Maintenance; Recognising And Repairing Of Mistakes; Guarantee Regulations; Notes On Product Liability - Profi-pumpe DIESEL Operating Instructions Manual

10 English

12. MAINTENANCE

K24 has been designed to require a minimum amount of maintenance. The only types of maintenance required are
the following:
l Battery change -necessary when the batteries have run down
l Cleaning of the turbine with washing or mechanically-handling
12.1. BATTERY REPLACEMENT
K24 is complete with 2 x 1.5 V. alkaline batteries SIZE AAA. K24 features two low-battery alarm levels:
l When the battery charge falls below the first level on the LCD, the fixed battery symbol
appears.
In this condition, K24 continues to operate correctly, but the fixed icon warns the user
that it is ADVISABLE to change the batteries.
l If K24 operation continues without changing the batteries, the second battery alarm level
will be reached which will prevent operation. In this condition the battery icon starts to
flash and is the only one to remain visible on the LCD.
WARNING
Do not discard the old batteries in the environment.
Refer to local disposal regulations.
To change the batteries, with reference to the exploded diagram positions, proceed as follows:
l Press RESET to update all the totals
l Loosen the 4 fixing screws of the lower cover
l Remove the old batteries
l Place the new batteries in the same position as the old ones
l close the cover again, by positioning the rubber protection as a gasket K24 will switch on automatically and normal
operation can be resumed.
The K24 will display the same Reset Total, the same Total and the same Partial indicated before the batteries were
changed. After changing the batteries, the meter does not need calibrating again.
12.2. CLEANING
Only one operation is necessary to clean the k24.
After removing k24 from the plant where it was built in, any residual elements can be removed by washing or mecha-
nically-handling. If this operation does not restore a smooth rotation of the turbine, it will have to be replaced.
WARNING:
Donotusecompressedairontotheturbineinordertoavoiditsdamagebecauseofanexcessive
rotation

13. RECOGNISING AND REPAIRING OF MISTAKES

Problem Possible cause
LCD: no indication Bad battery contact
Not enough measure- Wrong K FACTOR
ment precision
The meter works below minimum accepta-
ble flow rate.
Reduced or zero flow TURBINE blocked
rate
The meter does not Incorrect installation of gears after
count, but the flow rate cleaning
is correct
Possible electronic card problems
*AdBlue, a registered trademark of Verband der Automobilindustrie e. V.
Solution
Check battery contacts
With reference to paragraph H, check the K
FACTOR
Increase the flow rate until an acceptable
flow rate range has been achieved
Clean the TURBINE
Repeat the reassembly procedure
Contact your dealer

14. GUARANTEE REGULATIONS

For all manufacturing and material defects, the statutory warranty applies. In these cases, we assume the
Exchange or appliance repairs. Shipping costs are borne by us only to the extent legally
is prescribed.
In case of warranty please call our service platform http://www.profi-pumpe.de/service.php log the event.
Then we will inform you how to proceed with case by case basis.
Returns please sufficient postage. Unfortunately prepaid returns will not be accepted,
because they are filtered out before delivery. Our service we provide in Germany.
The warranty does not cover:
l Improper installation (proper installation, unauthorized persons)
l Material wear (eg. seals) or dirt in the unit
l Unjustified interventions or changes in the device
l Damages by selffault
l Improper servicing and improper use
Moreover, we give no damage compensation for secondary damages!
15.NOTESONPRODUCTLIABILITY
We point out, that we are only liable for damages under the Product Liability Act, which are caused by our units if no
changes were made to the equipment. We are only liable for repairs, if original spare parts and accessories were
used and repairs are carried out by our authorized service.

16. NOTES ON DISPOSAL

Electro devices of our company, labeled with the symbol of the crossed trash bin, are not permitted to
be disposed in your household garbage. We are registered at the German registration department EAR
under the WEEE-No.DE25523173. This symbol means, that you're not allowed to treat this product as a
regular household waste item – it has to be disposed at a recycling collection point of electrical devices.
This is the best way to save and protect our earth.
THANK YOU FOR YOUR SUPPORT!
In connection with the sale of batteries or with the delivery of equipment containing rechargeable battery
packs, the seller is obliged to draw your attention to the following:
You are obliged to return used batteries as an end-user. You can return batteries after use to the seller
or to the designated collection facilities, which are free of charge (eg: municipal collection points or in
stores). You can return the batteries for disposal at no charge to the seller.

17. EU DECLARATION OF CONFORMITY

The undersigned 1A Profi Handels GmbH, Unterriethstr. 37, 65187 Wiesbaden confirms, that the products placed
on the market execution referred to the relevant regulations below, the relevant EU directives and harmonized corre-
sponds to the EU standard for security.
This declaration is valid insofar as no changes to the product are made.
Authorized person to keep the technical documents:
1A-Profi-Handels GmbH · Unterriethstraße 37 · D-65187 Wiesbaden
LowVoltageDirective(2006/95/EC)
ECElectromagneticcompatibilitydirective(2004/108/EC)
The following harmonized standards:
EN 60335-1:2012; EN 60335-2-41:2003+A2:2010
EN 55014-1:2006+A2:2011; EN 55014-2:1997+A2:2008
EN 61000-3-2:2006+A2:2009; EN 61000-3-3:2008
Wiesbaden, 10th March 2016
Peter Neumüller
*AdBlue, a registered trademark of Verband der Automobilindustrie e. V.
English 11