Table of Contents
Related Manuals for HiDew DCS 040
Summary of Contents for HiDew DCS 040
- Page 1 w w w . h i d e w . i t i n f o @ h i d e w . i t Dehumidifier for small swimming pools – for direct on wall installation – for ducted installation I N S T A L L A T I O N , U S E A N D M A I N T E N A N C E M A N U A L P R E L I M I N A R Y...
- Page 2 WIRING DIAGRAM Following the law no parts of this manual can be reproduced with electrical, mechanical or other systems and/or spread without written permission of the producer HiDew S.r.l. 2 - 48 rev00 – Installation, use and maintenance manual...
- Page 3 Technical support Service, to assist you and supply the spare parts. For a quicker assistance, please contact us at the following references: HIDEW s.r.l. info@hidew.it - www.hidew.it Operations: Via dell’artigianato, 1 - 35020 - San Pietro Viminario (PD) - Italy...
-
Page 4: Table Of Contents
DDS-DCS – Dehumidifier for small swimming pools SUMMARY INTRODUCTION ..............................5 RESPONSABILITITIES ..............................6 SERVICE RULES ................................6 USES ....................................7 RESIDUAL RISK AREAS..............................7 INTERVENTION AND MAINTENANCE ........................8 GENERAL SAFETY RULES ............................. 9 PRODUCT DESCRIPTION ..........................10 COMPONENTS ................................10 SERIES .................................... -
Page 5: Introduction
DDS-DCS – Dehumidifiers for small swimming pools INTRODUCTION The present User Manual indicates the uses of the unit and gives instructions for transport, installation, assembling and regulation of the machine. It gives directions about maintenance, spare parts request, residual risks presence and staff education. The User Manual should be read and used in the following way: - each operator and person concerned with the use and maintenance of the unit should read it carefully and follow the instructions given;... -
Page 6: Responsabilitities
DDS-DCS – Dehumidifier for small swimming pools RESPONSABILITITIES The unit is granted according to the contract clauses subscribed in the sales negotiation. The manufacturer is not responsible for accidents that can occur because of: - the non-following of the instructions given in this manual about the correct use, maintenance and first-starting of the machine;... -
Page 7: Uses
DDS-DCS – Dehumidifiers for small swimming pools USES DDS – DCS units are dehumidifiers for small swimming pools, thought for all the environments where the non-control of the humidity may cause damages to the structure. Its use is recommended within the functioning limitations indicated in this manual. Place the unit where there are not explosion or fire dangers, neither in vibrating areas or in presence of electro-magnetical fields. -
Page 8: Intervention And Maintenance
DDS-DCS – Dehumidifier for small swimming pools INTERVENTION AND MAINTENANCE It is useful to remember that the manual can not substitute the suitable experience of the user; for some maintenance operations, the manual represents a reminder of the main activities for competent operators, who have attended, for instance, instructive courses promoted by the manufacturer. -
Page 9: General Safety Rules
DDS-DCS – Dehumidifiers for small swimming pools GENERAL SAFETY RULES 1.6.1 SAFETY CLOTHES Operators should wear safety equipment such as gauntlet, helmet, safety glasses, safety footwear and cap for protection from the noise. 1.6.2 FIRE EXTINGUISHER AND FIRST AID Place a first aid box and a fire extinguisher near the unit. Check regularly that fire extinguishers are charge and that you have understood how to use them. -
Page 10: Product Description
A long list of accessories allows meeting any type of requirement and, in the event that the standard range and available accessories are not enough to meet these demands, HiDew can offer specific solutions to the Customer. DDS and DCS series is composed by 10 models according to the air flow rate (from 350 up to 1500 m³/h) and to the capacity of dehumidification (from 46 up to 226 L/day). -
Page 11: Series
DDS-DCS – Dehumidifiers for small swimming pools 2.1.3 VENTILATION For the ventilation, centrifugal at double suctions, 7-speeds (3-speeds for models 210 – 230) with plastic fan (excluded models 210 -230) for a major resistance to the corrosion and a sensible reduction of the sound level emitted, for a major comfort. -
Page 12: Standard And Advanced Controls' Functions
DDS-DCS – Dehumidifier for small swimming pools Standard and Advanced Controls’ functions DDS and DCS range units are supplied with a control that manages the basic functions of the dehumidifier, such as dehumidification, heating, alarms, defrost cycles and duration of these. DDS and DCS units only need the closing of a clean contact coming from an hygrostat which can be mounted on board or at distance, on the wall. -
Page 13: Opzioni Disponibili
/ options easy to manage thanks to an intuitive and complete interface. The management software is totally developed in HiDew by high-qualified technician. The display can be put at a distance up to 20 meters and, thanks to the temperature and humidity probe mounted on board, can manage temperature, humidity and time-bands on/off of the unit. - Page 14 DDS-DCS – Dehumidifier for small swimming pools 2.5.5 ELECTRICAL HEATER Single-step electrical heaters allow the heating of supply air when there is no hot water available. The safety is granted by a thermostat that, in case of overheating, turns off the heaters and signals the alarm. The contemporaneity of the 3-ways valve and electrical heaters is possible only if combined with the Advanced control (excluded models 040 –...
