Electrolux ICON E30SO75ESS Technical & Service Manual page 48

Component Teardown
Door Adjustment
When removing and/or loosening the oven hinges such
as in door replacement, the following adjustment criteria
are taken.
Door adjustment is performed with the door properly
installed and closed and while the oven hinges are loose.
1. Loosen screws holding the oven hinge right and the
oven hinge left to the bottom plate with screwdriver.
2. Adjust door by moving it so that the door is parallel
with the oven cavity front plate lines (right and left
side lines) and the door latch heads pass through the
latch holes correctly.
3. Tighten the screws holding the oven hinge right and
the oven hinge left to the bottom plate.
After adjustment, make sure of the following:
1. The door latch heads smoothly catch the latch hooks
through latch holes and the latch heads goes through
center of latch holes.
2. The door is positioned with its face pressed toward
oven cavity front plate.
3. Reinstall outer case cabinet and check for microwave
leakage around the door with an approved microwave
survey meter. (Refer to Microwave Measurement
Procedure.)
The door on a microwave oven is designed to act
as an electronic seal preventing the leakage of
microwave energy from the oven cavity during the
cook cycle. This function does not require that the
door be airtight, moisture (condensation)-tight
or light-tight. Therefore, occasional appearance
of moisture, light or sensing of gentle warm air
movement around the oven door is not abnormal
and do not of themselves indicate a leakage of
microwave energy from the oven cavity. If such
were the case, the oven could not be equipped
with a vent, the very purpose of which is to exhaust
the vapor-laden air from the oven cavity.
Door Cam Left
Door Spring
Oven hinge
Left
Door
Assembly
Figure 4-5. Door Replacement and Adjustment
Left Door
Cam Pin
Door Cam Left
Oven Hinge
Left Door
Left
Hinge Pin
Figure 4-6. Door Assembly Components
4-10
Door Cam Right
Oven Hinge
Right
Door
Assembly
Right Door
Cam Pin
Door Cam Right
Oven Hinge
Right
Right Door
Hinge Pin
Door
Spring