1. Manuals
  2. Brands
  3. venture Manuals
  4. Motorhomes
  5. Sonic series
  6. Owner's manual

venture Sonic series Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
GUIDEBOOK TO ENJOYMENT OF
YOUR VENTURE RV
RECREATIONAL VEHICLE
Sonic
PDF created with pdfFactory trial version
www.pdffactory.com

Advertisement

Table of Contents
loading

Related Manuals for venture Sonic series

Summary of Contents for venture Sonic series

  • Page 1 GUIDEBOOK TO ENJOYMENT OF YOUR VENTURE RV RECREATIONAL VEHICLE Sonic PDF created with pdfFactory trial version www.pdffactory.com...
  • Page 2 THE PURPOSE OF THE VENTURE RV OWNER’S MANUAL IS TO PROVIDE THE MOST CURRENT INFORMATION AVAILABLE CONCERNING VENTURE RV RECREATIONAL VEHICLES. OPERATION AND MINOR MAINTENANCE IS THE MAIN FOCUS OF THIS BOOK. MAINTENANCE OF YOUR RECREATIONAL VEHICLE IS IMPORTANT TO KEEPING YOUR COACH IN GOOD CONDITION.
  • Page 3 As the owner of a new VENTURE RV, you can rest assured that we will do all we can to keep you a “happy camper”. Naturally, your selling dealership is always happy to help you with any questions you may have or service you may need.

  • Page 4: Table Of Contents

    TABLE OF CONTENTS Chapter 1 – Introduction to RV Ownership ........1 Safety Considerations ..............2 Reporting Safety Defects ............2 Safety When Emergency Stopping ........3 Additional Safety Considerations .......... 3 Extended or Cold Weather Use ..........4 Condensation ................4 Causes...….…………………………………………………..…4 Solutions…………………………………………………………5 Interior Ventilation……………………………………...……………6...
  • Page 5 How to Change a Tire ............26 Wheel Bearings…………………………………….………….26 Wheel Lugs..…………………………………….…………….26 Brakes—Electrical .............. 27 Breakaway Switch .............. 27 Setting Up and Using Your Recreational Vehicle ....28 Travel Trailer Hook Up………………………………………..29 General Detector Information………………………………..30 Safety Detectors….………….…...………………...…………30 Fire Extinguisher………………………………………….30 Propane/ Carbon Monoxide Detector….…...……..…...31 What is Carbon Monoxide?..........31 Dual Sensor Technology………………...……………..
  • Page 6 Bath and Shower ..............45 Outside Shower (Optional) ..........45 Fresh Water Lines…………………………………...………..46 Lo-Point Drains……………………………...……….………..46 Sanitizing and Filling the Potable Water System ....47 For Water Lines only……………………….….……...….47 Drainage (Fresh Water) ............48 To Drain System….………………………..……………..48 Sanitation System ..............48 Toilets…..………...
  • Page 7 Thermostat……………………………………………………...73 Operating Instructions………………………………………...74 External Vents…………………………………………………75 Ducting……………………………………………….…………75 Drop-In Cook Top Operation ............. 76 Operating Instructions............76 Water Heater…………..............78 Operating Instructions: Gas………..……………….…...78 Operating Instructions: Direct Spark Ignition……….….78 Operating Instructions: Electric Element……………….79 To Turn Off Water Heater……………………………….81 Winterizing Your Water Heater………………………………81 Refrigerator………………………………………………………..81 Leveling……………...

  • Page 8: Chapter 1 - Introduction To Rv Ownership

    CHAPTER 1 INTRODUCTION TO RV OWNERSHIP Welcome to the growing family of new VENTURE RV owners and the world of recreational vehicle travel. The purchase of your VENTURE RV product allows you to enter this type of camping and leisure travel.

  • Page 9: Safety Considerations

    However, NHTSA cannot become involved in individual problems between you, your dealer or VENTURE RV. To contact NHTSA, you may either call the Auto Safety Hotline toll- free at 1-800-424-9393 or write to:...

  • Page 10: Safety When Emergency Stopping

    You can also obtain other information about motor vehicle safety from the Hotline. Safety When Emergency Stopping It is wise to carry road flags and/or triangular warning devices to be used when necessary. When pulling off a highway, use your four way hazard lights as warning flashers, even if only to change drivers.

