Troubleshooting Guide - Razor crazy cart shift Owner's Manual

TROUBLESHOOTING GUIDE

Problem
Product does not run.
Product was running but
suddenly stopped.
Short run time.
Product runs sluggishly.
Sometimes the product doesn't
run, but other times it does.
Charger gets warm during use.
For more troubleshooting tips, a list of available replacement parts or to locate an authorized Service Center in your area,
visit our website at www.razor.com or call toll free +1 866 467 2967 to speak to a live Customer Service Representative
Need Help? Visit our web site for replacement parts, product support, a list of authorized service centers in the US and customer service contact information
at www.razor.com. Please have the product I.D. code (located on the white label of your product) available for better assistance. Additional Customer Service
contact information is listed at the back of this manual.
*Product(s) should be turned off and fully charged prior to doing any Troubleshooting
NOTE: All troubleshooting steps should be performed by an adult only
Possible Cause
Undercharged battery.
Charger is not working.
Loose wires or connectors.
Undercharged battery.
Battery is old and will not accept
full charge.
Riding conditions are too stressful.
Product is overloaded.
Loose wires or connectors.
Motor or electrical switch damage.
Normal response to charger use.
Solution
Charge the battery. A new battery should have been charged for at least
12 hours before using the product for the first time and up to 12 hours after
each subsequent use.
Check all connectors. Make sure the charger connector is tightly plugged
into the charging port and that the charger is plugged into a functioning
wall outlet.
Contact Razor Customer Service to get replacement charger.
Check all wires and connectors to make sure they are tight.
Charge the battery. A new battery should have been charged for at least
12 hours before using the product for the first time and up to 12 hours after
each subsequent use.
Refer to page 4. Replace only with a Razor replacement battery.
Use only on solid, flat, clean and dry surfaces such as pavement or
level ground.
Make sure you do not overload the product by allowing more than one
rider at one time, exceeding the maximum weight limit, going up too steep
a hill or towing objects behind the product.
Check all wires connectors to make sure they are tight.
Contact your local Razor authorized service center for diagnosis and repair.
Contact Razor customer service or visit www.razor.com.
No action required. This is normal for some chargers and is no cause for
concern. If your charger does not get warm during use, it does not mean
that it is not working properly.
8