Page 1
DTR-4.9 Ref. No. 4071 SERVICE MANUAL SERVICE MANUAL May, 2008 AV RECEIVER DTR-4.9 MODEL RC-711M Black model B MDD 120V AC, 60Hz SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ON THE SCHEMATIC DIAGRAM AND IN THE PARTS LIST ARE CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK.
Page 4
DTR-4.9 BLOCK DIAGRAMS-1 AUDIO SECTION TUNER UNIT AUDIO ANALOG Q5501 R2S15211FP FRONT L SELECTOR / TONE / VOLUME PHONES FRONT R POWER AMPLIFIER AUDIO DIGITAL MIC AMP. TONE +29dB SETUP MIC RL6600 MICDET FRONT SPEAKERS +29dB TONE Q6601 AUX IN...
DTR-4.9 Refer to following table about the parts displayed by mark " LIST ". SCHEMATIC DIAGRAMS-1 (SD-1) MODEL No. ---> DTR-4.9 DTR-5.9 DTX-5.9 TYPE ---> AUDIO INPUT SECTION MICROPROCESSOR PCB MICROPROCESSOR PCB AMPLIFIER PCB MICROPROCESSOR PCB MICROPROCESSOR PCB SIRIUS / DOCK TERMINAL PCB...
DTR-4.9 DSP/HDMI PCB ZONE 2 / IR PCB LIST SIRIUS/DOCK TERMINAL PCB SCHEMATIC DIAGRAMS-3 (SD-3) To NAETC-9452 To NAHDM-9565 LIST To NARF-9463 LIST LIST To TUNER UNIT To NALAN-9465 SD-8 : F1 SD-9 :C5 TO_FLASH_WRITER SD-10 : E3 SD-9 : H3...
DTR-4.9 SCHEMATIC DIAGRAMS-4 (SD-4) VIDEO SECTION P3007A NAVD-9467 Refer to following table about the parts displayed by mark " LIST ". LIST +12V MODEL NO. ---> DTR-4.9 DTR-5.9 DTX-5.9 Q9101 2SA950 FAN DRIVE R9102 1.2K TYPE ---> VIDEO PC BOARD R9103 4.7K...
DTR-4.9 SCHEMATIC DIAGRAMS-5 (SD-5) LIST NATRM-9428 SPEAKER TERMINAL / POWER SUPPLY SECTION NAETC-9449 ZONE 2 SPEAKER TERMINAL PC BOARD <Note> HEADPHONE JACK 1. NC = No mount of parts. PC BOARD 2. SD-x : XY is short for Schematic Diagrams-x and each sockets location, X = A to H, Y = 1 to 5.
Page 11
DTR-4.9 SCHEMATIC DIAGRAMS-6 (SD-6) DISPLAY SECTION NADIS-9444 DISPLAY PC BOARD Q7002 FL TUBE 16BT128GNK REMIN NOTE FLDRST THE COMPONENTS IDENTIFIED BY MARK ARE CRITICAL FOR SAFETY FLDCS FLDCLK REPLACE ONLY WITH PART NUMBER SPECIFIED. FLDSDO VOLTAGE (MEASURED WITH VOLTMETER) IS DC VOLTAGE.(NO INPUT SIGNAL).
DTR-4.9 SCHEMATIC DIAGRAMS-10 WAVEFORM SECTION-1/3 Digital Audio Waveform Part <Notes> 1. WF01 is short for Waveform-01 . 2. Refer to SD-3 (SCHEMATIC DIAGRAMS-3) for the location of each waveform on circuit. 3. SD-x : XY is short for Schematic Diagrams-x and each socket's location, X=A to H, Y=1 to 5.
Page 16
DTR-4.9 SCHEMATIC DIAGRAMS-11 WAVEFORM SECTION-2/3 Video Waveform Part Video source color and pattern <Notes> 1. WF21 is short for Waveform-21 . 2. Refer to SD-4 (SCHEMATIC DIAGRAMS-4) for the location of each waveform on circuit. 3. SD-x : XY is short for Schematic Diagrams-x and each socket's location, X=A to H, Y=1 to 5.
Page 17
DTR-4.9 SCHEMATIC DIAGRAMS-12 WAVEFORM SECTION-3/3 FL Driver IC Control Waveform Part <Notes> 1. WF61 is short for Waveform-61 . 2. Refer to SD-6 (SCHEMATIC DIAGRAMS-6) for the location of each waveform on circuit. 3. SD-x : XY is short for Schematic Diagrams-x and each socket's location, X=A to H, Y=1 to 5.
DTR-4.9 PACKING PROCEDURE A801 A804 A807 A822 A823 A805 A802 A824 A803 A806 A604 P901 A605 A607 Right side marking Front side A603 marking A821 A605 Front side A606 A702 A601 (L & R) A701 Left side marking Front side...
Page 21
DTR-5.9 PRINTED CIRCUIT BOARD VIEWS-3 TRANS. SEC. TERMINAL PC BOARD (NAPS-9425) Component side JL6952A NCPS-9425 25139425 THERMAL SENSOR PC BOARD (NAETC-9426) Component side Soldering side C6630 Q6380A Q6380 NCETC-9426 25139426 ZONE 2 SPEAKER TERMINAL PC BOARD (NATRM-9428) Component side JL6604C C6647 C6657 C6648...