  • Page 11: Extended Or Cold Weather Use

    11. Extinguish all campfires before leaving your campsite. EXTENDED OR COLD WEATHER USE Your VENTURE recreational vehicle has been built for enjoyment in a recreational manner. This recreational vehicle is not intended to be used as full-time living quarters. Nor is this a four season unit. Using this unit in freezing conditions is not recommended.

  • Page 12: Solutions

    B. Normal breathing will emit approximately 1/2 pint of moisture into the air per person, per day. The more occupants the greater quantity of condensation you may find. Solutions: 1. When taking a shower, open bath roof vent approximately ½ inch allowing moisture to escape.

  • Page 13: Interior Ventilation

    INTERIOR VENTILATION A new coach always has a peculiar aroma in it due to all the components used to build it, such as paneling, plywood, carpet and fabrics. Allowing fresh air to move and circulate throughout a new recreational vehicle is very valuable for several reasons. 1.

  • Page 14: Chapter 2 - Service Procedures

    CHAPTER 2 SERVICE PROCEDURES BASIC SERVICE PROCEDURES___________________________ VENTURE RV and Your VENTURE RV Dealer have a strong and dedicated interest in maintaining the highest quality customer relations with its owners. Your satisfaction with your VENTURE recreational vehicle and your VENTURE RV dealer is our primary concern.

  • Page 15: Dealer

    Your authorized VENTURE RV dealer has performed a PDI (pre- delivery inspection) on your recreational vehicle. Since your dealer is authorized to sell VENTURE RV products, they are also there to supply parts, optional equipment, and provide service repairs, warranty or otherwise as needed.

  • Page 16: Seasonal Site

    If you are traveling and are unable to locate an authorized VENTURE RV dealer, or an authorized dealer for the component needing service, please call our customer service office at (888)988- 8440. Service at a non-authorized dealer MUST have prior authorization.

  • Page 17: Towable Limited Warranty

    TLW are: (1) items added, changed, or modified after the unit left the posses- sion of Venture RV; (2) units used for any commercial purpose; (3) units used for full-time residential use or more than occasional recreational use ; (4) wear and tear caused by normal usage by the consumer, including but not limited to fading or discoloration of soft goods [e.g., tents, upholstery, drapes, carpet, vi-...
  • Page 18 Venture RV and delays may be experienced. Venture RV is not responsible for loss of use of the unit, expenses for fuel, telephone, food, lodging, travel, loss of income or revenue, or loss of or damage to personal property.
  • Page 19 Venture RV reserves the right to make changes in the design or material of its products without incurring any obligation to incorporate such changes in any product previously manufac- tured.
  • Page 20 The TLW registra- tion must be completed and returned to Venture RV within fifteen (15) days of delivery of the unit to the consumer. Failure to do so can void this TLW or cause delays in obtaining benefits.

  • Page 21: Chapter 3 Using Your Rv

    CHAPTER 3 USING YOUR RV In this chapter you will find three areas of useful information to assist you with correct equipment, traveling, and finally, actually using your recreational vehicle. EQUIPMENT______________________________________ Tow Vehicle Begin your camping experiences by obtaining a tow vehicle which will adequately transport your recreational vehicle to and from your chosen destinations.

  • Page 22: Hitch Height Specifications - Travel Trailer

    in both vehicles traveling level. The condition of the tow vehicle’s suspension system will affect the towing performance capability of your equipment. Sway controls may be needed based on size and weight of coach, plus capability of your tow vehicle. CAUTION Trailers with tandem axles need to travel as level as possible, avoiding different weights on each axle plus handling conditions.

  • Page 23: The Safety Chain (Travel Trailer)

    3. Back the tow vehicle into proper position, coupler over ball. 4. Turn the crank on the jack to lower the coupler onto the ball hitch. 5. Close the coupler latch after completely seated and insert pin. 6. Install weight distributing bars (equalizer), when required, as recommended by hitch supplier.

  • Page 24: Traveling

    TRAVELING______________________________________ Weights For safety reasons and federal regulations VENTURE RV provides accurate weight specifications to owners. On the exterior left front corner of the coach you will find the Federal “Vehicle Identification Number” sticker, as required by the federal government. This tag supplies...

