Advertisement
User's Manual & Operating Instructions
MH-150T-DFV-A / MH-220T-DFV-A - PT-150T-SDR / PT-220T-SDR
REM-150T-DFV-O / REM-220T-DFV-O - REM-150T-SDR / REM-220T-SDR
CONSUMER: READ AND SAVE THESE INSTRUCTIONS
DANGER
Be sure to comply with the instructions and warnings provided with this heater. Failure to
comply can result in fire or explosion that can cause property loss, bodily injury, or loss
of life. Only persons who can follow and understand these instructions should operate or
service this heater. If you need heater info; such as an operating manual, labels, etcetera,
contact Pinnacle Climate Technologies at 800-641-6996.
DANGER
FOR: THE TEMPORARY HEATING OF ADEQUATELY VENTILATED BUILDINGS
OR STRUCTURES UNDER CONSTRUCTION, ALTERATION OR REPAIR. This is an
unvented portable heater that uses air (Oxygen) from within the area in which it is used.
Failure to provide adequate combustion and ventilation air will result in asphyxiation, carbon
monoxide poisoning, bodily injury or death. Refer to "Ventilation" on Page 5.
WARNING
instructions. Never use the heater in spaces which contain products such as; gasoline,
solvents, paint thinners, dust particles, volatile or airborne combustibles or any unknown
chemicals. This is an unvented portable heater. It uses air (Oxygen) from the area in which
it is used. Adequate combustion and ventilation air must be provided. Refer to "Ventilation"
on page 5. Bulk fuel storage should be a minimum of 25 feet from heater.
WARNING
Failure to comply with the precautions and instructions provided with this heater can result
in death, serious bodily injury, property loss or damage from the hazards of fire, soot pro-
duction, explosions, burns, asphyxiation or carbon monoxide poisoning. Only persons who
can read and understand these instructions should use or service this heater
FACTORY ID: 001
1 Industrial Blvd #101, Sauk Rapids, MN 56379 USA
Fax: 320-251-2922
Model Numbers
Safety Information
GENERAL HAZARD WARNING: READ AND UNDERSTAND
ALL OF THE INSTRUCTIONS IN THIS MANUAL BEFORE
ASSEMBLING, STARTING, OR SERVICING THE HEATER.
NOT FOR USE IN RESIDENTIAL LIVING AREAS OR IN
ENCLOSED SPACES WITHOUT ADEQUATE VENTILATION.
FOR OUTDOOR USE. INDOOR USE PERMITTED ONLY
FIRE, BURN, INHALATION AND EXPLOSION HAZARD. Keep
combustibles such as; building materials, paper or cardboard a
safe distance away from the heater as recommended by these
DO NOT OPERATE THIS HEATER UNTIL YOU HAVE READ
AND THOROUGHLY UNDERSTAND THESE SAFETY AND
OPERATING INSTRUCTIONS.
© 2016 Pinnacle Climate Technologies, Inc.
• Web: www.pinnacleclimate.com • Email: info@pinnacleclimate.com
.
Toll Free (800)-641-6996
•
70-400-0200-14
Advertisement
Table of Contents
Related Manuals for Master MH-150T-DFV-A
Summary of Contents for Master MH-150T-DFV-A
- Page 1 User’s Manual & Operating Instructions Model Numbers MH-150T-DFV-A / MH-220T-DFV-A - PT-150T-SDR / PT-220T-SDR REM-150T-DFV-O / REM-220T-DFV-O - REM-150T-SDR / REM-220T-SDR CONSUMER: READ AND SAVE THESE INSTRUCTIONS Safety Information GENERAL HAZARD WARNING: READ AND UNDERSTAND DANGER ALL OF THE INSTRUCTIONS IN THIS MANUAL BEFORE ASSEMBLING, STARTING, OR SERVICING THE HEATER.
- Page 2 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE DO NOT START THE HEATER WHEN EXCESS OIL HAS WARNING ACCUMULATED. WARNING DO NOT START THE HEATER WHEN THE CHAMBER IS HOT. CALIFORNIA RESIDENTS: This product contains chemicals, WARNING including lead, known to the State of California to cause birth defects or other reproductive harm.
-
Page 3: Safety Information
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Safety Information NEVER use duct work in front or rear of heater. RISK OF WARNING ELECTRIC NEVER move or handle heater while still hot. SHOCK! NEVER transport heater with fuel in tank. ALWAYS use only the electrical power (voltage and NEVER use with an external fuel tank. -
Page 4: Wiring Diagram
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED DFV Wiring Diagram TO A POWER SOURCE Wiring Diagram 1. Igniter 2. Pump 3. Motor 4. Condensor 5. Limit Control 6. Dump 7. PCB Assembly 8. Thermistor 9. Photocell 10. P-Solenoid 11. - Page 5 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE What’s In The Box: 150T-SDR/DFV / 220T-SDR/DFV Tools Needed: Tip: Be sure to remove the axle from the - Phillips Head Screw Driver side of the Styrofoam packaging. - 8 mm open end wrench Tip: Use a power screwdriver and - 19 mm open end wrench...
-
Page 6: Operation
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Operation Ventilation: TIP: If the heater does not ignite, the thermostat may be set too low. Increase - Risk of indoor air pollution and Carbon the temperature to a higher setting until the Monoxide Poisoning. -
Page 7: Maintenance
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance Long Term Storage: Service: 1. Drain fuel through the drain plug in the bottom of DO NOT TAMPER WITH THE UNIT. HAVE the fuel tank. A COMPETENT SERVICEMAN MAKE ANY 2. - Page 8 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance Service (Continued): PHOTOCELL: The photocell should be cleaned using a cotton FUEL FILTER: swab dipped in alcohol or water at least once The fuel filter should be cleaned at least twice per heating season, or more depending on per heating season.
-
Page 9: Troubleshooting Guide
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Troubleshooting Guide Problem Possible Cause Solution Heater Ignites, but main PCB shuts 1. Dirty fuel filter. 1. Clean / replace fuel filter. off after a short period of time. 2. -
Page 10: Exploded View
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Exploded View Parts List Item # Description 150T-SDR/DFV 220T-SDR/DFV Front Shell 70-001-5100 70-001-5105 Upper Shell 70-001-5010 70-001-5010 Combustion Chamber 70-011-1000 70-011-1010 Main Power PCB 70-027-2000 70-027-2000 Power PCB Case 70-027-1250 70-027-1250 PCB Lead Wire... - Page 11 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Parts List Item # Description 150T-SDR/DFV 220T-SDR/DFV Limit Control Bracket 70-019-1010 70-019-1010 Photocell 70-016-1000 70-016-1000 Photocell bracket 70-016-1010 70-016-1010 Air Draft Tube 70-300-0001 70-300-0010 Duct Bracket 70-300-0020 70-300-0020 Sirroco Fan 70-060-0001...
-
Page 12: Limited Warranty
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE LIMITED WARRANTY Pinnacle Climate Technologies, Inc. warrants this heater If Pinnacle Climate Technologies, Inc. finds the item to to the original retail purchaser only, to be free from defects be in normal operating condition, or not defective the item in material and workmanship for a period of one (1) year will be returned freight collect.