Scotsman HD22 User Manual page 11

11. Using the ice machine cleaning solution, cleanthe ice grill, sink, sweep arm and dispense wheel.Rinse these parts
with clean, fresh water.
12. To sanitize: Use a locally approved sanitizer. Apossible sanitizer: Mix a solution of ice machinesanitizer and
water: 30 Milliliters of household bleach to 7.6 Liters of (35oC.-46oC) water. Wash all interior surfaces, the sweep
arm andthe dispense wheel with the sanitizer solution Use a clean cloth.
13. Allow the parts to air dry.
14. Reassemble wheel and sweeparm onto drive shaft. Be sure toreinsert hairpin.
15. Replace all panels.16. Reconnect power, be sureice machine is switched back on.
Maintenance
Spilled ice and user debris will collect in the icecatch pan, located just below the sink grill.Occasionally the debris
will need to be removedand the drain flushed out to prevent water backups.Note: Failure to clean out the ice catch
pan willlikely result in a water leak, one that is NOTcovered by warranty.To clean out the ice catch pan:
1. Remove the front panel.
2. Disconnect electrical power.
3. Remove the two screws holding the top panel tothe dispenser. Lift the top panel up and off thedispenser.
4. Pull the top edge of the front panel forward untilthe two snaps disengage.If the unit is a coin op model, reach
behind thefront panel and disconnect the coin mechanismharness from the front panel.If the unit is a water station
model, reach behindthe front panel and shut off the water supply valveto the water faucet. Then disconnect the water
linefrom the shut off valve.
5. Lift the front panel up and off the base.
6. Pull the ice catch pan forward a few inches untilthe drain hose can be reached.
7. Pull the drain hose from the ice catch pan.
8. Slide the ice catch pan out of the ice dispenserand clear it of any debris. Wash out the drain.
9. Return the ice catch pan to
its normal position.
10. Re-attach the drain hose
10