Related Manuals for Herrmidifier Herrtronic 6500 Series
Summary of Contents for Herrmidifier Herrtronic 6500 Series
- Page 1 Herrtronic 6500 Series ® READ AND SAVE THESE INSTRUCTIONS Electrode Steam Humidifiers H E R R M I D I F I E R | w w w . h e r r m i d i f i e r - h v a c . c o m ®...
-
Page 2: Table Of Contents
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l TABLE OF CONTENTS SECTION I WARRANTY Preface ................................3... -
Page 3: Section I Warranty
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l SECTION I WARRANTY Warranty HERRMIDIFIER warrants to the buyer or any user This Warranty gives you specific legal rights, and you during the duration of the Warranty that the humidifier... -
Page 4: Section Ii Unit Operation
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l SECTION II UNIT OPERATION Basic Operation Overview These cycles will repeat until:... -
Page 5: Key Features
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l Key Features Faults: Adjustable Setpoints (See Figure 13, Page 13) -
Page 6: Engineering & Application
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l Engineering and Application The Herrmidifier 6500 Series Steam Humidifiers can be applied in a variety of applications. The simplest application is to utilize NOTE: The steam distributor pipe is inherently sloped to return the condensate to the humidifier. -
Page 7: Section Iii Installation Instructions
The cabinet is designed to safely contain the working components To make the necessary connections for water fill and drain, the of the HERRMIDIFIER 6500 series humidifier and dissipate following steps are required. (Refer to Figure 4 for locations) heat to protect the electronics. Locate humidifier, steam pipe... -
Page 8: Steam Distribution
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l Steam Distribution Distributor Mounting Instructions HERRMIDIFIER supplies a stainless steel duct distributor for Sheetmetal Duct: injecting pure steam into the duct. This can be installed in the side Make a 1-1/4”... -
Page 9: Wiring
All field wiring should be routed up through the holes in the WARNING! bottom panel or in the back of the unit. Do NOT install any controls inside the HERRMIDIFIER 6500 cabinet. Installations of any extraneous devices inside the electrical compartment may cause erratic behavior of the circuitry and will VOID the warranty. -
Page 10: Installation Checklist
HERRMIDIFIER representative or the factory, the checklist is expected to be completed. If a job site visit is required from the HERRMIDIFIER representative or the factory, and the checklist has not been accurately completed, additional charges may be applied by the individual(s) representing HERRMIDIFIER. If the visit uncovers a component malfunction, the parts will be replaced under warranty. -
Page 11: Start-Up Instructions
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l SECTION IV OPERATING INSTRUCTIONS Start-up Instructions After approximately a five-second delay, the fill valve... -
Page 12: Maintenance
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l Maintenance cylinder. -
Page 13: Section V Troubleshooting Guide
SECTION V TROUBLESHOOTING GUIDE Test Points Each circuit board (see Figure 13) features three test points to All HERRMIDIFIER 6500 Series humidifiers are manufactured aid in the troubleshooting process. Each of these test points under strict quality control and are subjected to a complete works on a 0-5 VDC scale. -
Page 14: Unit Detected Faults: (Red Service Light On)
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l Unit Detected Faults (Red Service Light is ON) Problem / Symptom Probable Cause... -
Page 15: Non-Fault Activated Problems
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l Non-Fault Activated Problems Humidifier turned ON but will not Check power supply. - Page 16 I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l Problem/Symptom Reason - Correction Water “foaming”...
-
Page 17: Wiring Diagram
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l 6500-1 WIRING DIAGRAM POWER TERMINAL... -
Page 18: Exploded View
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l EST-596 FILL SUB-ASSEMBLY EST-207... -
Page 19: Parts List
I n s t a l l a t i o n , O p e r a t i o n , & M a i n t e n a n c e M a n u a l Parts List 1095 Hose clamp SS... - Page 20 HERRMIDIFIER ® 101 McNeill Rd. | Sanford, NC 27330 P: 800.884.0002 | F: 800.458.2379 | www.herrmidifier-hvac.com | cs@herrmidifier-hvac.com Form No. 267949-001 Rev. 11/16 © HERRMIDIFIER 2016. All Rights Reserved.
Need help?
Do you have a question about the Herrtronic 6500 Series and is the answer not in the manual?
Questions and answers