NSS WARHORSE Operation Manual

IMPORTANT SAFETY INSTRUCTIONS

WARNING: Failure to observe these instructions can cause
personal injury to machine operator or bystanders.
WARNING: Asphyxiation Hazard. An
improperly maintained engine can produce
excessive levels of carbon monoxide.
Excessive levels of carbon monoxide can
make you sick or cause death. NEVER
operate machine in an area less than 5,000
square feet for more than 15 minutes unless
there is adequate ventilation.
INTENDED USE
This machine is intended for commercial use,
burnishing floors in an indoor, well-ventilated
environment. NSS does not recommend using this
machine for any other purpose.
FOR SAFETY:
• ALWAYS read and understand all instructions before
operating or servicing machine.
• ALWAYS use this machine ONLY as described in this
manual.
• NEVER attempt to operate this machine unless you
have been trained in its operation.
• NEVER allow an untrained person to operate machine.
• NEVER attempt to operate this machine if it is not
working properly or has been damaged in any manner.
• NEVER let go of the handles when the machine is
operating.
• NEVER disconnect or modify any switches or safety
devices.
• NEVER service machine near fire or flame.
• NEVER operate this machine with any air opening
blocked. Keep all air openings free of dust, lint, hair, etc.
• NEVER allow this machine to be used as a toy. Close
attention is necessary when used by or near children.
• ALWAYS keep face, fingers, hair or any other body
part or loose clothing away from any machine
opening or moving part (revolving pad & pad driver).
• ALWAYS use extreme caution when operating the
machine on a ramp or loading/unloading this machine
into or out of a truck/trailer. Use extreme caution if the
ramp is wet, oily, or covered with cleaning chemicals.
• ALWAYS turn the machine off when attaching pads.
• ALWAYS be sure that the ramp is secured to the
vehicle before attempting to load/unload.
ALL REPAIR SERVICE MUST BE PERFORMED BY AN NSS AUTHORIZED DISTRIBUTOR/
SERVICE STATION USING ONLY NSS ORIGINAL EQUIPMENT PARTS.
OPERATION MANUAL
WARHORSE
SAVE THESE INSTRUCTIONS
WARNING: Fire or explosion hazard.
NEVER use with flammable or
combustible materials, such as gasoline,
kerosene, or other fuels or volatile
solvents to clean floor.
NEVER operate this machine in an
explosive atmosphere.
• NEVER stop or turn the machine on a ramp or incline.
• NEVER attempt to climb a grade or operate this
machine on a ramp or incline of more than 8 degrees.
• NEVER park or store the machine near a dock, on
ramps, near a furnace, boiler, open flame, or other
high heat source.
• NEVER expose the machine to rain, snow, or
extreme temperatures.
• NEVER store any items on this machine.
•
ALWAYS store this machine indoors in a dry, cool
area.
• ALWAYS store or transport LP fuel tank in the
upright position.
• ALWAYS use only tank and connections provided
with the Warhorse. This tank is fitted only for vapor
withdrawal, not liquid. It has safety features (check
valves, etc.) that are not found in tanks regularly
found in an LP supplier's yard.
• NEVER fill tank with any fuels other than propane
HD-5 Spec. carburetor grade. Do not use blends or
butane.
• ALWAYS have a qualified LP dealer fill the tank.
The dealer can be found in the yellow pages under
"Gas Liquefied Petroleum".
• NEVER store propane tank where unauthorized
personnel may tamper with it.
• NEVER alter or change the fuel system as incorrect
fuel mixture or gas leakage may result.
• ALWAYS check fuel system components and hoses
for leaks before operating.
• NEVER tip the engine on either side. Engine oil can
enter the air cleaner and cause the engine to run rich
and shut down.
• ALWAYS allow the engine time to cool before
performing any maintenance as hot parts can cause
severe burns.