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-1 Q201 : D788E001BRFP266 (Floating-Point Digital Signal Processor)-1/5 BLOCK DIAGRAM Program/Data JTAG EMU 256K Bytes McASP0 Data 16 Serializers Program/Data ROM Page1 C67x + CPU 256K Bytes Memory Data Controller Program/Data McASP1 ROM Page2...
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-3 Q201 : D788E001BRFP266 (Floating-Point Digital Signal Processor)-3/5 TERMINAL DESCRIPTION External Memory Interface (EMIF) Address and Control Pin Name Pin No. Type Description EM_A[0] EMIF Address Bus EM_A[1] EM_A[2] EM_A[3] EM_A[4] EM_A[5] EM_A[6] EM_A[7]...
Page 39
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-4 Q201 : D788E001BRFP266 (Floating-Point Digital Signal Processor)-4/5 TERMINAL DESCRIPTION McASP0, McASP1, McASP2, and SPI1 Serial Ports Pin Name Pin No. Type Description AHCLKR0/AHCLKR1 McASP0 and McASP1 Receive Master Clock ACLKR0 McASP0 Receive Bit Clock...
Page 40
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-5 Q201 : D788E001BRFP266 (Floating-Point Digital Signal Processor)-5/5 TERMINAL DESCRIPTION Clocks Pin Name Pin No. Type Description OSCIN 1.2-V Oscillator Input OSCOUT 1.2-V Oscillator Output OSCVDD Oscillator 1.2-V VDD tap point (for filter only)
Page 41
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-6 Q281 : M12L64164A-7TG ( 1M x 16 Bit x 4 Banks Synchronous DRAM ) BLOCK DIAGRAM PIN LAYOUT TOP VIEW Clock Generator DQ15 Bank D VDDQ VSSQ Bank C DQ14 Bank B DQ13...
Page 42
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-7 Q282 : ES29LV160ET-70TG ( 16Mbit CMOS 3.0 Volt-only, Boot Sector Flash Memory ) BLOCK DIAGRAM RY/BY# Timer/ Vcc Detector Counter DQ0-DQ15(A-1) Analog Bias Generator Input/Output Buffers Write Command State Register Machine RESET# Data Latch/...
Page 43
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-8 Q301 CS42518 (8-Ch Codec with S/PDIF Receiver)-1/4 BLOCK DIAGRAM VARX AGND LPFLT DGND DGND VD RXP0 RXP1/GPO1 RXP2/GPO2 C&U Bit Control RXP3/GPO3 Data Buffer AD0/CS S/P DIF Clock/Data Port RXP4/GPO4 AD1/CDIN Recovery Decoder...
Page 45
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-10 Q301 : CS42518 (8-Ch Codec with S/PDIF Receiver)-3/4 TERMINAL DESCRIPTION Name Pin No. Function AD0/CS Address Bit 0 (I2C)/Control Port Chip Select (SPI) (INput) - AD0 is a chip address pin in I2C mode; CS is the chip select signal in SPI mode.
Page 46
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-11 Q301 : CS42518 (8-Ch Codec with S/PDIF Receiver)-4/4 TERMINAL DESCRIPTION Name Pin No. Function CL_SDOUT CODEC Serial Data Output (Output) - Output for two's complement serial audio data the internal and external ADCs.
Page 48
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-13 Q3001 : AN15880A (Video SW for Receiver with Multi-signal)-2/3 TERMINAL DESCRIPTION (1/2) Pin No. Pin name Type Descripion Input Luminance signal input 1 Input Luminance signal input 2 Input Luminance signal input 3...
Page 49
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-14 Q3001 : AN15880A(Video SW for Receiver with Multi-signal)-3/3 TERMINAL DESCRIPTION (2/2) Pin No. Pin name Type Description No connection CYOUT1 signal output CYOUT1 Output Ground GND4 Ground COUT3 signal output COUT3 Output COUT2 signal output...
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-15 Q5501 : R2S15211FP (8 ch Electronic Volume and 11 Input Selector and Tone Control)-1/3 SYSTEM BLOCK DIAGRAM Multi Multi Rch Tone Lch Tone CLOCK DATA MCU I/F Tone Bass & Volume Volume Treble...
Page 51
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-16 Q5501 : R2S15211FP (8 ch Electronic Volume and 11 Input Selector and Tone Control)-2/3 BLOCK DIAGRAM AND PIN CONFIGURATION 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25...
Page 52
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-17 Q5501 : R2S15211FP (8 ch Electronic Volume and 11 Input Selector and Tone Control)-3/3 TERMINAL DESCRIPTION PIN No. Name Function 19,17, FROUT,FLOUT, 14,12, 6-OUT,5-OUT, Output pin of FL/FR/C/SW/SL/SR/SBL/SBR channel 4-OUT, 3-OUT, 9,7, 2-OUT,1-OUT...
Page 53
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-18 Q7003 : M66005-0001AHP (FL Tube Driver) BLOCK DIAGRAM Display code RAM SEG00 CG ROM Bank 1 : 8bit x 16 (35bit x 160) Bank 2 : 8bit x 64 SEG26 Segment output SEG27...
