Advertisement

IMPORTANT SAFETY INSTRUCTIONS

WARNING: Failure to observe these instructions can cause
personal injury to machine operator or bystanders
WARNING: Fire or explosion hazard.
NEVER operate this machine in an
explosive atmosphere (grain dust,
flammable liquids or fumes, etc.).
INTENDED USE
This machine is intended for commercial use,
scrubbing floors in an indoor environment. NSS
does not recommend using this machine for any
other purpose.
FOR SAFETY:
• ALWAYS read and understand all instructions before
operating or servicing machine.
• ALWAYS use this machine ONLY as described in this
manual.
• NEVER attempt to operate this machine unless you
have been trained in its operation.
• NEVER allow an untrained person to operate this
machine.
• NEVER attempt to operate this machine if it is not
working properly or has been damaged in any manner.
• NEVER disconnect or modify any switches or safety
devices (circuit breaker).
• NEVER drop or insert any object into any machine
opening.
• NEVER operate this machine with any air opening
blocked. Keep all air openings free of dust, lint, hair,
etc.
• NEVER pick up anything that is burning or smoking,
such as cigarettes, matches or hot ashes.
• NEVER spray this machine with water or any liquids.
• NEVER allow the vacuum motor or battery-charging
plug to get wet or a short may occur.
• NEVER operate this machine when the battery charger
is plugged in.
• NEVER operate this machine with the side skirt
removed.
ALL REPAIR SERVICE MUST BE PERFORMED BY AN NSS AUTHORIZED DISTRIBUTOR/
SERVICE STATION USING ONLY NSS ORIGINAL EQUIPMENT PARTS.
OPERATION MANUAL
WRANGLER 26
SAVE THESE INSTRUCTIONS
WARNING: Fire or explosion hazard.
NEVER attempt to pick up flammable or
combustible materials or use such
materials in tank.
• NEVER allow this machine to be used as a toy. Close
attention is necessary when used by or near children.
• ALWAYS wear clean tennis shoes or "non-slip"
shoes. Leather soled shoes will become extremely
slippery when wet.
• ALWAYS keep face, fingers, hair or any other body
part or loose clothing away from any machine
opening or moving part (revolving brush, pad driver,
or vacuum motor).
• ALWAYS turn the machine off when attaching pads
or brushes.
• ALWAYS remove keys when this machine is left
unattended.
• ALWAYS be sure that the ramp is secured to the
vehicle before attempting to load/unload.
• ALWAYS use extreme caution when operating the
machine on a ramp or loading/unloading this
machine into or out of a truck/trailer. Use extreme
caution if the ramp is wet, oily, or covered with
cleaning chemicals.
• NEVER stop or turn the machine on a ramp or
incline.
• NEVER attempt to climb a grade or operate this
machine on a ramp or incline of more than
8 degrees.
• NEVER park or store the machine near a dock, on
ramps, near a furnace, boiler, open flame, or other
high heat source.
• NEVER allow this machine to freeze.
• NEVER expose the machine to rain, snow, or
extreme temperatures.
• NEVER store any items on this machine.
• ALWAYS store this machine indoors in a dry, cool
area.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the WRANGLER 26 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for NSS WRANGLER 26

  • Page 1: Important Safety Instructions

    • NEVER store any items on this machine. removed. • ALWAYS store this machine indoors in a dry, cool area. ALL REPAIR SERVICE MUST BE PERFORMED BY AN NSS AUTHORIZED DISTRIBUTOR/ SERVICE STATION USING ONLY NSS ORIGINAL EQUIPMENT PARTS. SAVE THESE INSTRUCTIONS...
  • Page 2 • ADD only distilled or treated city water. Not well water. Milk of Magnesia, beaten egg or vegetable oil. Call a physician immediately. ALL REPAIR SERVICE MUST BE PERFORMED BY AN NSS AUTHORIZED DISTRIBUTOR/ SERVICE STATION USING ONLY NSS ORIGINAL EQUIPMENT PARTS. SAVE THESE INSTRUCTIONS...
  • Page 3: Machine Inspection

    MACHINE INSPECTION Battery Meter The battery meter is located on the right side of the • Now that the machine is unpacked remember to operator control panel and shows the state of charge of recycle all packing materials. batteries during operation and recharge. •...
  • Page 4 Check for any liquid leaks. retaining latch. Battery Package Drive Motor The Wrangler 26 is a 24 volt system and is available This machine is powered forward and reverse by a with one battery package: 24-volt drive motor. • Four (4) 6 volt, 225 Amp Hour Batteries. Consult •...
  • Page 5: Machine Operation

    • Align the lugs of the brush with the slots on the drive General Information casting. The Wrangler 26 is very maneuverable and is • Turn the lugs of the brush toward the latch, close the designed to scrub floors as you operate the machine latch around the lug to lock onto the drive casting.
  • Page 6: Operating The Machine

    Place the drain hose back into the machine and secure the plug end in the clamp. Do The Wrangler 26 has the brush motors offset to the not obstruct the lift mechanism or brush motors. right side of the machine. This offset allows you to •...
  • Page 7: Machine Maintenance

    • If the batteries have been discharged (used) too warm water. deeply, the battery charger will not start. Consult • Repair or replace any worn or damaged components your local authorized NSS distributor or service as needed. center for assistance. Monthly Maintenance Battery Electrolyte (Liquid) Level •...
  • Page 8 Authorized Repair Service procedure be performed at the described interval. Repair service for this machine must be performed by This procedure should be performed by an NSS an NSS authorized service center. Repairs performed authorized distributor or service center. Failure to...
  • Page 9: Troubleshooting

    TROUBLE-SHOOTING PROBLEM CAUSE SOLUTION No solution flow. Clogged filter. Clean filter. Low battery charge. Charge the batteries. The solution valve is closed. Open the solution valve. Obstruction in the solution hose. Remove the obstruction. Solution valve or linkage damaged. Repair/replace the valve linkage. Solution hose kinked.
  • Page 10 NOTES:...
  • Page 11 NOTES:...
  • Page 12 NSS ® Enterprises, Inc. European Distribution Centre Unit II, Pinfold Trading Estate * 55 Nottingham Road STAPLEFORD, NOTTINGHAM NG9 8AD ENGLAND U.K. PHONE: (44) 0115 939 1568 * FAX: (44) 0115 949 0615 WRANGLER 26 VS Orig. 6/98 Rev C 04/03 9092607...

Table of Contents