Troubleshooting - Weed Eater TE 400 CXL Operator's Manual

TROUBLESHOOTING TABLE
WARNING:
Always stop unit and disconnect spark plug before performing any of the
recommended remedies below other than remedies that require operation of the unit.
TROUBLE CAUSE
Engine will not S Engine flooded.
S Fuel tank empty.
start.
S Spark plug not firing.
S Fuel not reaching carburetor.
S Carburetor requires adjustment.
Engine will not S Carburetor requires adjustment.
S Throttle trigger screw too
idle properly.
tight.
Engine will not
S Air filter dirty.
accelerate, S Spark plug fouled.
S Carburetor requires adjustment.
lacks power,
or dies under
a load.
Engine S Fuel mixture incorrect.
smokes
S Air filter dirty.
excessively.
S Carburetor requires adjustment.
Line does not S Line improperly routed in head.
S Line improperly routed through
advance or
line guide.
breaks while
S Line size incorrect.
cutting.
Line welds S Line size incorrect.
S Incorrect spool.
onto spool.
S Line is being crowded against
material being cut.
Line pulls
S Too little line outside of head.
back into
S Line size incorrect.
head.
LIMITED WARRANTY
ELECTROLUX HOME PRODUCTS NORTH
AMERICA, Division of WCI Outdoor Prod-
ucts, Inc. warrants to the original purchaser that
each new Weed Eater brand gasoline tool or at-
tachment is free from defects in material and
workmanship and agrees to repair or replace
under this warranty any defective gasoline prod-
uct or attachment as follows from the original
date of purchase.
2 YEARS- - Parts and Labor, when used for
household purposes.
90 DAYS - - Parts and Labor, when used for
commercial, professional, or income producing
purposes.
30 DAYS - - Parts and Labor, if used for rental
purposes.
This warranty is not transferable and does not
cover damage or liability caused by improper
handling, improper maintenance, or the use of
accessories and/or attachments not specifically
recommended by ELECTROLUX HOME
PRODUCTS NORTH AMERICA for this tool.
Additionally, this warranty does not cover tune-
ups, spark plugs, filters, starter ropes, starter
springs, cutting line, or rotating head parts that
REMEDY
S See "Starting."
S Fill tank with correct fuel mixture.
S Install new spark plug.
S Check for dirty fuel filter; replace.
Check for kinked or split fuel line;
repair or replace.
S See "Carburetor Adjustments."
S See "Carburetor Adjustments."
S Loosen screw.
S Clean or replace air filter.
S Clean or replace spark plug; re-gap.
S See "Carburetor Adjustments."
S Empty fuel tank and refill with
correct fuel mixture.
S Clean or replace air filter.
S See "Carburetor Adjustments."
S Check line routing.
S See "Replacing the line."
S Use only 0.080" (2 mm) dia. line.
S Use only 0.080" (2 mm) dia. line.
S Replace with correct spool.
S Cut with tip of line fully extended.
S Remove spool and pull 4 -- 6 inches
(10 -- 15 cm) of line outside of head.
S Use only 0.080" (2 mm) dia. line.
will wear and require replacement with reason-
able use during the warranty period. This war-
ranty does not cover predelivery setup or nor-
mal adjustments explained in the operator's
manual.
THIS WARRANTY GIVES YOU SPECIFIC
LEGAL RIGHTS, AND YOU MAY HAVE
OTHER RIGHTS WHICH VARY FROM
STATE TO STATE.
NO CLAIMS FOR CONSEQUENTIAL OR
OTHER DAMAGES WILL BE ALLOWED,
AND THERE ARE NO OTHER EXPRESS
WARRANTIES EXCEPT
PRESSLY STIPULATED HEREIN.
SOME STATES DO NOT ALLOW LIMITA-
TIONS ON HOW LONG AN IMPLIED WAR-
RANTY LASTS OR THE EXCLUSION OR
LIMITATIONS OF INCIDENTAL OR CONSE-
QUENTIAL DAMAGES, SO THE ABOVE
LIMITATIONS OR EXCLUSION MAY NOT
APPLY TO YOU.
ELECTROLUX HOME PRODUCTS NORTH
AMERICA'S policy is to continuously improve
its products. Therefore, ELECTROLUX HOME
PRODUCTS NORTH AMERICA reserves the
right to change, modify, or discontinue models,
designs, specifications, and accessories of all
products at any time without notice or obligation
to any purchaser.
6
THOSE EX-