SPECIFICATIONS A340 (EZ) A360 (LH) • • Design and specifications are subject to change without Design and specifications are subject to change without notice notice...
Page 3
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING This set employs laser. Therefore, be sure to follow carefully the CAUTION instructions below when servicing. Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous WARNING! radiation exposure.
Page 4
Precaution to replace Optical block (SF-P101NR) Body or clothes electrostatic potential could ruin laser diode in the optical block. Be sure ground body and workbench, and use care the clothes do not touch the diode. 1) After the connection, remove solder shown in the right figure.
Page 5
ELECTRICAL MAIN PARTS LIST-1/4 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION C401 87-010-403-080 CAP, ELECT 3.3-50V C402 87-010-197-080 CAP, CHIP 0.01 DM 87-A20-955-010 IC,LA1828 C403 87-010-263-080 CAP, ELECT 100-10V 87-A21-193-010 IC,TA8227P C404 87-010-248-080 CAP, ELECT 220-10V 87-A21-443-040 C-IC,M62495AFP C405...
Page 6
ELECTRICAL MAIN PARTS LIST-2/4 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION C490 87-012-368-080 C-CAP,S 0.1-50 F C830 87-010-178-080 CHIP CAP 1000P C491 87-018-134-080 CAPACITOR,TC-U 0.01-16 C834 87-010-248-080 CAP, ELECT 220-10V C492 87-010-221-080 CAP, ELECT 470-10V C843 87-018-134-080 CAPACITOR,TC-U 0.01-16...
Page 7
ELECTRICAL MAIN PARTS LIST-3/4 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION 87-010-314-080 C-CAP,S 22P-50V C902 87-A11-146-080 CAP,TC U 0.022-50 Z F 87-010-316-080 C-CAP,S 33P-50 CH C903 87-A11-146-080 CAP,TC U 0.022-50 Z F 87-010-314-080 C-CAP,S 22P-50V C904 87-A11-146-080 CAP,TC U 0.022-50 Z F...
Page 8
ELECTRICAL MAIN PARTS LIST-4/4 • Regarding connectors, they are not stocked as they are not the initial order items. The connectors are available after they are supplied from connector manufacturers upon the order is received. CHIP RESISTOR PART CODE Chip Resistor Part Coding Figure Resistor Code Value of resistor...
Page 9
IC BLOCK DIAGRAM-1/2 IC, BA4560N IC, LA1828...
Page 10
IC BLOCK DIAGRAM-2/2 IC, M62495AFP AUTO RESET IC, MM1469XH DRIVER MUTE T.S.D -10-...
Page 11
WIRING-1/6 (MAIN/MOTOR) MAIN-CD C.B CD DOOR TO FRONT C.B (INSERTED PARTS) CN602 PHONES MSJ-2000 MAIN SP 7Ω 3W (R-CH) (L-CH) TO BATT1 C.B CNA901 NOTE E C B E C B E C B TAPE MECHANISM ZZM-1 AR2NC – TO CD MECHANISM (TAPE MOTOR) DA-11T3C (TAPE SW)
Page 16
SCHEMATIC DIAGRAM-3/5 (FRONT) FRONT C.B STANDBY OPE/BATT SFT LED SYSTEM LED SW CONTROL RADIO Q606,607 LED SW 0.01 REPEAT R653 1K KEY C.B CLK-SHIFT SW LED SW CNA604 CN605 CONN ASSY 3P 0.01 CONN3P RESET DIGIT SW DTC124YS TRACK VOLUME/3-MODE EQ S601 REPEAT SLEEP/OSC S607 RADIO...
Page 17
WIRING-4/6 (BATT1/BATT2) BATT 2 C.B (INSERTED PARTS) – DRY BATTERY R14 x 8 DC 12V BATT 1 C.B (INSERTED PARTS) TO MAIN-CD C.B CN301 – A340 (EZ) MODEL J901 PT901 230V/50Hz A360 (LH) MODEL J901 PT901 110-120V SW901 220-240V 50/60Hz VOLTAGE SELECT 220-240V...
Page 18
WIRING-5/6 (TUNER: EZ) TUNER C.B (INSERTED PARTS) L003 BAR ANT TC003 TC004 TC002 TC001 SW001 BAND FM ROD FM (ST) (MONO) TO MAIN-TP C.B CNA302 NOTE RXXX RXXX CXXX E C B TUNER C.B (CHIP PARTS) -18-...