-
Page 15: Dimensions
DDS-DCS – Dehumidifiers for small swimming pools DIMENSIONS Model 850 x 780 x 280 1050 x 780 x 280 Dimensions L x H x P 802 x 763 x 257 1002 x 763 x 257 Dimensions L x H x P Model 1350 x 850 x 330 1550 x 850 x 330... -
Page 16: Installation
DDS-DCS – Dehumidifier for small swimming pools INSTALLATION DDS models are conceived for a direct installation in the ambience to dehumidify. DCS models are conceived for a ducted installation in a technical adjacent room, thus are supplied without the front cover (see dimensional drawings on page 7). -
Page 17: Advanced Control
DDS-DCS – Dehumidifiers for small swimming pools ADVANCED CONTROL The Advanced Control is composed by a power board and an elegant display which allows to command the unit and to modify all the different functions. Here below there are the functions of the different keys and all the screens: KEYS ON-OFF KEY - on the main screen it allows the turning off of the unit... -
Page 18: Main Screen
DDS-DCS – Dehumidifier for small swimming pools MAIN SCREEN KEYS USE: - With the OFF key, you turn off the unit - Keeping pressed the EXIT key, you display the software version - With the MENU key, you enter the user menu the rectangle on the left indicated the current day on the right is indicated the current time in the middle are indicated the current values of temperature and humidity... - Page 19 DDS-DCS – Dehumidifiers for small swimming pools Now we see in detail the possible screens of the ‘user menu’: On the left you find the screen 1 of the user menu, which allows to set the functioning of the unit: MANUAL or on TIME BANDS (this screen does not appear if: the unit is managed from a serial modbus) press OK to enter in the modification phase press UP and DOWN to modify and with OK you confirm and exit from the modification phase...
- Page 20 DDS-DCS – Dehumidifier for small swimming pools On the left you find the screen 6 of the user menu, which allows the setting of the language press OK to enter the modification phase press UP and DOWN to modify and with OK you confirm and exit from the modification phase press EXIT to exit and come back to the main screen press UP to come back to the previous screen press DOWN to go to the following screen...
-
Page 21: Alarms Menu
DDS-DCS – Dehumidifiers for small swimming pools ALARMS MENU This menu is accessible only if there is an alarm on the unit and it allows to display the active alarm and, if possible, to reset it. On the left you see the screen which allows to chose whether to display the alarm or to reset it. press EXIT to exit and come back to tha main screen press UP and DOWN to select what to do press OK to confirm the choice and to shift to the further screen... -
Page 22: Time-Bands Menu
DDS-DCS – Dehumidifier for small swimming pools TIME-BANDS MENU You can access this menu only if the unit is set in time-bands and it allows to program the bands which manage the on/off, the humidity and the temperature. It is fundamental to set the current date and time, go to the screen 7 of the User Menu (additional information in the previous chapters). -
Page 23: Other Screens
DDS-DCS – Dehumidifiers for small swimming pools 3.6.2 UIDE Selecting this guide, you have access to 5 screens which explain how to realize the time bands. KEYS USE: - Pressing UP and DOWN you move from a screen to another - Pressing EXIT you come back to the main screen 3.6.3 EFAULT... -
Page 24: Technical Data
DDS-DCS – Dehumidifier for small swimming pools TECHNICAL DATA TECHNICAL DATA TABLES Model Dehumidifying capacity 30° - 80% R.H. L/day Dehumidifying capacity 30° - 60% R.H. L/day Dehumidifying capacity 27° - 60% R.H. L/day Dehumidifying capacity 20° - 60% R.H. L/day Nominal air flow m3/h... - Page 25 DDS-DCS – Dehumidifiers for small swimming pools Model Dehumidifying capacity 30° - 80% R.H. L/day Dehumidifying capacity 30° - 60% R.H. L/day Dehumidifying capacity 27° - 60% R.H. L/day Dehumidifying capacity 20° - 60% R.H. L/day Nominal air flow m3/h 1000 1200 1500...