Page 54
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-19 Q8162 : SiI9185ACTU (Three Input, Single Output Deep Color HDMI Switch)-1/3 BLOCK DIAGRAM R0X0+/- EDID Configuration R0X1+/- I C Switch Logic R0X2+/- R0XC+/- Serializer / TX0+/- Tx Driver R1X0+/- Serializer / R1X1+/- TX1+/-...
Page 55
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-20 Q8162 : SiI9185ACTU (Three Input, Single Output Deep Color HDMI Switch)-2/3 TERMINAL DESCRIPTION System switching Pin Name Pin # Description DSDA0, Input / DDC I C Data for respective port. DSDA1, Output DSDA2...
Page 56
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-21 Q8162 : SiI9185ACTU (Three Input, Single Output Deep Color HDMI Switch)-3/3 TERMINAL DESCRIPTION Differential Signal Data Pins Pin Name Pin # Description RX0+ 20, 41, 62 Input TMDS input data pairs. RX0- 21, 42, 61...
Page 57
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-22 Q8401 : SiI9034CTU (HDMI Transmitter)-1/4 BLOCK DIAGRAM E-DDC CSDA DSDA Master DSCL Slave CSCL Registers CI2CA Receiver Sense + Interrupt Logic Configuration Logic Block RESET# HDCP Keys Video Data EXT_SWING IDCK encrypted Capture /...
Page 59
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-24 Q8401 : SiI9034CTU (HDMI Transmitter)-3/4 TERMINAL DESCRIPTION Video and Audio Input pins Pin Name Pin # Description Input These are the lower 12 bits of the 24-bit pixel bus. Input These pins are highly configurable, and support multiple RGB and YCbCr formats.
Page 60
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-25 Q8401 : SiI9034CTU (HDMI Transmitter)-4/4 TERMINAL DESCRIPTION Configuration / Programming Pins Pin Name Pin # Description Input Hot Plug Detect Input. RSVDL Input Reserved for use by Silicon Image and must be tied LOW.
Page 63
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-28 Q8051 : SiI9013 ( HDMI Receiver)-3/4 TERMINAL DESCRIPTION Digital video Output Pins Pin Name Pin # Description Pin Name Pin # Description Output Output Output Output Output 24-Bit Even Pixel Output 24-Bit Odd Pixel...
Page 64
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-29 Q8051 : SiI9013 ( HDMI Receiver)-4/4 TERMINAL DESCRIPTION Configuration / Programming Pins Pin Name Pin # Description Output Interrupt Output. RESET# Input Reset Pin. Active LOW. Note that this pin must be dynamically controlled as part of normal operation.
Page 65
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-30 Q6310 : M61540FP (6ch Electronic Volume with 5 Input Selector)-1/2 BLOCK DIAGRAM MCU I/F DVDD Gain Gain Control Control SLOUT BASL2 SROUT BASL1 Gain Gain Gain Gain Control Control Control Control Bass /Tre...
Page 66
DTR-4.9 IC BLOCK DIAGRAMS AND TERMINAL DESCRIPTIONS-31 Q6310 : M61540FP (6ch Electronic Volume with 5 Input Selector)-2/2 TERMINAL DESCRIPTION Pin No. Pin Name Description 1, 8, 25, 32 AGND Analog Ground Input pin of L channel (Multi) Input pin of R channel (Multi)
Page 69
DTR-4.9 MICROPROCESSOR TERMINAL DESCRIPTIONS-1 Q701 : MPD70F3746 (Main Microprocessor) Pin No. Pin Name Act. Description AVREF Power supply. (A/D reference) AVSS Ground. FANCTRL Not used. VDLOCK INT signal input from Video signal processor (FLI30502). AVREF Power supply. (D/A reference) VSPREQ Video signal processor (FLI30502) handshaking 1.
Page 70
DTR-4.9 MICROPROCESSOR TERMINAL DESCRIPTIONS-2 Q701 : MPD70F3746 (Main Microprocessor) Pin No. Pin Name Act. Description DSPCLK DSP IC (D788E001) clock output. MUTE_RX HDMI receiver IC (SiI9013) RXMUTE signal input. RST_RX HDMI switch IC (SiI9185) reset signal output. CECOUT CEC (consumer electronic control) signal output.
Page 71
DTR-4.9 MICROPROCESSOR TERMINAL DESCRIPTIONS-3 Q701 : MPD70F3746 (Main Microprocessor) Pin No. Pin Name Act. Description VSW_S7 Video switch IC (AN15880A) control. VSW_S8 Video switch IC (AN15880A) control. Ground. VCC2 Power supply. SBZ2MUT Surround back/ Zone 2 muting control. PRRLF Preout (front L/R) relay control.
DTR-4.9 SERVICE PROCEDURE-1 1. Replacing the fuses This symbol located near the fuse indicates that the fuse used is show operating type, For continued protection against fire hazard, replace with same type fuse, For fuse rating, refer to the marking adjacent to the symbol.
Page 73
DTR-4.9 SERVICE PROCEDURE-2 5. To check version of Main microprocessor, DSP and Network microprocessor FW 1. Press and hold down Display button, then press On/Standby button when the unit is power on. The main microprocessor version will be displayed on Front Display for about 3 seconds.