  • Page 25: Weighing Vehicle (Loaded Or Unloaded)

    The difference between the two weights is the hitch weight. VENTURE RV suggests you also weigh each side (2 tires) separate to find balance of pounds per side. Its possible to have 1 side correct and the other side over-loaded.
  • Page 26 CAUTION Any damage caused by improper loading or installing additional equipment is NOT covered by Venture RV Limited Warranty. Below is a blank space for you to calculate the “ Cargo Carry Capacity “ of your unit. You will find the weights of your unit on a sticker, placed on the edge OR CENTER of the screen door.

  • Page 27: Towing

    7. Remember to drive more slowly on wet and icy highways to keep control of your vehicle. Tires All VENTURE RV towable coaches are equipped with appropriate tires for recreational vehicles. Tires are rated to carry weight as listed to G.V.W.R. PDF created with pdfFactory trial version...

  • Page 28: Safety First-Basic Tire Maintenance

    Tires are radial in design using components to offer excellent strength and mileage in all kinds of weather conditions. Tires on your vehicle( s) are one of the most important components of the towing package. Without inflated tires ,you will not be moving anywhere., Taking care of your tires during travel is very important.

  • Page 29: Understanding Tire Pressure And Load Limits

    CAUTION It is recommended that the tire pressure be checked at the beginning of each journey, and at least once per week during useage to obtain the maximum life of the tires. Understanding Tire Pressure and Load Limits Tire inflation pressure is the level of air in the tire that provides it with load- carrying capacity and affects the overall performance of the vehicle.

  • Page 30: Tire Tread

    Tire Tread The tire tread provides the gripping action and traction that prevent your vehicle from slipping or sliding, especially when the road is wet or icy. In general, tires are not safe and should be replaced when the tread is worn down to 1/16 of an inch.

  • Page 31: Vehicle Load Limits

    The letters “ST’ refer as “service trailer” meaning they are for RV TRAILERS, manufactured for that purpose. These tires should not be used for automotive use. NOTE; Each original tire installed on KZ –RV recreational vehicles have a speed rating of 75 mph, or greater. Please note maximum load rating, tire pressure, and speed rating as imprinted on the sidewall of tire.

  • Page 32: How Overloading Affects Your Rv And Tires

    fresh water storage tank of 100 gallons, this tank when filled would weigh about 800 pounds. If more cargo is being transported, water can be off- loaded to keep the total amount of cargo added to the vehicle within the limits of the GVWR so as not to overload the vehicle.

  • Page 33: How To Change A Tire

    How to Change a Tire 1. Place blocking under main rail/frame with hydraulic jack on top of blocking in front of spring hanger, ALWAYS on main rail. 2. Break lug nuts loose before raising coach. DO NOT remove nuts. 3. Raise coach with jack until tire is off the ground. 4.

  • Page 34: Brakes-Electrical

    Brakes – Electrical Electric brakes on your recreational vehicle are designed to work in conjunction with the hydraulic brakes on your tow vehicle. This means to have the best brake performance on both systems, the trailer and the tow vehicle must perform and operate together. Any attempt to use either brake system alone, tow vehicle or trailer will cause accelerated wear and damage.

  • Page 35: Setting Up And Using Your Recreational Vehicle

    brakes. This system will apply the brakes of the trailer should it become loose or detached from the tow vehicle. A 12-volt battery installed on the coach is required to power the breakaway switch. Never use this breakaway switch and trailer brake system as a parking brake.

  • Page 36: Travel Trailer Hook Up

    live on the level. Should a level site not be available, use short 2 x 6 inch blocks of wood to raise the low side wheels to a level position. Before unhooking the trailer from the tow vehicle, be sure the jack foot is in place on the tongue jack and block the trailer wheels to keep the trailer from moving.

  • Page 37: General Detector Information

    v Turn on propane tanks and light pilot lights, if any, on appliances. Remember there may be air in your propane lines. Be sure to bleed them before planned usage. v Open any windows and roof vents as desired for ventilation. v Fresh water connections.

