Dust Free Bio-Fighter VersaLight 1SVL14 Installation & Operation Manual

1s and 2s ultraviolet light systems

Advertisement

Quick Links

GENERAL
This product is designed to help disinfect the inter-
nal surfaces of heating, ventilation, and air condi-
tioning systems. Bacteria and viruses that are in
the air stream that passes through the system will
also be reduced. The result is an improved level of
indoor air quality for occupants and improved sys-
tem hygiene.
The Bio-Fighter® emits ultraviolet(UV-C) radiation
at a frequency of 254 nanometers, which has been
proven effective in damaging the DNA of microor-
ganisms such as viruses, bacteria, yeast and
molds. This process either destroys the micro-
organism or neutralizes its ability to reproduce.
©2015 Dust Free® • All rights reserved. • 212702-00 Rev. 4C 10/15
P/N
Model 1SVL14
#06151
Model 1SVL16
#06153
Model 1SVL20
#06155
Model 1SVL00
#06208
P/N
Model 2SVL14
#06152
Model 2SVL16
#06154
Model 2SVL20
#06156
Model 2SVL00
#06209
BIO-FIGHTER
VersaLight 1S and 2S
Ultraviolet Light Systems
Installation & Operation Manual

FEATURES

• Reduces or prevents mold growth on HVAC
coils, allowing them to operate at peak effi-
ciency. Also significantly reduces bacteria,
viruses, fungi, and yeasts in the ductwork.
• High output, long life UV-C lamps.
• Remote-mount lamp configuration.
• Multi-input voltage electronic ballast.
• Odor control (O3) lamps available.

INCLUDED INSIDE BOX

• Bio-Fighter® VersaLight UV-C system
• UV-C bulb(s)
(Not included on models 1SVL00, 2SVL00.)
• Power cord
• Viewport(s)
• Gasket(s)
• Sheet metal screws
• Installation & operation manual
• UV warning label for duct
• Registration card

TOOLS REQUIRED FOR INSTALLATION

• Electric drill
• Phillips screw bit or screwdriver
• 1/2" drill bit
• 1" drill bit or holecutter
• Eye protection

BEFORE INSTALLING

• Read all instructions carefully. Failure to do
so could damage the equipment or cause
harm to yourself or others.
• Acknowledge all warnings.
• Only qualified technicians should perform
the installation.
®

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Bio-Fighter VersaLight 1SVL14 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Dust Free Bio-Fighter VersaLight 1SVL14

  • Page 1 • Read all instructions carefully. Failure to do so could damage the equipment or cause harm to yourself or others. • Acknowledge all warnings. • Only qualified technicians should perform the installation. ©2015 Dust Free® • All rights reserved. • 212702-00 Rev. 4C 10/15...
  • Page 2 ETL LISTED CONFORMS TO UL STD 1598 CERTIFIED TO CSA STD C22.2 NO. 250.0 Important: The device must be installed in compliance with all national and local electrical and mechanical codes. Failure to do so will void Dust Free® warranty.
  • Page 3 HVAC system is configured such that the Any modification to the supplied power cord blower is located between the return air filter will void ETL safety listing and Dust Free® and the inlet side (return air side) of the coil, warranty. Accessory 240V power cord...
  • Page 4 BIO-FIGHTER® VERSALIGHT 1S, 2S INSTALLATION & OPERATION MANUAL INSTALLING THE LAMP REMOTE LAMP MOUNTING (Fig.2) (Fig.3) To maximize the efficiency and life of the UV-C Remove the remote lamp housing from the lamp, clean each lamp prior to installation. remote lamp base by removing the knurled nuts.
  • Page 5 BIO-FIGHTER® VERSALIGHT 1S, 2S INSTALLATION & OPERATION MANUAL CONNECTING THE HARNESS (Fig.5 ) Whip-type Power Cord Option With the lamp housing in place attach the con- nector to the lamp. Hold back the protective Connect green wire boot to expose the harness connector. The har- to ground.
  • Page 6 6. Unscrew the two knurled nuts of the lamp received your replacement lamps to: retaining bracket and slide the bracket away from the lamp retaining lip. Dust Free® Lamp Reclamation 1112 Industrial Drive 7. Carefully remove the UV-C lamp and Royse City, TX 75189 replace it with the new lamp.
  • Page 7 Bio-Fighter UV-C Light which is found to be defective within the param- eters defined herein. Dust Free LP reserves the right to replace or repair the defective part or component. DUST FREE LP SHALL NOT BE LIABLE FOR ANY LOSS OR DAMAGE OF ANY KIND, INCLUDING ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING, DIRECTLY OR INDIRECTLY, FROM ANY BREACH OF WARRANTY, EXPRESS OR IMPLIED, OR ANY OTHER FAILURE OF THIS PRODUCT.

This manual is also suitable for:

Bio-fighter versalight 1svl20Bio-fighter versalight 1svl16Bio-fighter versalight 1svl00Bio-fighter versalight 2svl14Bio-fighter versalight 2svl16Bio-fighter versalight 2svl00 ... Show all

Table of Contents