Page 74
DTR-4.9 OPERATION CHECK-1 SPEAKER PROTECT-1 Circuit configuration The unit go into protect mode when either of thermal detection, dc voltage detection or current detection circuit operates. Power amplifier VPRO : DC voltage detection IPRO : Current detection Q6070 Q6071 Thermal sensor...
Page 75
DTR-4.9 OPERATION CHECK-2 SPEAKER PROTECT-2 DC Voltage detection check [When] 1. Exchange power transistors (Q6050 - Q6054, Q6060 - Q6064). 2. Exchange amplifier PC board ass'y (NAAF-9424). [Procedure] Note : No load. No input. 1. Press and hold down CD button, then press On/Standby button while the unit is powered on.
DTR-4.9 OPERATION CHECK-3 SPEAKER PROTECT-3 Current detection check [When] 1. Exchange power transistors (Q6050 - Q6054, Q6060 - Q6064). 2. Exchange amplifier PC board ass'y (NAAF-9424). [Procedure] Notes : No input. Do not check two or more channels at the same time.
Page 77
DTR-4.9 OPERATION CHECK-4 POWER SUPPLY CONTROL Configuration The power supply voltage of +/-B1 for power amplifier is changed by the relays (RL6901, 6902). Output sensor RL6901 Power amplifier S1H+ +22V S1H- Thermal sensor Q6380 RL6902 D6901 To Power amp. S1L+...
DTR-4.9 FIRMWARE UPDATE-1 GENERAL To check version of Main Microprocessor, DSP and Video FW 1. Press and hold down Display Display button, then press On/Standby On/Standby button when the unit is power on. The main microprocessor version will be displayed on Front Display for about 3 seconds.
Page 79
DTR-4.9 FIRMWARE UPDATE-2 UPDATE OF MAIN MICROPROCESSOR-2/2 Update Procedure 1. Double click "Update.exe Update.exe" in the unzipped folder "Update_SR606Main1.2.zip” (Folder name depends on the version). The following window will appear. Updater COM Port(C) Log Visible Firmware Read Result 001. F0000007 / FF000000 002.
Page 80
DTR-4.9 FIRMWARE UPDATE-3 UPDATE OF DSP Preparation for update Update is done by playback of CD-R in a CD player. Tool 1. Blank CD-R : 1pc, PC (Personal computer with CD-R writer) 2. Writing soft : “CD_SR6060_08213A.wav” (File name depends on the version.) <Note>...
DTR-4.9 DEBUG MODE-1 DSP DEBUG MODE-1 The operations of DSP and DIR etc are able to checked by the information displayed on FL in this debug mode. This information will help to analysing digital audio no sound trouble. To set in Debug mode 1.
Page 82
DTR-4.9 DEBUG MODE-2 DSP DEBUG MODE-2 Content of Display (Continued) DSP Port DSP Decode This figure is displayed in hexadecimal form. o = Decode OK If this is transformed to binary form, each bit indicates x = Decode NG the following DSP port status. Refeo to <Fig-1>.
Page 83
DTR-4.9 DEBUG MODE-3 DSP DEBUG MODE-3 Trouble Shooting by DSP DEBUG MODE (Continued) Symptom on FL display Cause of trouble Remedy Digit No. on FL Continue to display "1" Interface between DSP and MPU is no good. The same remedy as 10 -b.
Page 84
DTR-4.9 DEBUG MODE-4 SERVICE INFORMATION MODE Trouble Shooting by Displaying Service information This service information display system is helpful in analyze the status when the unit goes into Protect mode and is powered off. Pay attention that the status will change if a button is pushed.
Page 85
DTR-4.9 DEBUG MODE-5 HDMI DEBUG MODE-1/2 HDMI-related operations can be checked to some extent by displaying HDMI debug mode. To enter this mode Hold down Display Display button for 3 seconds. Information display will last for about 8 seconds. Content of Display FL Display Segment No.
Page 86
DTR-4.9 DEBUG MODE-6 HDMI DEBUG MODE-2/2 FL segment No. ---> Video Input Format Status Description Video signal route : Source Device HDMI Through Video resolution is not Determined Error State ---> Remedy Input Input Description ---> i/p/I/P Frame Rate Horizontal Resolution...
Page 87
HDMI VIDEO SETUP TROUBLE This trouble shooting map focuses on the video setup errors regarding HDMI. For reference, read DTR-4.9 Owner’s Manual. Analysis written below is of typical cases. So, more detailed check may need in actual cases. Video trouble...
Page 88
HDMI AUDIO SETUP TROUBLE This trouble shooting map focuses on the audio setups and connections regarding HDMI. For reference, read DTR-4.9 Owner’s Manual. Analysis written below is of typical cases. So, more detailed check may need in actual cases. Audio trouble...
DTR-4.9 ADJUSTMENT PROCEDURE-1 IDLING CURRENT ADJUSTMENT [When] 1. Exchange Power transistor (Q6050 - Q6054, Q6060 - Q6064). 2. Amplifier PC board (NAAF-9424). [Procedure] Refer to "ADJUSTMENT PROCEDURE-2 " for the adjustment points and the test points. <Note> No load and No signal 1.