  • Page 38: Propane/ Carbon Monoxide Detector

    Propane/Carbon Monoxide Detector —#2 Any recreational vehicle which contains a propane fuel system with propane consuming appliances requires a propane leak detection device for safety protection. Currently this detector also serves as a carbon monoxide protection device. A converter or auxiliary battery is required to supply 12-volt DC energy to operate the device.

  • Page 39: Low Power Option

    the test button. See Test Procedure in this manual. After the warm-up period, the GREEN power ON indicator should glow continuously. If the ON indicator light does not light, see the section, Trouble-Shooting Guide, in the user’s manual for further information. Do not attempt to fix it yourself.

  • Page 40: Propane Gas Alarm

    of alarm is pressed. Ventilate the RV. The RED light will stay ON until the CO has cleared, or the alarm will reactivate in approximately 6 minutes if the CO is still present. DO NOT RE-ENTER THE RV. This alarm will return to normal operation after the RV’s properly ventilated.

  • Page 41: Smoke Alarm

    The signal is the LED flashing. RED/RED GREEN/GREEN with a beep every 25-30 seconds. The EOL signal may be reset by pushing TEST/ RETEST button on the alarm. This will reset the EOL signal for a period of 72 hours for a total of up to 30 days. After 30 days the signal cannot be reset and the alarm MUST be replaced.

  • Page 42: Steps-Two Or Three

    electronic circuitry, horn and battery are working. If no alarm sounds, the unit has a defective battery or other failure and should be replaced immediately. • Test each smoke alarm weekly to be sure it is installed correctly and operation properly. •...

  • Page 43: Windows

    Windows All windows are of slider opening design, solid picture window, or opening vent panels. Sliders may open horizontal or vertical as called for per floor plan. Egress windows have an unlocking handle or two small hinged clips on each side. After unlatching, the panel will swing out on a top hinge.
  • Page 44 PDF created with pdfFactory trial version www.pdffactory.com...

  • Page 45: Slide Outs

    NOTE: The Venture, Sonic models that have slide-outs, use one of the following slide-outs that are listed. SLIDE-OUTS With different models of trailers, VENTURE RV uses numerous slide out systems as listed below, followed by descriptions. Several different vendors supply components, loose and/or attached to frames.

  • Page 46: Trailer Set-Up Requirements-General

    TRAILER SET-UP REQUIREMENTS - GENERAL Note: 1. Before operating the slide-out room, level the trailer front-to-rear and side to side. 2. Extend all stabilizer jacks to make solid contact with the ground and/ or on solid blocks. Placing stabilizer jacks onto a hard surface allows the coach to remain square and assure a good weather tight seal between the room and trailer sidewall.

  • Page 47: Electrical Components

    It takes about 20 seconds to move the slide in or out. VENTURE RV does NOT require or suggest blocking, supports, jacks, etc., to be used under slide outs during extended normal use.

  • Page 48: Manual Override

    Night shades installed, have cords anchored to lower part of window and need to be secured for operation. VENTURE RV recommends these shades be in the UP position for travel to avoid lower metal holder being in contact with garnish on window.
  • Page 49 WARNING These individual tassel cords reduce the strangulation hazard in the pull cord by re- moving the loop. Do not tie cords together. Check periodically to make sure the cords have not twisted into a loop. CAUTION While traveling, all mini blinds need to be in :up “ position to avoid swinging and scratching paneling.

  • Page 50: Chapter 4 - Systems

    CHAPTER 4 SYSTEMS WATER AND DRAINAGE PLUMBING_______________________ Your Venture recreational vehicle has a complete water system, to carry fresh water, as well as holding tanks for used water. Each group has its own explanation along with its own operation. FRESH WATER SYSTEM_________________________________...

  • Page 51: 12-Volt Demand Pump

    CAUTION DO NOT leave tank unattended while filling, as an over filled tank will built pressure, causing tank to crack, rupture, and leak or even damaging sup- ports holding it in place. CAUTION Excessive pressure from water supply systems may be encountered in some parks, especially in mountain regions.

  • Page 52: Faucets

    Faucets The basic operation of a faucet is the same as in your home. Open the knobs for water supply. Close faucets when sufficient water volume is achieved. It is normal to experience occasional air pockets in the system. Bath and Shower Your bathtub and shower are built with Vinyl, Fiberglass, or ABS plastic material, similar to those in your home.