-
Page 26: Functional Diagram
DDS-DCS – Dehumidifier for small swimming pools FUNCTIONAL DIAGRAM compressor high pressure manostat condensing coil fde-hydrator filter flux light electro-valve thermal expansion valve (or similar) evaporative coil low pressure probe post-heating water coil [optional] 3-ways water valve [optional] 26 - 48 rev00 –... -
Page 27: After Sales
DDS-DCS – Dehumidifiers for small swimming pools AFTER SALES FAILURES In the following pages you find the more frequent possible causes of block or dysfunction of the unit. The classification is made on easy-to-identify signs. When executing the operations suggested to solve the problem, be careful: an excessive self- confiance can be dangerous. -
Page 28: Periodical Maintenance
DDS-DCS – Dehumidifier for small swimming pools PERIODICAL MAINTENANCE The manufacturer recommends that the periodical maintenance is done every three months. 5.2.1 LEANING UBSTITUTION OF THE AIR FILTER Without removing any panel, incline the filter towards low, remove and wash it under current water; remove with hands eventual impurities without damaging it. - Page 29 DDS-DCS – Dehumidifiers for small swimming pools 5.3.2 AINTENANCE ABLE To grant the performance of the unit, it is strongly suggested to make reference to the following table for maintenance done and to be done. 4° quarter 3° quarter 2° quarter 1°...
-
Page 30: Dismantling Of The Unit
DDS-DCS – Dehumidifier for small swimming pools DISMANTLING OF THE UNIT When dismantling the unit, please take note of the following advices: - the refrigerant gas should be recovered from qualified staff and sent to the proper collection centers; - the compressors lubricating oil should be recovered and sent to the proper collection centers; - the structure and the components, if no more usable, should be demolished and divided according to their material: this is particularly true for copper and aluminium. -
Page 31: Installation
DDS-DCS – Dehumidifiers for small swimming pools INSTALLATION INTRODUCTION 7.1.1 NSPECTION When receiving the unit, please check it: the unit has left our factory after having been controlled; damages should be immediately protested to the forwarder and noted on the Delivery Paper before signing it. The manufacturer or his agent should be informed as soon as possible about the entity of the damage. -
Page 32: Positioning
DDS-DCS – Dehumidifier for small swimming pools POSITIONING All DDS - DCS models are projected and built for internal installation. Do not install the unit external and make sure it is not exposed to atmospheric agents such as rain, hail, humidity and frost. Please keep attention to the following advices when deciding the most suitable place for the installation of the unit and its connections: - hydraulic pipes dimensions and origin;... - Page 33 DDS-DCS – Dehumidifiers for small swimming pools 7.2.1 DIMENSIONS AND REQUIRED DISTANCE - DDS FRAME 1 7.2.2 DIMENSIONS AND REQUIRED DISTANCE - DDS FRAME 2 33 - 48 Installation, use and maintenance manual – rev00...
- Page 34 DDS-DCS – Dehumidifier for small swimming pools 7.2.3 DIMENSIONS AND REQUIRED DISTANCE - DDS FRAME 3 7.2.4 DIMENSIONS AND REQUIRED DISTANCE - DDS FRAME 4 34 - 48 rev00 – Installation, use and maintenance manual...
- Page 35 DDS-DCS – Dehumidifiers for small swimming pools 7.2.5 DIMENSIONS AND REQUIRED DISTANCE - DCS FRAME 1 7.2.6 DIMENSIONS AND REQUIRED DISTANCE - DCS FRAME 2 35 - 48 Installation, use and maintenance manual – rev00...
