Table Of Contents - Panasonic CU-3TZ52TBE Service Manual

TABLE OF CONTENTS

1. Safety Precautions ............................................. 3
2. Precaution for Using R32 Refrigerant .............. 6
3. Specifications ................................................... 10
3.1 CU-3TZ52TBE ............................................ 10
4. Dimensions ....................................................... 17
5. Refrigeration Cycle Diagram ........................... 18
6. Block Diagram .................................................. 19
7. Wiring Connection Diagram ............................ 20
8. Electronic Circuit Diagram .............................. 21
9. Printed Circuit Board ....................................... 22
9.1 Main Printed Circuit Board ......................... 22
9.2 Noise Filter Printed Circuit Board ............... 23
9.3 Display Printed Circuit Board ..................... 23
10. Installation Information .................................... 24
11. Installation Instruction ..................................... 25
11.1 Select The Best Location ........................... 25
11.2 Install The Outdoor Unit ............................. 26
11.3 Connect The Piping .................................... 26
11.4 Air Tightness Test on the Refrigerating
System ........................................................ 28
11.5 Connect The Cable To The Outdoor Unit .. 29
11.6 Heat Insulation ............................................ 31
11.7 Disposal of Outdoor Unit Drain Water ........ 31
12. Operation Control ............................................. 32
12.1 Cooling Operation ....................................... 32
12.2 Heating Operation ...................................... 33
12.3 Outdoor Quiet Cooling Operation Control .. 33
13. Simultaneous Operation Control .................... 35
14. Protection Control ............................................ 36
14.1 Freeze Prevention control (Cool) ............... 36
14.2 Dew Prevention control (Cool) ................... 36
14.3 Electronic Parts Temperature Rise
Protection 1 (Cool) ...................................... 36
14.4 Electronic Parts Temperature Rise
Protection 2 (Cool) ...................................... 36
14.5 Cooling overload control (Cool) .................. 37
14.6 Heating overload control (Heat) ................. 37
14.7 Extreme Low Temperature Compressor low
pressure protection control (Heat) .............. 37
14.8 Deice Control .............................................. 38
14.9 Time Delay Safety Control (Restart Control) ..
.................................................................... 38
14.10 30 seconds Force Operation ...................... 38
14.11 Total Current Control .................................. 38
14.12 IPM (power transistor) Protection Control .. 38

Specifications, designs and contents in this Service Manual are subject to change without notice.
PAGE
14.13 Compressor Protection Control (Gas leak
detection control 1) .....................................39
14.14 Compressor Protection Control (Gas leak
detection control 2) .....................................39
14.15 Valve close detection control ......................39
14.16 Compressor discharge high pressure
protection control ........................................39
14.17 Cooling Outdoor Air Temperature Control
(Cool) ..........................................................40
14.18 Heating Outdoor Air Temperature Control
(Heat) ..........................................................40
15. Servicing Mode .................................................41
15.1 Pump down operation (SW1) .....................41
15.2 Test Run Operation ....................................41
15.3 Wiring Error Check .....................................42
15.4 Power Save Mode ......................................42
15.5 Mode priority function .................................42
15.6 Cooling only operation ................................42
15.7 Heating only function ..................................42
16. Troubleshooting Guide ....................................43
16.1 Self Diagnosis Function ..............................43
17. Disassembly and Assembly Instructions ......46
17.1 Outdoor Unit Removal Procedure ..............46
18. Technical Data ..................................................49
18.1 Cool Mode Performance Data ....................49
18.2 Heat Mode Performance Data ....................61
19. Service Data ......................................................71
19.1 Operation Characteristics (CU-3TZ52TBE) ...
....................................................................71
20. Exploded View and Replacement Parts List ......
............................................................................83
2
PAGE