Table of Contents
Advertisement
Absolute Boilers ABS 1500-2000-2500-3000-4000
1.2 General safety notes
Installers and operational personnel must at all times observe all safety regulations. The following warnings and cautions
are general and must be given the same attention as specific precautions included in these instructions.
The installation must conform to the requirements of their authority having jurisdiction or, in the absences of such
requirements, with the National Fuel Gas Code ANSI Z223.1/NFPA 54 and /or Natural Gas and Propane Installation
Code, CAN/CSA B149.1
Where required by the authority having jurisdiction, the installation must conform to the Standards for Control and
Safety Devices for Automatically Fired Boiler, ANSI/ASME CSD1
Product is CSD-1 complaint. Authorities having jurisdiction should be contacted before installations begin.
DANGER
Flue gas products contain carbon monoxide gas
which can cause nausea or asphyxiation, resulting
in severe personnel injury or death!
WARNING
The boiler is connected to 120 VAC 1ph and/or 230 VAC
3 ph. An improper installation or attempts to repair
electrical components or controls may result in life
threatening situation. Always disconnect main service
to boiler before servicing.
WARNING
Only properly qualified personnel that hold all necessary
licenses shall work on the installation and service of this
boiler. Unlicensed and untrained service technicians are
strictly prohibited from installing or servicing this boiler
WARNING
Do not touch the boiler; hot surfaces can be a burn hazard.
WARNING
Pressure hazard! Annually test safety relief valve for proper
operation. Do not operate boiler with faulty relief valve.
WARNING
The boiler must not be installed on carpet.
WARNING
Do not stand on top of this boiler, or place items on top
of the boiler.
WARNING
The boiler must not be modified or fitted with non OEM
spare parts without the express written approval of
Innovative Industrial Inc.
WARNING
If you smell gas, turn the boiler off immediately, by
shutting off the gas supply downstream of the boiler.
Do not try to light or operate any appliances, evacuate
all people. Do not touch any electric switch; do not use
any phone in the building. If you cannot reach your gas
supplier, call the fire department, using a phone outside
the building.
WARNING
Lifting hazards! Use properly rated lifting equipment to
lift and position the boiler.
WARNING
Pressure hazard! Hot fluids. Install isolation valves on
boiler water inlet and outlet. Make sure isolation valves
are closed before servicing boiler.
8
Advertisement
Table of Contents