Page 90
DTR-4.9 ADJUSTMENT PROCEDURE-2 IDLING CURRENT ADJUSTMENT Adjustment points and the test points Front side Adjustment point Test point (Trimming resistor) P6086 R6044 P6084 Surround Amplifier PC board Right ch (NAAF-9424) P6084 R6041 P6081 P6081 Front Right ch R6042 R6042 P6082...
1/76 PAGE DTR-4.9 <Note> Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. NOTE : THE COMPONENTS IDENTIFIED BY THE MARK ! ARE CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK. REPLACE ONLY WITH PART NUMBER SPECIFIED.
Page 94
4/76 PAGE Q6062 or MP130S-P 2203676 EXPLODED Q6063 MP130S-O 2203673 EXPLODED Q6063 or MP130S-Y 2203674 EXPLODED Q6063 or MP130S-P 2203676 EXPLODED Q6064 MP130S-O 2203673 EXPLODED Q6064 or MP130S-Y 2203674 EXPLODED Q6064 or MP130S-P 2203676 EXPLODED <Note> EXPLODED Must use the same HFE rank mutually about the following parts. EXPLODED Ref.
EXPLODED TUNER UNIT ENG06507QFUS 240156 EXPLODED U45 or TUNER UNIT FAE385-A11US 240152 EXPLODED DTR-4.9 PC BOARD PARTS LIST AMPLIFIER PC BOARD (NAAF-9424-1E) PCB1 TRANS. SEC. TERMINAL PC BOARD (NAPS-9425-1E) PCB1 THERMAL SENSOR PC BOARD (NAETC-9426-1E) PCB1 PCB1 CIRCUIT NO. PART NAME DESCRIPTION Q'TY PART NO.
Page 98
8/76 PAGE D6001 C-DIODE KDS4148U 223283R2 PCB1 D6001 or C-DIODE 1SS352 223234R2 PCB1 D6001 or C-DIODE MA2J111 223279R2 PCB1 D6002 C-DIODE KDS4148U 223283R2 PCB1 D6002 or C-DIODE 1SS352 223234R2 PCB1 D6002 or C-DIODE MA2J111 223279R2 PCB1 D6003 C-DIODE KDS4148U 223283R2 PCB1 D6003 or C-DIODE...
Page 99
9/76 PAGE D6703 ZENER D UDZ3.3B 224490330R2 PCB1 D6703 or ZENER D UDZS3.3B 224550330R2 PCB1 D6704 ZENER D UDZ3.3B 224490330R2 PCB1 D6704 or ZENER D UDZS3.3B 224550330R2 PCB1 D6901 DIODE D10XB60H 22380337 PCB1 D6901A HEAT SINK RAD-196 27160545 PCB1 D6901C SCREW 3P+10FN(3BC) 82143010GR...
Page 100
10/76 PAGE C5554 UTSP C CE04W25V-47M(UTSP) 397554707T PCB1 C5555 UTSP C CE04W25V-47M(UTSP) 397554707T PCB1 C5556 UTSP C CE04W25V-47M(UTSP) 397554707T PCB1 C5557 UTSP C CE04W25V-47M(UTSP) 397554707T PCB1 C5558 UTSP C CE04W25V-47M(UTSP) 397554707T PCB1 C5559 TF C ECQ-V50V-474J 374724744T PCB1 C5560 TF C ECQ-V50V-823J 374728234T PCB1...
Page 101
11/76 PAGE C5667 UTSP C CE04W25V-220M(UTSP) 397552217T PCB1 C5670 UTSP C CE04W50V-1M(UTSP) 397580107T PCB1 C5671 UTSP C CE04W50V-1M(UTSP) 397580107T PCB1 C5672 UTSP C CE04W25V-220M(UTSP) 397552217T PCB1 C5673 UTSP C CE04W25V-220M(UTSP) 397552217T PCB1 C5674 UTSP C CE04W16V-470M(UTSP) 397544717T PCB1 C5675 UTSP C CE04W16V-470M(UTSP) 397544717T PCB1...
Page 102
12/76 PAGE C6050 TF C ECQ-B50V-103J 374721034T PCB1 C6051 TF C ECQ-B50V-103J 374721034T PCB1 C6052 TF C ECQ-B50V-103J 374721034T PCB1 C6053 TF C ECQ-B50V-103J 374721034T PCB1 C6054 TF C ECQ-B50V-103J 374721034T PCB1 C6630 C-CERA C CK725F1E-104Z1 332161040R1 PCB1 C6701 UTSP C CE04W25V-100M(UTSP) 397551017T PCB1...
Page 103
13/76 PAGE R5514 C-CARBON R RN72K1J-331JE 435033314R1 PCB1 R5515 C-CARBON R RN72K1J-222JE 435032224R1 PCB1 R5516 C-CARBON R RN72K1J-222JE 435032224R1 PCB1 R5517 C-CARBON R RN72K1J-331JE 435033314R1 PCB1 R5518 C-CARBON R RN72K1J-331JE 435033314R1 PCB1 R5519 C-CARBON R RN72K1J-331JE 435033314R1 PCB1 R5520 C-CARBON R RN72K1J-331JE 435033314R1 PCB1...
