............7 3.1. Stop Switch..........7 3.2. Chair Lift.............8 Raising & Lowering the Chair Lift with Membrane Switches..............8...
  • Page 4: Important Information

    Installation and Operating Instructions. condensation Storage: 10 to 100% “NOTE” Amplifi es a procedure, practice, or condition. Type B, Applied Part Dangerous Voltage / Shock Hazard Fuse Rating Specifi cation Protective Earth Ground Alternating Current-AC Safe Working Load “Attention, Consult Accompanying Documents” IN-FXM920...
  • Page 5: Introduction

    “NOTE”- Note indicates points of particular or additional information. 1.1. This manual contains information applicable only to the Reliance® Model FXM920 Chair. “NOTE” - la note indique des remarques d’information particulière ou supplémentaire. 1.2. Whenever you see the symbols shown below, heed their instructions! Always follow safe operating and maintenance practices.
  • Page 6: Technical Specifications

    POTENTIAL ELECTROMAGNETIC or OTHER This equipment is rated Class I, Type B INTERFERENCE Equipment Model Low Voltage Chair FXM920 This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in Volts Hertz Amps accordance with the instructions, may cause harmful...
  • Page 7: Installation

    Si cette présidence est achetée tipped from the skid onto the fl oor. conjointement avec un gabarit d’instrument de Reliance®, le câble de commande de présidence 2.1.1.4. Do not lift the chair by the upper structure. fourni fournira le fonctionnement approprié. Référez However, the chair may be tipped or slid into position by le manuel de gabarit d’instrument pour la connexion...
  • Page 8: Chair Lift

    NOTE: By design, the motion of the chair will STOP when either of the switches is released. NOTE: Par conception, le mouvement de la présidence S’ARRÊTERA quand l’un ou l’autre de ces contacts est relâché. IN-FXM920...
  • Page 9: Chair Top

    3.6.1. The footrest may be retracted by lifting near its outer edge. When retracted, the footrest stays in place. 3.7. Headrest 3.7.1. The No. 26 headrest is the standard headrest for the Model FXM920 Chair. WARNING- IF THE NO. 26 HEADREST RECEIVES A IMPACT OR STRIKES AN OBJECT WITH FORCE CONTACT RELIANCE®...
  • Page 10: Adjustment-No.26 Headrest

    If the dot does not fully clear the lock housing when the headrest is locked securely, turn the set screw located at the top of the lock housing (Figure 5, item 2) counterclockwise until the dot on the actuator is fully exposed. IN-FXM920...
  • Page 11: Fuse Replacement

    Remove the drawer by pulling it out with your fi ngers. 4.1.2. To remove fuses from fuse drawer, tilt fuses in direction of arrows as shown in Figure 6. Examine the fuses, replace as necessary. FIGURE 6 IN-FXM920...
  • Page 12: Troubleshooting Guide

    CHAIR BASE (UNDER SEAT BOARD.) CHAIR RECLINES WITHOUT 1) CONTROL CABLE OUT OF ADJUSTMENT 1) ADJUST CONTROL CABLE HANDLE BEING ACTIVATED. CHAIR WILL NOT RECLINE 1) CONTROL CABLE OUT OF ADJUSTMENT 1) ADJUST CONTROL CABLE WHEN HANDLE IS ACTIVATED. IN-FXM920...
  • Page 13: Cleaning And Maintenance

    fl ammable. Exercise proper care in cleaning and notify personnel in area of danger. Wear rubber gloves during all cleaning activity. Use caution in cleaning around buttons, stitching and wooden or other decorative trim, since these solvents could seriously damage such areas. IN-FXM920...
  • Page 14: Parts List

    Should your Control Chair not perform properly, or if replacement parts are needed, contact the Reliance® Distributor, where you purchased this product or contact the Technical Service Department, Reliance® Medical Products, Inc., 3535 Kings Mills Road, Mason, Ohio 45040-2303, or call (800) 735-0358.
  • Page 15: Model Fxm920 Chair Assembly

    Upholstered Center Assembly** 1761273 Upholstered Back Assembly** 1761373 Upholstered Arm Assembly** 1779273 Seat Board Assembly** 1765073 Scuff Pad** ** Please specify upholstery color when ordering. To order complete Upholstery Set use P/N. 1782073 Upholstery Set - FX920 - FXM920 IN-FXM920...
  • Page 16: Chair Top Assembly

    FIGURE 8 CHAIR TOP ASSEMBLY SEE DETAIL A IN-FXM920...
  • Page 17 DETAIL A Chair Top Assembly Parts List on pages 18 and 19 . IN-FXM920...
  • Page 18 Lock Block 1842692 Armrest Link Assembly - RH 1484095 Lock Shaft, Swivel 1842792 Armrest Link Assembly - LH 0563299 Linkage Hinge Pin 2260599 .50 ID Thrust Washer 0561799 Lock Cam 0732599 Retaining Ring 0643582 Lock Plug 1537699 Rotation Arm Pin IN-FXM920...
  • Page 19 1538199 Cable Clevis 0305599 1/4 Retaining Ring 0300199 8A Tinnerman Clip 1521399 Bolt, Shoulder 1/2 x 3/4 1529899 Control Cable Assembly 1518499 Lock Frame 1523399 Rocker 1520399 Lock Shaft 1529699 Lock Shoe Pin *Please specify paint color when ordering. IN-FXM920...
  • Page 20: Chair Base Assembly

    FIGURE 9 CHAIR BASE ASSEMBLY 3, 4 30, 17 30, 17 16, 17 35, 34 IN-FXM920...
  • Page 21 230V ne comprend pas une fi che. 2714292 Chair Base Assembly - Low - 120V* 2714392 Chair Base Assembly - High - 120V* 2714492 Chair Base Assembly - Low - 230V* 2714592 Chair Base Assembly - High - 230V* *Please specify paint color when ordering. IN-FXM920...
  • Page 22: Lift Assembly

    FIGURE 10 LIFT ASSEMBLY 33 & 37 IN-FXM920...
  • Page 23 Pin - Roll (in Item 12) 1060392 Tubing Assembly 0422899 Disc - Valve 1183592 Piston Rod - High 1183692 Piston Rod - Low To order complete Lift Assembly use P/N’s. 2721192 Lift Assembly - Low 2721292 Lift Assembly - High IN-FXM920...
  • Page 24: Headrest Assembly

    FIGURE 11 #26 HEADREST ASSEMBLY IN-FXM920...
  • Page 25 144060 #26 Headrest Assembly* 2721692 Middle Joint Screw Assembly Includes: Item’s 5, 6, 7 & 8. *Please specify paint color when ordering. 2721792 Bottom Joint Screw Assembly ** Please specify upholstery color when ordering. Includes: Item’s 5, 6, 8 & 18 IN-FXM920...
  • Page 26 (NOTES) IN-FXM920...
  • Page 27 (NOTES) IN-FXM920...
  • Page 28: Wiring Diagram - Fxm920

    FIGURE 12 WIRING DIAGRAM IN-FXM920...
  • Page 29 IN-FXM920...
  • Page 30 (NOTES)
  • Page 31: Limited Warranty

    3. The products have not sustained breakage or other type damage due to accident or misuse. 4. This warranty will not apply to Reliance® products which have had the serial number removed, altered or effaced.
  • Page 32 MADE IN AMERICA 3535 Kings Mills Road Mason, Ohio 45040-2303 1-800-735-0357(Customer Service) 1-800-735-0358 (Technical Service) (513) 398-3937 Http://www.reliance-medical.com P/N 27148 REV C © Copyright 2008 Printed in U.S.A. Revised 07-2010-7383...

Table of Contents