Page 1
CAUTION! PLEASE KEEP POWER SWITCH ON BEFORE OPERATING THIS EQUIPMENT Turbo Air Speed up the Pace of Innovation Underbar Equipment Service Manual Please read this manual completely before attempting to install or operate this equipment! BEER DISPENSERS TBD-1SD / TBD-2SD / TBD-3SD / TBD-4SD...
Page 22
Condenser Coil Fan Motor Assy Compressor Fan Control PCB Fan Motor Assy Compressor Condenser Coil Ballast Fan Control PCB...
Page 25
TBD + TCB Series Models. TBB Series Models.
Page 26
Fan output AC input AC input Compressor on/off signal...
Page 27
) h / TBB-2SB 896 BTU/h HBL27YE-1 3952127G10 1/4 HP 3.7A DAEWOO l a c ) h / TBD-2SD/SB, TCB-2SD/SB TBD-3SD/SB, TCB-3SD/SB 1,202 BTU/h (303 Kcal/h) TBD-4SD/SB, TCB-4SD/SB SK1A1C-L2W 30200Q1200 1/3 HP 4.0A SAMSUNG TBB-2SG, TBB-3SG TBB-4SG, TBB-4SB...
Page 28
TBB-1SB Below List IS-4420DWSG-1 3963320410 Aluminum 200mm SUNG-SHIN TBD-2SD/SB, TBD-3SD/SB, TBD-4SD/SB, TCB-2SD/SB, TCB-3SD/SB, TCB-4SD/SB TBB 2SB TBB 3SB TBB 4SB TBB 2SG TBB 3SG TBB 4SG TBB-2SB, TBB-3SB, TBB-4SB, TBB-2SG, TBB-3SG, TBB-4SG MODEL PART NAME SPEC PART NO. TBD-1SD/SB, TBD-2SD/SB...
Page 29
MODEL PART NAME PART NO. MAKER TBD-1SD/SB, TBB-1SB GNA-106D-01A 3028302400 TBB-4SG TBD-4SD/SB, TCB-4SD/SB GNA-240L-4 30283F0800 TBB-2SB, TBB-3SB, TBB-4SB SHIN-HAN TBD-2SD/SB, TBD-3SD/SB TCB-2SD/SB, TCB-3SD/SB GNA-242L 30283F1000 TBB-2SG, TBB-3SG WARM NORMAL COLD MODEL GNA-106D-01A -2.0 -5.0 -8.0 GNA-240L-4 10.0 -2.5 -7.0 -11.0...
TEMPERATURE CONTROL TEMPERATURE CONTROL (TBB-2SB, TBB-3SB, TBB-4SB (TBD-1SD/SB, TBB-1SB, TBB-4SG) TBB-2SG, TBB-3SG, TBB-4SG TBD-2SD/SB, TBD-3SD/SB, TBD-4SD/SB TCB-2SD/SB, TCB-3SD/SB, TCB-4SD/SB)
Page 34
7-1. REPLACING DOOR TCB-2SD/SB, TCB-3SD/SB, TCB-4SD/SB) SOLID DOOR MODEL TBB-1SB, TBB-2SB, TBB-3SB, TBB-4SB TBD-1SD/SB, TBD-2SD/SB, TBD-3SD/SB, TBD-4SD/SB A. Unscrew the screw top hinge assembly. B. Lift the door GLASS DOOR MODEL A. Unscrew the last screw with pushing the hinge .
7-2. REFRIGERATION COMPARTMENT PARTS A Disassemble Evaporator Housing A. Disassemble Evaporator Housing. B. Remove the front face of the Evaporator Housing. C. Unscrew the screws from the suction line cover(B) and remove it.
Page 36
D. Remove Evaporator Housing guide*L and Evaporator Housing guide*R by unscrewing the ten screws located at each side of the Evaporator. E. Refer to the figure of disassembled refrigeration compartments. s e i . s l s e i . s l F.
Page 37
G. Disconnect the connector from the lamp harness. H. Replacing the evaporator Fan Motor. Pull out the fan motor connector. s e i . s l s e i . s l Ⓑ Unscrew the four screws at the bottom of the fan motor. TBD + TCB Series Models.
Page 38
TBB Series Models. I. Remove the evaporator by unscrewing the five screws at each side of the evaporator.
Page 39
7-3. COMPRESSOR COMPARTMENT PARTS. A. Disassemble the Bottom Grille. (FRONT) (REAR) B. Unscrew the four screws at front and rear of the compressor base. C. Pull out of the condensing unit. D. The condensing unit as follows. s e i .