  • Page 53: Fresh Water Lines

    4. To end operation close valve (s) on the faucet and allow water to drain from the shower head. 5. Close the valve on the shower head. Any water remaining in the hose will drip or run out of the vacuum breaker.

  • Page 54: Sanitizing And Filling The Potable Water System

    Sanitizing and Filling the Potable Water System For your safety, you should sanitize your potable water system when your recreational vehicle is new or when it has been sitting unused for a period of time such as over winter, and it may have become contaminated.

  • Page 55: Drainage (Fresh Water)

    Your demand water system is now ready for use. 10. Be sure to TURN OFF the pump when traveling or when the recreational vehicle is not in use. Your water system is now ready to be used. When sanitizing is completed, remember V-1 valve needs to be closed, and V-2 valve needs to be open for normal use.

  • Page 56: Using Toilet And Tank System

    OPERATION: Note the photos showing movement of pedal downward. To flush, press pedal all the way down. To add water, press pedal halfway down. When hooked up to a sewer drain at a camp ground, ALWAYS keep the termination valve CLOSED until the tank is at least 3/4 full.

  • Page 57: Holding Tanks

    CAUTION Keep drain valve closed. Sewer gases may be present when RV is connect- ed to campground sewage hookup. If drain valve is open, sewer gases may be vented out the side of the RV. (See owners manual). Holding Tanks The final parts of your sanitation system are the holding tanks for waste materials and water.

  • Page 58: Black Tank Flush System

    requiring unit to be level or slightly up in front. Others will drain from end permitting a slight tilting to the side which drains are on. CAUTION It is important to use adequate water to flush and have several gallons of water with chemicals in the tank.

  • Page 59: Maintenance For Holding Tanks

    CAUTION Sewer Tank Flusher– Sewer valves must be OPEN when using this inlet. Maintenance for Holding Tanks The following maintenance is recommended by our holding tank suppliers to keep your tanks clean and keep the probes free of debris and build-up. Gray (Waste-Water) Tank.

  • Page 60: By Pass Kit

    3. After water has been drained, use an air hose from compressor and an adapter attached to city water fill. In about 3 to 5 minutes all water will be blown out of system. 4. Pour one (1) cup (12 oz) of non-toxic RV anti-freeze into each P-Trap.

  • Page 61: Propane Fuel System

    PROPANE FUEL SYSTEM________________________________ The fuel system in your recreational vehicle has numerous components such as, piping, copper tubing, brass connectors, hoses, regulators and appliances. Each of these components will be explained in its appropriate area. Propane is the only fuel permitted to be used in a recreational vehicle and its appliances.

  • Page 62: Servicing And Filling Propane Containers

    2. A small screw on the side of main body OPD Cylinder Valve referred to as the 10 % valve which allows air to be released and indicates when container is at 80 % capacity. 3. Incoming positive seal valve MUST be pushed inward with fill nozzle to fill or by POL fitting to draw vapor out for appliance use.

  • Page 63: Installing Propane Containers

    Your vehicle has exterior combustion air inlets. Appliance pilot lights should be turned off during gasoline or propane refueling. (Required by law in some states.) Installing Propane Containers Venture recreational vehicles are equipped with 20 or 30 pound propane containers, depending on floor plan models. Mounting and attaching instructions are listed below: 1.
  • Page 64 6. Attach the main hose from the regulator to the manifold fitting in the frame. 7. Attach two short pigtail hoses to the regulator and bottles at the ACME fitting. 8. Test all propane connections for leakage. A warning label has been located near the propane container. This label read as follows: DANGER All pilot lights, appliances and their igniters (see operating instructions) shall...

  • Page 65: Regulator

    WARNING Propane cylinders shall not be placed or stored inside the vehicle. Propane cylinders are equipped with safety devices that relieve excessive pressure by discharging gas to the atmosphere. FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY. CAUTION THIS GAS PIPING SYSTEM IS DESIGNED FOR USE WITH PROPANE ONLY.
  • Page 66 The propane regulator used on the Venture units, is the automatic two stage regulator. With both cylinders full of propane, turn the lever on the regulator towards the cylinder you wish to use first.

