, a l way s c o n s u l t t h e c u r r e n t P I O N E E R u163 Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
The interlock mechanism mentioned above becomes invalid in this mode. 2. When the cover is open, close viewing through the objective lens with the naked eye will cause exposure to the laser beam. ∗ : Refer to page 38. u163 PD-D9MK2-K http://www.xiaoyu163.com...
Page 4
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. PD-D9MK2-K http://www.xiaoyu163.com...
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: • Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. L 13942296513 u163 PD-D9MK2-K http://www.xiaoyu163.com...
(±0.001 % W. PEAK) or lower Digital output Coaxial digital output....RCA jack Optical digital output..Optical digital jack u163 PD-D9MK2-K http://www.xiaoyu163.com...
To turn on the power in this case, reconnect the power cord and then press either the remote control unit’s CD PLAYER u button or a different button (other than the POWER button) on the main unit. u163 PD-D9MK2-K http://www.xiaoyu163.com...
PROGRAM CLEAR ENTER REPEAT RANDOM h OPEN/CLOSE DIMMER L 13942296513 PROGRAM REPEAT RANDOM 10 PURE AUDIO 11 LEGATO LINK VOLUME 12 ENTER 13 AMP controls MUTE Use to control Pioneer amplifier. AMP u VOLUME MUTE SACD PLAYER u163 PD-D9MK2-K http://www.xiaoyu163.com...
Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools. Position to be cleaned Name Part No. Remarks u163 Pickup leneses Cleaning liquid GEM1004 Refer to “9.6 Traverse Mechanism Assy-S”. Cleaning paper GED-008 PD-D9MK2-K http://www.xiaoyu163.com...
ASSY DVDM ASSY REGULATOR ASSY L 13942296513 AJKB ASSY Mark No. Description Part No. Mark No. Description Part No. LIST OF ASSEMBLIES For PD-D9MK2-K/CUXJ 1..LOADER ASSY PXA1648 For PD-D9MK2-K/SYXJ5 2..LOAB ASSY VWG2346 1..LOADER ASSY PXA1648 2..LOAB ASSY VWG2346 1..DVDM ASSY AWM8184 1..DVDM ASSY...
(V+6R5V line) Is status of D1702 1 IC1702 OK? is +8.5V Can stop <confirmation> spicdle movement Refer to Addendum No. 4. HB at CN1701 (stop key react) Change IC1702 u163 CN1702 3 <confirmation> is +6.5V HB at CN1702,CN2704,IC101 PD-D9MK2-K http://www.xiaoyu163.com...
Page 19
(V+12RY line) IC1707 1 is status of IC1706 HB at CN1701 or RY1302 1 is +17V is OK? change D1709,D1710 +12V Change IC1707 Change IC1706 <confirmation> RY1302 a XSYSMUTE : H is 0V DVDMUTE : L Change RY1302 u163 PD-D9MK2-K http://www.xiaoyu163.com...
Page 20
Are wires of CN104 and CN103 on the DVDM Assy disconnected or Connector / cable damaged ? Does the voltage of CN102-pin 1 on the DVDM Assy change to 0V by Inside switch u163 pressing the Inside switch. PD-D9MK2-K http://www.xiaoyu163.com...
Page 21
0.4 V or more, the 780-nm LD is definitely deteriorated. impossible) DVDM Assy Is there abnormality in FG waveform ? (IC201-pin 47) FG output : FTS Driver IC (IC101) Are there scratches or dirt on the disc ? Disc L 13942296513 u163 PD-D9MK2-K http://www.xiaoyu163.com...
Note 1: In this step, the unit wait for the DVD module to turn the power off. If the DVD module takes a longer time to turn itself off, the elapsed time will become longer, by just that much. PD-D9MK2-K http://www.xiaoyu163.com...
Page 23
• Other than in an emergency power-off, the unit awaits for a while. • SYSTEM POWER2 OFF (Pin 92: H) Display only POWER OFF completed + 240 msec 5240 msec • SYSTEM POWER1 OFF (Pin 91: H) u163 PD-D9MK2-K http://www.xiaoyu163.com...
