Advertisement
Quick Links
®
HYFIRE
1
HYFIRE
V Ignition Control
®
4
#10 Sheet Metal Screws
2
Wire Ties
2
Ring Terminals, Insulated
1
1-amp/100 volt Diode
2
1/4" Tab Terminals
®
®
®
MALLORY TECHNICAL SUPPORT
INSTALLATION INSTRUCTIONS
®
IGNITION CONTROL
PART NO. 585
®
®
®
®
®
(775) 882-6600
V
ELECTRONIC
5
1/4" Male Disconnects
5
1/4" Female Disconnects
1
Rubber Grommet
2
Cable Clamps
1
Magnetic Pickup Extension
®
tech@mrgasket.com
FORM 1051 (REV. A) 10/01
®
®
1
Advertisement
Related Manuals for Mallory HYFIRE V
Summary of Contents for Mallory HYFIRE V
- Page 1 #10 Sheet Metal Screws 1/4" Female Disconnects Wire Ties Rubber Grommet Ring Terminals, Insulated Cable Clamps 1-amp/100 volt Diode Magnetic Pickup Extension 1/4" Tab Terminals ® ® ® ® ® ® ® ® ® ® ® MALLORY TECHNICAL SUPPORT (775) 882-6600 tech@mrgasket.com...
- Page 2 ® ® ® Heavy Red ® Heavy Black ® Small Red Orange ® Small Black ® ® Trigger Wires ® White ® Violet/Green ® Yellow FIGURE 1 DIAGNOSTIC ® MALLORY IGNITION 550 MALLORY WAY, CARSON CITY, NV 89701...
- Page 3 ® ® COMMON COLORS FOR MAG PICKUP WIRES Distributor Mag + Mag – Mallory Crank Trigger Purple Green Mallory Billet Competition Distributor, Series Nos. 81 and 84 Orange Purple Mallory COMP 9000 Series Nos. 96-99 Orange Purple ® Mallory Harness P/N 29040 Black ®...
- Page 4 1A-100V DIODE SPLICE HERE FIGURE 5A SPLICE HERE DELCOTRON ALTERNATOR TO CHARGING LIGHT ® 1A-100V DIODE ® HYFIRE V SMALL RED SWITCHED 12V TO ENGINE/CHASSIS GROUND FIGURE 5B CHRYSLER DUAL BALLAST RESISTOR MALLORY IGNITION 550 MALLORY WAY, CARSON CITY, NV 89701...
- Page 5 ® ® ® ® ® FIGURE 6 FIGURE 7 WHITE WIRE GREEN JUMPER WIRE TO GROUND VIOLET ® MALLORY TECHNICAL SUPPORT (775) 882-6600 tech@mrgasket.com...
- Page 6 MICROPROCESSOR CONTROLLED IGNITION SYSTEM PURPLE NOT USED GREEN SHRINK TUBING RED (LARGE 14 GA) TO BATTERY POS (+) BLACK (LARGE 14 GA) TO BATTERY NEG (–) YELLOW TO TACHOMETER ORANGE COIL – BLACK (SMALLER) MALLORY IGNITION 550 MALLORY WAY, CARSON CITY, NV 89701...
- Page 7 ® MICROPROCESSOR CONTROLLED IGNITION SYSTEM MICROPROCESSOR CONTROLLED IGNITION SYSTEM WHITE NOT USED YELLOW TO TACHOMETER ORANGE COIL – BLACK (SMALLER) FIGURE 12 ® SHRINK TUBING PART OF MALLORY HEI KIT P/N 29008 (NOT INCLUDED) MALLORY TECHNICAL SUPPORT (775) 882-6600 tech@mrgasket.com...
- Page 8 NOT USED PURPLE YELLOW TO TACHOMETER TO ENGINE C– GRD B+ GROUND TACH BLACK (SMALL 18 GA TO C–) ORANGE (TO B+) PART OF MALLORY HEI KIT P/N 29008 (NOT INCLUDED) MALLORY IGNITION 550 MALLORY WAY, CARSON CITY, NV 89701...
- Page 9 NOT USED (TAPE END) JUMPER PART No. 585 WHITE JUMPER WHITE ® MICROPROCESSOR CONTROLLED IGNITION SYSTEM RED (SMALL 18 GA) PART OF MALLORY HEI KIT P/N 29008 (NOT INCLUDED) BLACK ORANGE SHRING TUBING (SMALL 18 GA) RED (LARGE 14 GA)
- Page 10 FACTORY HARNESS PLUG BLACK (LARGE 14 GA) TO BATTERY NEG (–) (ORIGINALLY CONNECTED TO THE COIL) TO BATTERY POS (+) RED (LARGE 14 GA) PURPLE MAGNETIC PICK-UP (NOT USED) GREEN IGNITION COIL MALLORY IGNITION 550 MALLORY WAY, CARSON CITY, NV 89701...
- Page 11 RED (LARGE 14 GA) TO BATTERY POS (+) BLACK (LARGE 14 GA) TO BATTERY NEG (–) GREEN MAGNETIC PICKUP NOT USED STOCK PURPLE IGNITION COIL GREEN/ORANGE ORANGE BLACK/GRAY OR GRAY BLACK (SMALL 18 GA) MALLORY TECHNICAL SUPPORT (775) 882-6600 tech@mrgasket.com...
- Page 12 BLACK (LARGE 14 GA) TO BATTERY NEG (–) GREEN MAGNETIC PICKUP NOT USED PURPLE MALLORY IS A DIVISION OF THE MR. GASKET PERFORMANCE GROUP FORM 1051 550 MALLORY WAY, CARSON CITY, NEVADA 89701 (REV. A) 10/01 (775) 882-6600 FAX (775) 887-4326 Made in U.S.A.
Need help?
Do you have a question about the HYFIRE V and is the answer not in the manual?
Questions and answers