Coleman PxXU-V series Installation Instructions Manual page 6

B
A
FRONT
B
VENT CONNECTION
(VENT SIZE
20
POWER
WIRING
7/8 K.O.
1-7/8
E F
FRONT
TOP IMAGE
RETURN END
FIGURE 2 : Dimensions - Downflow/Horizontal Models
Table 2: RATINGS & PHYSICAL / ELECTRICAL DATA - DOWNFLOW/HORIZONTAL MODELS
P*XD-V/G9V-DH
CABINET
INPU OUTPUT
WIDTH
NOM.
MBH MBH
(INCHES)
CFM
H/L H/L
80/52 75/48 1200 17-1/2
120/78 112/72 2000 24-1/2
1.
AFUE numbers are determined in accordance with DOE test procedures
2.
Wire size and overcurrent protection must comply with the National Electrical Code (NFPA-70-latest edition).
For altitudes above 2,000 ft., reduce capacity 4% for each 1,000 ft. above sea level. Refer to Form 035-14460-000.
•
Wire size based on copper conductors, 60°C, 3% voltage drop.
•
Continuous return air temperature must not be below 55°F.
•
Table 3: UNIT CLEARANCES TO COMBUSTIBLES
APPLICATION TOP FRONT
UPFLOW 1 3
DOWNFLOW 1 3
HORIZONTAL 1 3
1.
Special floor base or air conditioning coil required for use on combustible floor.
2.
Minimum of 8" clearance required to install condensate removal system.
3.
Line contact only permitted between lines formed by the intersection of the rear panel and side panel (top in horizontal position) of
the furnace jacket and building joists, studs or framing.
6
20
3/4
T'STAT WIRING
7/8 K.O.
CONDENSATE
DRAIN ACCESS
3-1/4 x 3
5-1/4
AIR INTAKE
45
3-5/8 x 3-5/8
1-1/4
G
( CONN. SIZE/
PIPE SIZE)
GAS INLET
1-1/4 x 2-1/2
28-1/2
LEFT SIDE
A
19-1/4
C
5-3/8
H
FRONT
BOTTOM IMAGE
RETURN END
LOW HIGH MAX.
FIRE FIRE OUTLET
1
AFUE
TEMP. TEMP. AIR
RISE °F RISE °F TEMP. °F
92.0 35-65 35-65 165
92.0 40-70 40-70 170
LEFT RIGHT
REAR
SIDE SIDE
UPFLOW MODELS (P*XU-V / G9V-UP)
0 0 0
DOWNFLOW / HORIZONTAL MODELS (P*XD-V / G9V-DH)
0 0 0
+
0 0
0
D
VENT CONNECTION
1-3/4
35
16-3/4
18-1/2
3-3/4
7-1/2
6-1/4
2-3/4
1-3/8
MODELS
A
P*XD-V / G9V-DH
80/75/1200/B
17-1/2 16-1/4
120/112/2000/D
24-1/2 23-1/4
8
1. VENT PIPE MUST BE INCREASED TO 3" ON THIS MODEL.
ALL DIMENSION ARE IN INCHES, AND ARE APPROXIMATE.
BLOWER
TOTAL
UNIT
HP AMPS SIZE
AMPS
1/2 1.7 11 x 8 12.0
1 4.4 11 x 10 14.5
FLUE FLOOR/BOTTOM
0 COMBUSTIBLE
1
0
COMBUSTIBLE
2
0
COMBUSTIBLE
035-17468-001 Rev. A (801)
CONDENSATE
DRAIN ACCESS
3-1/4 x 3
3-3/4
AIR INTAKE
3-5/8 x 3-5/8
G
( CONN. SIZE/
PIPE SIZE)
1-1/4
ALT. GAS INLET
4-1/8
1-1/4 x 2-1/2
RIGHT SIDE
B C D E F
14-3/4 2 6-5/8 2-1/4
1
21-3/4 10-1/8 2-1/4
2 (3)
MAX. MIN WIRE SIZE
OVER-CURRENT (AWG) @ 75 FT.
2 2
PROTECT ONE WAY
20 14
20 12
CLOSET ALCOVE ATTIC
YES YES YES
YES YES YES
NO YES YES
Unitary Products Group
G
2
3
OPERATING
WT. (LBS)
128
184
LINE
CONTACT
NO
NO
3
YES