Measure the voltage between the both ends of R322 or R325 on the DVDM Assy. If the voltage is 0.4 V or higher, the 650-nm LD is degraded. 05SD PICKUP ASSY CN101 L 13942296513 DVDM ASSY Front side u163 SIDE A PD-D9MK2-K http://www.xiaoyu163.com...
Press the OPEN/CLOSE button to close the Tray. (Test Disc is clamped.) Press the STANDBY/ON button to turn off the power. Pull out the Power cord. Screwdriver (small) Projection Test Disc Drive cam u163 LOADER ASSY Bottom view Tray Tray Panel PD-D9MK2-K http://www.xiaoyu163.com...
Page 29
Slightly lift the LOADER ASSY and displace it slightly CN953 backward. LOADER ASSY ×4 ×2 ×2 17P FFC extension jig cable (GGF1157) Mecha Angle Diagnosis Note: Service cable 5P (GGD1425) is required when u163 diagnosing the DVDM ASSY side B. PD-D9MK2-K http://www.xiaoyu163.com...
Page 30
Note when reinserting the tray When reinserting the tray, first align the triangle printed on the loading base and the pin of the drive cam, then insert the tray. Drive cam u163 Tray Front side Loading base Triangle PD-D9MK2-K http://www.xiaoyu163.com...
Page 31
Dislodge the two flexible cables from their factory for the spindle motor placement. Front Side L 13942296513 Flexible cable for the pickup Bottom view Unhook the four hooks. Traverse Mechanism Assy-S Remove the Traverse Mechanism Assy-S × 2 u163 × 2 PD-D9MK2-K http://www.xiaoyu163.com...
Page 32
Adjustment screw Remove the 05SD Pickup Assy. (skew screw VK1) (skew screw VK1) 05SD Pickup Assy-S Note: Be careful not to lose the adjustment spring (skew spring VK1). Adjustment screw (skew screw VK1) Adjustment spring u163 (skew spring VK1) PD-D9MK2-K http://www.xiaoyu163.com...
Page 33
Make sure to apply the silicone adhesive after reattaching the screw. Joint VK1B Joint spring VK1 Silicone Adhesive GEM1037 L 13942296513 Arrangement of the flexible cable for the spindle motor : Conductive surface Hook Front Side Hook u163 Bottom view PD-D9MK2-K http://www.xiaoyu163.com...
Page 34
Fold the flexible cable along the hook. L 13942296513 Pass the flexible cable through the hook. Hook Backing Front Side Bottom View Hook Pass the flexible cable through the hook. Hook Hook u163 Make sure that the cable is loose PD-D9MK2-K http://www.xiaoyu163.com...
Page 35
Set the top and bottom edges of the Front Panel L even with R and tighten the screws. Adjust this gap to zero (0). Front Panel L Front Panel R L 13942296513 Screw for securing the Front Panel L (Tighten the screw while adjusting the gap.) Rear face of the Panel ASSY u163 PD-D9MK2-K http://www.xiaoyu163.com...
[Electrical Part] screw screw Electrical adjustments are not required. L 13942296513 8.2 JIGS AND MEASURING INSTRUMENTS Test mode remote control Screwdriver (large) Screwdriver (medium) unit (GGF1381) Screw tight (GYL1001) u163 DVD test disc Soldering iron Precise screwdriver (GGV1025) PD-D9MK2-K http://www.xiaoyu163.com...
Assy-S Electric point ∗ After adjustment, screw locks Mechanical Exchange the Spindle Motor point with the Screw tight. Electric point Exchange PCB Assy L 13942296513 Mechanical Exchange PC Board point LOAB and DVDM ASSYS Electric point u163 PD-D9MK2-K http://www.xiaoyu163.com...