- Page 36 DDS-DCS – Dehumidifier for small swimming pools 7.2.7 DIMENSIONS AND REQUIRED DISTANCE - DCS FRAME 3 7.2.8 DIMENSIONS AND REQUIRED DISTANCE - DCS FRAME 4 36 - 48 rev00 – Installation, use and maintenance manual...
-
Page 37: Hydraulic And Electrical Connections
DDS-DCS – Dehumidifiers for small swimming pools HYDRAULIC AND ELECTRICAL CONNECTIONS 7.3.1 YDRAULIC ONNECTIONS When preparing the hydraulic connection, it is compulsory to follow the indications below and to follow the National dispositions. Do not twist the unit connections. With a key, block the connection and, with another key, fix the connecter. - Page 38 DDS-DCS – Dehumidifier for small swimming pools 7.3.3 LECTRICAL ONNECTION Open the electrical panel, introduce the supplying cable and the others according to the hole, connect them to the clamps and on the disconnecting switch, close the panel. The grounding connection is compulsory. The installer should connect the ground cable with the suitable clamp situated within the electrical panel, with a yellow-green indication.
- Page 39 DDS-DCS – Dehumidifiers for small swimming pools 7.3.5 TERMINAL BOARD AND WIRING DISPOSITION MORSETTIERE 39 - 48 Installation, use and maintenance manual – rev00...
- Page 40 DDS-DCS – Dehumidifier for small swimming pools CLAMPING BOX 6 POLES + PE Clamps N - L - PE are for the supplying: connect the neutral on N, the phase on L and the PE on the opposite. CLAMPING BOX 10 POLES Clamps 101 - 102 are for the signal of alarms in the unit;...
-
Page 41: First Starting
DDS-DCS – Dehumidifiers for small swimming pools FIRST STARTING First starting, calibration and configuration of the unit should be done only by qualified staff. DO NOT IMPROVISE, UNIT DISFUNCTION DANGER! Before proceeding with the start of the unit, check that all the closing panels are placed correctly and closed properly. For the first start follow carefully these directions: Check that all the connections (hydraulic, electric and aeraulic) are properly installed and that all the directions indicated on labels, user manual and electric drawing are followed. - Page 42 DDS-DCS – Dehumidifier for small swimming pools 7.4.1 INSTALLER’S PARAMETERS MODIFICATION Installer’s parameters allow the advanced setting of the unit. Some parameters regard important modifications to the unit. MODIFY ONLY IF NECESSARY To enter the installer menu, follow this process: Go to the main screen pressing EXIT if necessary Press MENU to enter the first screen of the user menu Press DOWN up to the last screen (screen 9)
- Page 43 DDS-DCS – Dehumidifiers for small swimming pools Now we see in detail the different screen of the installer menu: On the left you see the screen 1 of installer menu, which allows to modify the fan speed in the functioning phases: 1.
- Page 44 DDS-DCS – Dehumidifier for small swimming pools On the left you see the screen 7 of the installer menu, which allows o activate the contact for the on/off of the heating and, if necessary, to invert the functioning logic This screen is present only if the modbus communication is not active and if the option hot water coil with valve or the option electrical heater has been bought.
-
Page 45: Additional Notes
DDS-DCS – Dehumidifiers for small swimming pools ADDITIONAL NOTES ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… 45 - 48 Installation, use and maintenance manual – rev00... - Page 46 ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ……………………………………………………………………………………………………………………………………………………………………………………………………………… ………………………………………………………………………………………………………………………………………………………………………………………………………………...
- Page 47 DDS-DCS – Dehumidifiers for small swimming pools 47 - 48 Installation, use and maintenance manual – rev00...
- Page 48 DDS-DCS – Dehumidifier for small swimming pools HIDEW s.r.l. info@hidew.it - www.hidew.it Operations: Via dell’artigianato 1 - 35020 - San Pietro Viminario (PD) – Italy Tel +39 049/9588510 Legal Office: Viale Spagna, 31/33 - 35020 - Tribano (PD) - Italy...
Need help?
Do you have a question about the DCS 040 and is the answer not in the manual?
Questions and answers