Processing freezer/chiller/refrigeration system (60 pages)
Summary of Contents for Alto-Shaam 20-20W
Page 1
H o l d i n g C a b i n e t s E l e c t r i c Models: 20-20W 20-20MW 20-20MW • InstallatIon • operatIon • MaIntenance W164 N9221 Water Street • P.O. Box 450 Menomonee Falls, Wisconsin 53052-0450 U.S.A.
• Relative humidity of less than 95% non-condensation. when moving or leveling appliance • Atmospheric pressure range of 50KPa to 106KPa. and handling accessories. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 1...
If not followed the operator could suffer personal injury. Used to indicate that referral to operating instructions is recommended to understand operation of equipment. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 2...
Page 5
• ALWAYS open the appliance door very slowly. Escaping hot vapors or steam can cause serious injury or death. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 3...
I ght beneath the unit. Warranty will become null and 378 lb (171mm) void if these directions are not followed. 513 lb (233 kg) ship MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 4...
OR PROPERTY DAMAGE, ALWAYS DEATH, OR PROPERTY DAMAGE, lock-out or post breaker panel until ALWAYS disconnect unit from power service work has been completed. source before cleaning or servicing. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 6...
6-15P n e m a 50/60 12.5 15A-250V Plug 50/60 12.0 250v plugs rated 2-16 1363 3112 Wire diagrams are located under the top cover of the unit . MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 7...
Equipment on casters can positioned above the eye level of the LA-22026 move or roll on uneven fl oors. operator. Such products may scald and cause serious injury. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 8...
Temperature Down temperature of each item to assure maintenance of Display Arrow Arrow the proper temperature range. Reset the holding temperature accordingly. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 9...
Use a metal-stemmed thermometer to measure the internal temperature of the product being held. Adjust the thermostat setting to achieve the best overall setting based on internal product temperature. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 10...
fi re!). Failure NEVER use wire brushes, metal to clean the appliance properly scouring pads or scrapers. invalidates the warranty and relieves Alto-Shaam of all liability. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 11...
DO NOT use water jet to clean. Failure to observe this precaution will void the warranty. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 12...
Additional HACCP information is receiving through service. available by contacting: Center for Food Safety and Applied Nutrition Food and Drug Administration PHONE: 1-888-SAFEFOOD www.foodsafety.gov MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 13...
Do not attempt to repair or service the oven beyond this point. Contact Alto-Shaam for the nearest authorized service agent. Repairs made by any other service agents without prior authorization by Alto-Shaam will void the warranty.
Tes t probe and air sensor by placing sensor in ice water bath and using an ohmmeter set on the ohm scale. The reading should be 100 ohms resistance. If it is more than 2 ohms higher or lower, sensor needs to be replaced MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 15...
P ar t n umb e rs a nd d r aw ing s a re s u b j e c t t o c h a n g e wi t h o u t n o t i c e . MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 16...
Page 19
DEATH, OR PROPERTY DAMAGE, OR PROPERTY DAMAGE, ALWAYS ALWAYS disconnect unit from power lock-out or post breaker panel until source before cleaning or servicing. service work has been completed. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 17...
P ar t n umb e rs a nd d r aw ing s a re s u b j e c t t o c h a n g e wi t h o u t n o t i c e . MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 18...
Page 21
DEATH, OR PROPERTY DAMAGE, OR PROPERTY DAMAGE, ALWAYS ALWAYS disconnect unit from power lock-out or post breaker panel until source before cleaning or servicing. service work has been completed. MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 19...
P ar t n umb e rs a nd d r aw ing s a re s u b j e c t t o c h a n g e wi t h o u t n o t i c e . MN-36608 (Rev. 3) 10/15 • 20-20MW, 20-20W Holding Cabinets • 20...
LIMITED WARRANTY Alto-Shaam, Inc. warrants to the original purchaser only that any original part that is found to be defective in material or workmanship will, at Alto-Shaam's option, subject to provisions hereinafter stated, be replaced with a new or rebuilt part.