Page 20
WIRING-6/6 (TUNER: LH) TUNER C.B (INSERTED PARTS) CN003 CN004 L003 BAR ANT CN005 TC004 TC003 CN006 SW001 BAND TC002 TC001 FM (ST) (MONO) FM ROD TO MAIN-TP C.B CNA302 NOTE RXXX RXXX CXXX E C B TUNER C.B (CHIP PARTS) -20-...
Page 22
TRANSISTOR ILLUSTRATION-1/1 E C B E C B E C B 2SA1296 2SA933 2SA1979 2SC1815 2SC1740 DTC114TS DTC114YS DTC124XS B C E 2SC2714 2SB1370 DTC114TK DTC114YK DTC144EK -22-...
ELECTRICAL ADJUSTMENT-2/2 < TUNER SECTION > 7. FM Tracking Adjustment (LH MODEL) L004 ..............88.0MHz 1. AM Freq. Range Adjustment TC002 ..............108.0MHz L006 ............... 517kHz TC003 ..............1750kHz 8. FM IF Adjustment Settings: • Test point: IC001 (LA1828) 19PIN 2.
Page 29
IC DESCRIPTION-1/3 (LA9241ML)-1/2 Pin No. Pin Name Description Pin to which external pickup photo diode is connected. RF signal is created by adding with the FIN2 FIN1 pin signal. FE signal is created by subtracting from the FIN1 pin signal. FIN1 Pin to which external pickup photo diode is connected.
Page 30
IC DESCRIPTION-1/3 (LA9241ML)-2/2 Pin No. Pin Name Description Pin from which TES signal is output to DSP. “High Frequency Level” is used to judge whether the main beam position is on top of bit or on top of mirror. SLOF Sled servo off control input pin.
Page 31
IC DESCRIPTION-2/3 (LC78622NE)-1/2 Pin No. Pin Name Description DEFI Defect sense signal (DEF) input pin. (Connect to 0V when not used). Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V. Phase comparator output pin to control external VCO. VVSS —...
Page 32
IC DESCRIPTION-2/3 (LC78622NE)-2/2 Pin No. Pin Name Description XVDD — Crystal oscillator power supply pin. XOUT Pin to which external 16.9344 MHz crystal oscillator is connected. XVSS — Crystal oscillator GND pin. Be sure to connect to 0V. SBSY Subcode block sync signal output pin. (Not connected) EFLG C1, C2, single and dual correction monitoring pin.
Page 33
IC DESCRIPTION-3/3 (LC865516A-5T66)-1/2 Pin No. Pin Name Description ____________ SEG E SEG E control. ____________ SEG F SEG F control. ____________ SEG G SEG G control. — Not connected. ____________ RESET Micro processor reset input XT1 (IN) Connected to an external 32.768 kHz crystal oscillator. —...
Page 34
IC DESCRIPTION-3/3 (LC865516A-5T66)-2/2 Pin No. Pin Name Description — Not connected. SEG DP SEG DP control. SEG A SEG A control. SEG B SEG B control. SEG C SEG C control. SEG D SEG D control. — Not connected. -34-...
Page 35
MECHANICAL EXPLODED VIEW-1/1 CSD-A340 model CUSHION, CD A CSD-A360 model CUSHION, CD A SW-COV CSD-A360 model PLATE, PT PLATE, SHIELD ZZM-1 -35-...
Page 36
MECHANICAL PARTS LIST-1/1 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION 1 8B-CDB-142-010 CABI,ASSY FR EX (D)<6LHDC> 32 8A-CD8-604-010 PT,H 2.5W<EXCEPT 4EZLC> 1 8B-CDB-140-010 CABI,ASSY FR EX<6LHHC> 33 8B-CDB-202-010 LEVER,BAND 1 8B-CDB-143-010 CABI,ASSY FR EX (G)<6LHGC> 34 8B-CDB-205-010 DRUM,DIAL 1 8B-CDB-141-010...
Page 37
COLOR NAME TABLE Basic color symbol Color Basic color symbol Color Basic color symbol Color Black Cream Orange Green Gray Blue Transparent Blue Gold Pink Silver Titan Silver Brown Violet White Transparent White Yellow Transparent Yellow Metallic Blue Light Blue Transparent Green Dark Blue Transparent Orange...