• The SKIP key and the SCAN key are effective during the test mode. Note: Even if you intend to continuously use the unit after displaying the error rate, be sure to turn the power off then TEST MODE: OFF back on u163 POWER GGF1381 Test mode remote control unit PD-D9MK2-K http://www.xiaoyu163.com...
Page 39
Service Test mode connecting point LCD ASSY SIDE B R2109 L2105 Short L2103 L2102 L 13942296513 R2146 17.GNDD 16.SROUT D2204 15.SRIN C2205 14.SRIN D2203 13.XDFDT C2204 12.GNDD 11.XDFCLK 7.GNDD 10.XDFCS 6.XSRRST 9.XDFRST 8.XSYSMUTE 5.LEGATO 4.XDACCK 3.XDACDT 2.XDACCS1 1.XDACCS2 C2107 C2211 u163 PD-D9MK2-K http://www.xiaoyu163.com...
(Refer to "8.1 ADJUSTMENT ITEMS AND LOCATION".) Joint 7.5mm Mechanism base • Attach the Traverse Mechanism Assy-S to the 05 LOADER Assy. • Turn it over and attach the joint and the joint spring. u163 • Arrange the flexible cables. (Refer to "7. DISASSEMBLY".) PD-D9MK2-K http://www.xiaoyu163.com...
Page 41
90 degrees step till ERROR RATE block error rate becomes around "1E-3" again . u163 • Record the number of rotation (N1). • Fasten the tangential adjustment screw till the number of rotation becomes Service mode end harf of N1. Best tangential point PD-D9MK2-K http://www.xiaoyu163.com...
(In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING SECTION SYXJ5 type Only SYXJ5 type Only No.9: CUXJ type Only CUXJ type Only CUXJ type Only L 13942296513 CUXJ type Only u163 PD-D9MK2-K http://www.xiaoyu163.com...
Page 43
See Contrast table (2) 13 Operating Instructions See Contrast table (2) 14 Operating Instructions See Contrast table (2) (2) CONTRAST TABLE PD-D9MK2-K/SYXJ5 and PD-D9MK2-K/CUXJ are constructed the same except for the following : PD-D9MK2-K/ PD-D9MK2-K/ Mark No. Symbol and Description SYXJ5...
3 7 63 1515 0 MNSW CN2501 AJKB CN1401 Tape 19 X 40 CONNECTOR PRIMARY CN2703 CN11 Refer to "9.3 CHASSIS SECTION". L 13942296513 Refer to "9.4 FRONT PANEL SECTION". Tape 19 X 50 Tape 19 X 50 u163 PD-D9MK2-K http://www.xiaoyu163.com...
Page 45
PNB1674 18 • • • • • 19 Beam L PNS1064 20 Beam S PNS1065 (2) CONTRAST TABLE PD-D9MK2-K/SYXJ5 and PD-D9MK2-K/CUXJ are constructed the same except for the following : L 13942296513 PD-D9MK2-K/ PD-D9MK2-K/ Mark No. Symbol and Description SYXJ5...
19 X 60 L 13942296513 Tape CN2105 CN2105 19 X 40 Tape Refer to 19 X 20 Tape "9.5 LOADER ASSY 19 X 20 SECTION". Tape 19 X 50 Tape Tape 19 X 40 19 X 20 u163 CN2106 PD-D9MK2-K http://www.xiaoyu163.com...
Page 47
PNB1666 28 Trans Cover PNB1667 29 Trans Angle PNB1668 30 Center Plate PNB1669 (2) CONTRAST TABLE PD-D9MK2-K/SYXJ5 and PD-D9MK2-K/CUXJ are constructed the same except for the following : PD-D9MK2-K/ PD-D9MK2-K/ Mark No. Symbol and Description SYXJ5 CUXJ 4 REGULATOR Assy...
IC2101 AJKB CN1401 PLED PRIMARY Double Side Tape J2601 CN11 L 13942296513 IC2101 CONNECTOR CN2703 Double Side Tape 10 X 30 Double Side Tape 10 X 20 Double Side Tape SYXJ5 type 10 X 40 u163 CUXJ type PD-D9MK2-K http://www.xiaoyu163.com...