Page 104
14/76 PAGE R5575 C-CARBON R RN72K1J-224JE 435032244R1 PCB1 R5576 C-CARBON R RN72K1J-224JE 435032244R1 PCB1 R5577 C-CARBON R RN72K1J-473JE 435034734R1 PCB1 R5578 C-CARBON R RN72K1J-473JE 435034734R1 PCB1 R5579 C-CARBON R RN72K1J-224JE 435032244R1 PCB1 R5585 C-CARBON R RN72K1J-182JE 435031824R1 PCB1 R5586 C-CARBON R RN72K1J-182JE 435031824R1 PCB1...
Page 105
15/76 PAGE R5617 C-CARBON R RN72K1J-222JE 435032224R1 PCB1 R5618 C-CARBON R RN72K1J-000JE 435030004R1 PCB1 R5619 C-CARBON R RN72K1J-000JE 435030004R1 PCB1 R5620 C-CARBON R RN72K1J-101JE 435031014R1 PCB1 R5623 C-CARBON R RN72K1J-000JE 435030004R1 PCB1 R5624 C-CARBON R RN72K1J-000JE 435030004R1 PCB1 R5625 C-CARBON R RN72K1J-000JE 435030004R1 PCB1...
Page 106
16/76 PAGE R5822 C-CARBON R RN72K1J-000JE 435030004R1 PCB1 R5823 METAL O R RS1WBJ-33 443623304T PCB1 R5824 METAL O R RS1WBJ-33 443623304T PCB1 R5831 C-CARBON R RN72K1J-000JE 435030004R1 PCB1 R5832 C-CARBON R RN72K1J-000JE 435030004R1 PCB1 R5833 C-CARBON R RN72K1J-000JE 435030004R1 PCB1 R5834 C-CARBON R RN72K1J-000JE...
Page 107
17/76 PAGE R6042 TRIM R N06HR2KBC 5210390T PCB1 R6043 TRIM R N06HR2KBC 5210390T PCB1 R6044 TRIM R N06HR2KBC 5210390T PCB1 R6050 CARBON R R16J-3.3K 417343324T PCB1 R6051 CARBON R R16J-3.3K 417343324T PCB1 R6052 CARBON R R16J-3.3K 417343324T PCB1 R6053 CARBON R R16J-3.3K 417343324T PCB1...
Page 108
18/76 PAGE R6140 C-CARBON R RN72K1J-223JE 435032234R1 PCB1 R6141 C-CARBON R RN72K1J-223JE 435032234R1 PCB1 R6142 C-CARBON R RN72K1J-223JE 435032234R1 PCB1 R6143 C-CARBON R RN72K1J-223JE 435032234R1 PCB1 R6144 C-CARBON R RN72K1J-223JE 435032234R1 PCB1 R6150 C-CARBON R RN72K1J-123JE 435031234R1 PCB1 R6151 C-CARBON R RN72K1J-123JE 435031234R1 PCB1...
Page 109
19/76 PAGE R6704 C-CARBON R RN72K1J-473JE 435034734R1 PCB1 R6706 C-CARBON R RN72K1J-224JE 435032244R1 PCB1 R6708 C-CARBON R RN72K1J-333JE 435033334R1 PCB1 R6709 C-CARBON R RN72K1J-562JE 435035624R1 PCB1 R6710 C-CARBON R RN72K1J-472JE 435034724R1 PCB1 R6902 C-CARBON R RN72K1J-102JE 435031024R1 PCB1 R6903 C-CARBON R RN72K1J-473JE 435034734R1 PCB1...
21/76 PAGE TRANS. SEC. TERMINAL PC BOARD (NAPS-9447-1D) PCB2 SETUP MIC JACK PC BOARD (NAETC-9448-1D) PCB2 HEADPHONE JACK PC BOARD (NAETC-9449-1D) PCB2 INLET PC BOARD (NAETC-9451-1D) PCB2 ZONE 2 / IR PC BOARD (NAETC-9452-1D) PCB2 PCB2 CIRCUIT NO. PART NAME DESCRIPTION Q'TY PART NO.
Page 112
22/76 PAGE Q7004 or 2SC1740S-R 2213284T PCB2 Q7004 or 2SC1740S-S 2213285T PCB2 Q7033 KTC3198-GR 2215985T PCB2 Q7033 or 2SC1815-GR 2211255T PCB2 Q7152 2SA1015-Y 2211454T PCB2 Q7402 NJM4580D-D 22241112 PCB2 D6019 DIODE 1SS133 223163T PCB2 D6021 ZENER D MTZJ7.5B 224470752T PCB2 D6022 ZENER D MTZJ3.6B...
Page 113
23/76 PAGE D933 DIODE 1SS133 223163T PCB2 D934 ZENER D MTZJ5.1B 224470512T PCB2 D935 DIODE 1SS133 223163T PCB2 T902 P TRANS NPT-1520JQ 2301812A PCB2 C901 IS C LE103-C3.5 3800042S PCB2 C901 or IS C ECQU2A103MLC 3800039S PCB2 C902 TF C ECQ-V50V-104J 374721044T PCB2...
Page 114
24/76 PAGE C6031 TF C ECQ-B50V-102J 374721024T PCB2 C6032 UTSP C CE04W16V-470M(UTSP) 397544717T PCB2 C6033 CERA C CK45B50V-102K 335321025T PCB2 C6034 UTSP C CE04W25V-220M(UTSP) 397552217T PCB2 C7001 CERA C CK45F50V-223Z 335622230T PCB2 C7002 MMT C MMT50V-104J 375521044T PCB2 C7003 CERA C CC45SL50V-101J 345021014T PCB2...