  • Page 67: High Pressure Hoses With Acme Connectors

    CAUTION If you have double bottles and a standard regulator on your RV, use only one bottle at a time. Otherwise the gas supply will be drawn equally from both bottles until supply has been totally exhausted. Using one bottle until it is empty, then using the second bottle will allow you to fill the empty bottle at your convenience without being totally out of propane.

  • Page 68: Operation

    Should you experience a propane “freeze-up”, close the main valve and wait 15 minutes before trying again. Keep the container valve(s) closed when traveling. Some states prohibit traveling with the propane container valves open, especially in underground tunnels on expressways. Operation After the camper is completely set up and you are prepared for camping enjoyment, follow these steps for propane operation.

  • Page 69: Propane Gas Consumption

    DANGER IT IS NOT SAFE TO USE COOKING APPLIANCES FOR COMFORT HEAT- ING. Cooking appliances need fresh air for safe operation. Before operation: 1. Open overhead vent or turn on exhaust fan. 2. Open window (s). FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY. Unlike homes, the amount of oxygen supply is limited due to the size of the recreational vehicle, and proper ventilation when using the cooking appli- ances avoids danger of asphyxiation.
  • Page 70 APPLIANCE LP GAS CONSUMPTION Water Heater 12,000 BTU Furnace 20,000- BTU Stove/Oven 6,500-9,100 BTU Refer 1,200-2,200 BTU Note: The above chart represents many different models. WARNING Portable fuel-burning equipment, including wood and charcoal grills and stoves, shall not be used inside the recreational vehicle. The use of this equipment inside the recreational vehicle may cause fire or asphyxiation.

  • Page 71: Electrical System

    All installations and designs are built to comply with safety requirements of ANSI standard 1192, National Electric Code and Canadian Standards Association. This model manufactured by VENTURE RV has 30 amp system. Highly recommend that your RV electrical connection, is not plugged into a household outlet.

  • Page 72: Circuit Breakers And Box

    In some hook-ups the power cord may not be long enough and extension cords are required. Always use a cord with the gauge of wire equal to or greater then the power cord. Should you use a cord with a smaller wire gauge, overheating, loss of amperage, and possible melting could occur.

  • Page 73: Gfci Protection

    WARNING NEVER, under any circumstances, remove a grounding pin in any cord or plug. It may mean the difference between LIFE OR DEATH. GFCI Protection Each coach has a GFCI, Ground Fault Circuit Interrupter, protection receptacle installed into the circuitry. This GFCI device is designed to protect people from hazards of line to ground electric shock.

  • Page 74: Volt Dc System

    This GFCI receptacle will not protect against short-circuits or overloads. The circuit breaker or fuse in the electrical panel which supplies power to the circuit provides this protection. Polarity is extremely important. You should be certain that the polarity of the external power is not reversed, in order to avoid harm to appliances and personal electrical shock.

  • Page 75: Auxiliary Battery

    When the converter receives 120 AC power, it transfers power into 12-volt DC without any manual switches. The converter also charges the auxiliary battery (s) when installed on the coach and is attached to 120-volt AC power. The third function of a converter is to send 12-volt power to the fuse panel and throughout the coach.
  • Page 76 Fuses are placed into the fuse panel with the converter or into a separate panel near the converter with access inside of coach. Fuses are placed in your electrical system to protect wiring and components when overloads appear or short circuits occur. Radios, stereos and possibly other components may have “in-line”...

  • Page 77: Exterior Lights And Connector, 12V

    Contact your dealer should you desire an isolator for your protection. Two types are available, mechanical type, or solid state which is the best and most expensive. #1 – Black/Ground (8 Gauge) #2 – Blue/Brakes #3 – Green/Running A – Breakaway Switch #4 –...
  • Page 78 If experiencing any electrical problems, check the following items, fuses, breakers, and connections. If none of these items resolve the problem, contact your dealer for trouble shooting, and needed repairs. FURRION is a solar panel connection, for portable panel, placed in sun light, on the ground or a table. Only the hook-up connection has been installed in this RV.