Page 49
22 Bottom Spacer F PEB1334 23 EMI Spacer (15X20) PEB1339 NSP 24 Front Sheet PEB1348 (2) CONTRAST TABLE PD-D9MK2-K/SYXJ5 and PD-D9MK2-K/CUXJ are constructed the same except for the following : PD-D9MK2-K/ PD-D9MK2-K/ Mark No. Symbol and Description SYXJ5 CUXJ 7 Front Panel L...
Page 51
No. 23 No. 25 GEM1036 GEM1036 Tray Tray Concave of unevenness EMI Spacer Concave of unevenness Inner side of a ditch Daifree GEM1036 u163 Top View Bottom View Side of the rib Concave of unevenness Daifree Daifree GEM1036 GEM1036 PD-D9MK2-K http://www.xiaoyu163.com...
Page 53
Fibers or dirt in the grease have an adverse affect on operation and must be removed. (2) Guide bar Apply grease GYA1001 to the crosshatched area shown in the center of the picture Amount of grease: 2 ± 1 mg for 1 location u163 PD-D9MK2-K http://www.xiaoyu163.com...
ICE MODE (RF) : RF SIGNAL ROUTE GNDD : FOCUS SERVO LOOP LINE : TRACKING SERVO LOOP LINE AYW7197 : STEPPING SERVO LOOP LINE V+3D : DIGITAL SIGNAL ROUTE u163 R284 (AD) : AUDIO DATA SIGNAL ROUTE R285 GNDD PD-D9MK2-K http://www.xiaoyu163.com...
Page 55
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. : The power supply is shown with the marked box. PD-D9MK2-K http://www.xiaoyu163.com...
10.4 LCD, PLED, IR and KEY ASSYS 3 7 63 1515 0 PLED ASSY (PWX1677) 4.4V L 13942296513 IR ASSY (PWX1653) 5.6V 5.2V 5.8V u163 D E K PD-D9MK2-K http://www.xiaoyu163.com...
• NOTE FOR FUSE REPLACEMENT CAUTION FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND RATINGS OF FUSE. SYXJ5 CUXJ SYXJ5 PRIMARY ASSY CUXJ (PD-D9MK2-K/SYXJ5: PWX1681) (PD-D9MK2-K/CUXJ: PWX1683) L 13942296513 MNSW ASSY SYXJ5 CUXJ (PWX1654) 12.3V 5.6V SYXJ5 12.9V...
Page 63
3 7 63 1515 0 REGULATOR ASSY (PD-D9MK2-K/SYXJ5: PWX1678) (PD-D9MK2-K/CUXJ: PWX1680) 17.3V 13.3V -13.3V -18V 7.6V 3.3V L 13942296513 5.8V SYXJ5 CUXJ SYXJ5 CUXJ 8.6V 6.5V 17.3V u163 CAUTION CAUTION FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE ONLY WITH SAME TYPE NO.
CN602 VWG2346- Connector Capacitor CN601 (VNP1836-C) SIDE A SIDE B CN602 CN601 P.C.Board Chip Part LOADING MOTOR ASSY To STEPPING To SPINDLE Motor CN2701 To Pickup Assy Motor DVDM ASSY CN101 CN901 CN102 CN101 L 13942296513 u163 (ANP7733-A) PD-D9MK2-K http://www.xiaoyu163.com...
Page 69
3 7 63 1515 0 SIDE B SIDE B LOAB ASSY PNE-1B1 LOAD+ C102 LOAD- CN602 C101 (VNP1836-C) CN601 CN601 CN602 DVDM ASSY L 13942296513 u163 (ANP7733-A) PD-D9MK2-K http://www.xiaoyu163.com...
11.2 AJKB ASSY 3 7 63 1515 0 SIDE A SIDE A AJKB ASSY CN2105 CN1802 CN1401 J1901 C1911 L 13942296513 u163 (PNP1497-A) PD-D9MK2-K http://www.xiaoyu163.com...