Page 124
34/76 PAGE C313 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C314 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C315 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C316 C-CERA C CC725CH1H-221J1 342102214R1 PCB3 C317 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C318 C-CERA C CC725CH1H-060D1 342100602R1 PCB3 C319 C-CERA C CC725CH1H-060D1 342100602R1 PCB3...
Page 125
35/76 PAGE C364 C-CERA C CC725CH1H-101J1 342101014R1 PCB3 C365 UTSP C CE04W50V-10M(UTSP) 397581007T PCB3 C366 UTSP C CE04W50V-10M(UTSP) 397581007T PCB3 C367 UTSP C CE04W50V-10M(UTSP) 397581007T PCB3 C368 UTSP C CE04W50V-10M(UTSP) 397581007T PCB3 C369 C-FILM C ECHU50V-222J 373022224R2 PCB3 C370 C-FILM C ECHU50V-222J 373022224R2 PCB3...
Page 126
36/76 PAGE C602 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C603 UTSP C CE04W50V-4.7M(UTSP) 397580477T PCB3 C605 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C606 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C607 UTSP C CE04W50V-4.7M(UTSP) 397580477T PCB3 C608 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C609 C-CERA C CK725F1E-104Z1 332161040R1 PCB3...
Page 127
37/76 PAGE C644 UTSP C CE04W50V-0.47M(UTSP) 397584797T PCB3 C645 UTSP C CE04W50V-1M(UTSP) 397580107T PCB3 C646 UTSP C CE04W50V-1M(UTSP) 397580107T PCB3 C647 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C1001 C-CERA C CK725F1E-104Z1 332161040R1 PCB3 C1002 C-CERA C CK725B1H-103K1 332101035R1 PCB3 C1003 C-CERA C CK725B1H-103K1 332101035R1 PCB3...
Page 128
38/76 PAGE R315 C-CARBON R RN72K1J-470JE 435034704R1 PCB3 R316 C-CARBON R RN72K1J-470JE 435034704R1 PCB3 R317 C-CARBON R RN72K1J-331JE 435033314R1 PCB3 R318 C-CARBON R RN72K1J-331JE 435033314R1 PCB3 R319 C-CARBON R RN72K1J-331JE 435033314R1 PCB3 R321 C-CARBON R RN72K1J-331JE 435033314R1 PCB3 R322 C-CARBON R RN72K1J-470JE 435034704R1 PCB3...
Page 129
39/76 PAGE R355 C-CARBON R RN72K1J-224JE 435032244R1 PCB3 R356 C-CARBON R RN72K1J-224JE 435032244R1 PCB3 R361 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R362 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R363 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R364 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R365 C-CARBON R RN72K1J-560JE 435035604R1 PCB3...
Page 130
40/76 PAGE R433 C-CARBON R RN72K1J-471JE 435034714R1 PCB3 R434 C-CARBON R RN72K1J-471JE 435034714R1 PCB3 R435 C-CARBON R RN72K1J-471JE 435034714R1 PCB3 R436 C-CARBON R RN72K1J-471JE 435034714R1 PCB3 R441 C-CARBON R RN72K1J-472JE 435034724R1 PCB3 R442 C-CARBON R RN72K1J-472JE 435034724R1 PCB3 R443 C-CARBON R RN72K1J-472JE 435034724R1 PCB3...
Page 131
41/76 PAGE R576 C-CARBON R RN72K1J-000JE 435030004R1 PCB3 R591 METAL O R RS1/2WBJ-22 443522204T PCB3 R592 METAL O R RS1/2WBJ-22 443522204T PCB3 R602 C-CARBON R RN72K1J-470JE 435034704R1 PCB3 R603 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R604 C-CARBON R RN72K1J-221JE 435032214R1 PCB3 R605 C-CARBON R RN72K1J-473JE...
Page 132
42/76 PAGE R640 C-CARBON R RN72K1J-272JE 435032724R1 PCB3 R641 C-CARBON R RN72K1J-272JE 435032724R1 PCB3 R642 C-CARBON R RN72K1J-272JE 435032724R1 PCB3 R643 C-CARBON R RN72K1J-470JE 435034704R1 PCB3 R644 C-CARBON R RN72K1J-470JE 435034704R1 PCB3 R645 C-CARBON R RN72K1J-102JE 435031024R1 PCB3 R646 C-CARBON R RN72K1J-470JE 435034704R1 PCB3...
Page 133
43/76 PAGE R677 C-CARBON R RN72K1J-221JE 435032214R1 PCB3 R678 C-CARBON R RN72K1J-221JE 435032214R1 PCB3 R679 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R680 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R681 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R682 C-CARBON R RN72K1J-103JE 435031034R1 PCB3 R683 C-CARBON R RN72K1J-103JE 435031034R1 PCB3...