  • Page 79: Chapter 5 - Appliances

    CHAPTER 5 APPLIANCES VENTURE RV places brand name, quality-built equipment, as guided by current codes and standards, in all recreational vehicles. Some appliances are built and equipped to operate on propane gas ONLY. DO NOT attempt to operate on natural, butane or methane gas.

  • Page 80: Furnace

    BEFORE OPERATING, take note of any unusual odor in coach, near floor or elsewhere similar to propane. Each appliance has it’s own manual, be sure to read and obey all instructions as written by manufacture. FURNACE____________________________________________ The furnace in your recreational vehicle requires 12-volt DC electrical current and propane gas energy for correct operation.

  • Page 81: Operating Instructions

    Operating Instructions 1. Before using your furnace, it is suggested to open entrance door and windows to ventilate camper for any unusual odors such as propane or other. 2. Be sure propane container has fuel and valve is turned open. 3.

  • Page 82: External Vents

    Do not install screens over the vents for any reason. Screens will become restricted and cause unsafe furnace operation. Accessories are being mar- keted for RV products which Venture RV does not recommend. For your safety, only factory authorized parts are to be used on your furnace.

  • Page 83: Drop-In Cook Top Operation

    DROP-IN COOK TOP The cooking appliance used in the Venture RV, Sonic models, is a 2 Burner Drop-In Cook top. These appliances operate with propane gas only, never natural gas or methane. This model of stove DOES NOT have a free standing pilot light.
  • Page 84 CAUTION Hand held igniters may be used but be sure they are the type designed for lighting open flame burners. WARNING Be sure all control knobs are turned “OFF” when you are not cooking. Someone could be burned or a fire could start if a burner is accidentally left on or unattended even if only momentarily.

  • Page 85: Water Heater

    WATER HEATER________________________________________ SAFETY INFORMATION FOR YOUR SAFETY READ SAFETY INSTRUCTIONS ON PAGE 73. OPERATING INSTRUCTIONS—GAS A. This appliance does not have a pilot light. It is equipped with an ignition device which automatically lights the burner. Do not try to light the burner by hand. B.

  • Page 86: Operating Instructions: Electric Element

    8. If lock-out occurs before main burner lights, turn switch to “OFF”, wait five seconds and turn switch to “ON” position. This will restart the ignition cycle. The first start-up of the heater may require several ignition cycles before all air is purged from the propane lines.
  • Page 87 CAUTION The thermostat on your water heater is not adjustable. It is a temperature sens- ing limit designed to maintain a water temperature of 130 degree F (54 degree C ). Water temperatures over 130 degree F (54 degree C ) can cause severe burns instantly or death from scalds;...

  • Page 88: To Turn Off Water Heater

    TO TURN OFF WATER HEATER: 1. Turn switch to “OFF” position. 2. Turn off the electric power to the appliance. 3. Turn off propane supply. 4. If the vehicle is to be stored or the water heater is going to be turned while subject freezing...

  • Page 89: Operation During Travel

    Operation During Travel While the refrigerator should be level when the vehicle is stopped, performance during travel is not usually effected. Venting For an absorption unit to operate fully it must have two vents. The lower vent serves as access to service components and allows air to enter.

  • Page 90: Door Handles

    Door Handles During travel, the door latch prevents the door from opening. When closing each door, push the door toward the refrigerator until you hear a “ clicking sound”. To open each door, pull the handle away from the refrigerator. CAUTION Do not use undue force or jerking action when opening the refriger- ator door.

  • Page 91: Air Conditioner

    AIR CONDITIONER—ROOF or SIDE Normal air conditioner is placed on top of roof and all controls are inside on air box. See instructions supplied by the manufacturer of product. A possible future air conditioner may be placed in the sidewall, near roof line and will installed only by factory personnel.

  • Page 92: Important Phone Numbers

    If problems occur with any appliance while traveling, contact the appliance manufacture direct. These phone numbers are listed in the appliance manuals. Manuals should stay in unit at all times. Important Phone Numbers ————————————————————— ————————————————————— ————————————————————— ————————————————————— ————————————————————— ————————————————————— ————————————————————— —————————————————————...

This manual is also suitable for:

Sonic

Table of Contents