Page 134
44/76 PAGE R718 C-CARBON R RN72K1J-221JE 435032214R1 PCB3 R719 C-CARBON R RN72K1J-221JE 435032214R1 PCB3 R720 C-CARBON R RN72K1J-470JE 435034704R1 PCB3 R721 C-CARBON R RN72K1J-470JE 435034704R1 PCB3 R722 C-CARBON R RN72K1J-470JE 435034704R1 PCB3 R723 C-CARBON R RN72K1J-221JE 435032214R1 PCB3 R724 C-CARBON R RN72K1J-221JE 435032214R1 PCB3...
Page 135
45/76 PAGE R752 C-CARBON R RN72K1J-272JE 435032724R1 PCB3 R753 C-CARBON R RN72K1J-272JE 435032724R1 PCB3 R754 C-CARBON R RN72K1J-272JE 435032724R1 PCB3 R755 C-CARBON R RN72K1J-473JE 435034734R1 PCB3 R757 C-CARBON R RN72K1J-221JE 435032214R1 PCB3 R760 C-CARBON R RN72K1J-473JE 435034734R1 PCB3 R761 C-CARBON R RN72K1J-473JE 435034734R1 PCB3...
Page 136
46/76 PAGE R799 C-CARBON R RN72K1J-102JE 435031024R1 PCB3 R1001 C-CARBON R MCR03EZPF49R9(49.9_1%) 4100037R2 PCB3 R1002 C-CARBON R MCR03EZPF49R9(49.9_1%) 4100037R2 PCB3 R1003 C-CARBON R MCR03EZPF49R9(49.9_1%) 4100037R2 PCB3 R1004 C-CARBON R MCR03EZPF49R9(49.9_1%) 4100037R2 PCB3 R1005 C-CARBON R RN72K1J-222JE 435032224R1 PCB3 R1006 C-CARBON R RN72K1J-331JE 435033314R1 PCB3...
Page 139
49/76 PAGE D9022 DIODE RL1N4003 22380260T PCB4 D9023 C-DIODE KDS4148U 223283R2 PCB4 D9023 or C-DIODE 1SS352 223234R2 PCB4 D9023 or C-DIODE MA2J111 223279R2 PCB4 C3001 VR C CE04W16V-100M(VR) 394641017T PCB4 C3002 C-CERA C CK725F1E-104Z1 332161040R1 PCB4 C3003 UTSP C CE04W50V-22M(UTSP) 397582207T PCB4 C3004...
Page 140
50/76 PAGE C3038 C-CERA C CK725F1E-104Z1 332161040R1 PCB4 C3039 C-CERA C CK725B1H-102K1 332101025R1 PCB4 C3040 UTSP C CE04W50V-10M(UTSP) 397581007T PCB4 C3041 UTSP C CE04W50V-10M(UTSP) 397581007T PCB4 C3042 C-CERA C CK725F1E-104Z1 332161040R1 PCB4 C3043 C-CERA C CK725B1H-102K1 332101025R1 PCB4 C3044 UTSP C CE04W50V-1M(UTSP) 397580107T PCB4...
Page 141
51/76 PAGE C9012 TF C ECQ-V50V-334J 374723344T PCB4 C9013 UTSP C CE04W50V-2.2M(UTSP) 397580227T PCB4 C9014 UTSP C CE04W50V-1M(UTSP) 397580107T PCB4 C9023 UTSP C CE04W50V-10M(UTSP) 397581007T PCB4 C9025 VR C CE04W6.3V-470M(VR) 394624717T PCB4 C9030 UTSP C CE04W25V-220M(UTSP) 397552217T PCB4 C9031 C-CERA C CK725F1E-104Z1 332161040R1 PCB4...
Page 142
52/76 PAGE R3041 C-CARBON R RN72K1J-750JE 435037504R1 PCB4 R3042 C-CARBON R RN72K1J-750JE 435037504R1 PCB4 R3043 C-CARBON R RN72K1J-750JE 435037504R1 PCB4 R3050 C-CARBON R RN72K1J-000JE 435030004R1 PCB4 R3051 C-CARBON R RN72K1J-000JE 435030004R1 PCB4 R3052 C-CARBON R RN72K1J-000JE 435030004R1 PCB4 R3053 C-CARBON R RN72K1J-000JE 435030004R1 PCB4...
Page 143
53/76 PAGE R6692 METAL O R RS1/2WBJ-390 443523914T PCB4 R9001 METAL O R RS1WBJ-220 443622214T PCB4 R9002 C-CARBON R RN72K1J-822JE 435038224R1 PCB4 R9003 C-CARBON R RN72K1J-822JE 435038224R1 PCB4 R9004 C-CARBON R RN72K1J-333JE 435033334R1 PCB4 R9011 METAL R RNU1/2WCJ-4.7 453530474T PCB4 R9012 METAL R RNU1/2WCJ-1...
Page 144
54/76 PAGE P3004 PIN JACK NPJ-5PDSY629 25045850 PCB4 P3004 or PIN JACK NPJ-5PDBY482 25045685 PCB4 P3005 PIN JACK NPJ-9PDGLR630 25045851 PCB4 P3005 or PIN JACK NPJ-9PDGLR520 25045732 PCB4 P6601 NTM-2PDMCR400 25060472 PCB4 P6602 NTM-4PDMNRR420 25060492 PCB4 P6603 NTM-4PDMNRR420 25060492 PCB4 E9001 TRM-423(SCREW) NEJITANSI ST3...