Page 71
3 7 63 1515 0 SIDE B SIDE B AJKB ASSY J1901 CN1401 L 13942296513 u163 (PNP1497-A) PD-D9MK2-K http://www.xiaoyu163.com...
11.3 LCD ASSY 3 7 63 1515 0 SIDE A SIDE A LCD ASSY J2106A J2106 J2106 L 13942296513 C2213 J2104 CN2106 UPPER SIDE u163 (PNP1491-A) CN2106 CN2703 PD-D9MK2-K http://www.xiaoyu163.com...
PLED ASSY J2102 J2601 [[ G ]] C2602 J2601 D2601 IR ASS'Y PLED PWX1655 ASS'Y PWX1653 (PNP1492-A) (PNP1492-A) L 13942296513 KEY ASSY 2301 KEY ASS'Y PWX1652 S2301 S2302 [[ G ]] u163 (PNP1492-A) E G K E G K PD-D9MK2-K http://www.xiaoyu163.com...
Page 75
3 7 63 1515 0 SIDE B SIDE B PLED ASSY IR ASSY J2601 1.V+5U 2.PLED R2601 (PNP1492-A) (PNP1492-A) L 13942296513 KEY ASSY 1.KEY1 2.V+5U 3.GNDD R2302 R2301 u163 (PNP1492-A) E G K E G K PD-D9MK2-K http://www.xiaoyu163.com...
3 7 63 1515 0 SIDE A SIDE A PRIMARY ASSY J2101 CN11 PRIMARY ASS'Y PWX1657 KN11 CN11 PWX1658 V+5R6ST PWX1659 [[ G ]] PWX1660 WHITE J11-2 YELLOW L 13942296513 SECONDARY PRIMARY YELLOW WHITE RY11 CN13 (PNP1491-A) CN13 CN10 J1702 J1701 u163 PD-D9MK2-K http://www.xiaoyu163.com...
Page 77
3 7 63 1515 0 SIDE B SIDE B PRIMARY ASSY CN11 SECONDARY PRIMARY L 13942296513 (PNP1491-A) CN10 CN13 u163 PD-D9MK2-K http://www.xiaoyu163.com...
1.AUDIO1 IC1706 C1801 4.MECHA2 MECHA1 DIGITAL2 1.DIGITAL1 R1801 D1701 D1702 CAUTION REPLACE WITH SAME TYPE NO. 491003 FOR IC1701, TYPE NO. 49103.5 FOR IC1702, MFD. BY LITTEL FUSE INC. KN1701 IC1704 u163 J1702 C1717 CN1702 (PNP1491-A) CN1702 CN2704 PD-D9MK2-K http://www.xiaoyu163.com...
Page 81
IC1706,N'UTILISER QUE LA REFERENCE REFERENCE 491002 DE CHEZ LITTEL EN CAS DE REMPLACEMENT DES FUSIBLES IC1801,IC1802,N'UTILISER QUE LA ATTENTION EN CAS DE REMPLACEMENT DES FUSIBLES D1703 ATTENTION C1715 D1705 C1706 C1705 D1704 C1722 u163 R1710 C1708 R1704 C1723 R1709 (PNP1491-A) CN1702 PD-D9MK2-K http://www.xiaoyu163.com...
IC1701 AEK7015 AEK7018 IC1702 AEK7017 AEK7019 D1709,D1710 1SR139-400 11EQS06 PCB PARTS LIST FOR PD-D9MK2-K/SYXJ5 UNLESS OTHERWISE NOTED Mark No. Description Part No. Mark No. Description Part No. IC 201 (A,50,44) DVD IC MT1389EE/B2-L IC 202 (B,34,25) IC K4S641632K-UC75 LOAB ASSY...
R 315 (A,80,128) RS1/10SR103J R 205 (A,45,67) RS1/10SR184J R 318 (A,80,126) RS1/10SR104J R 206 (A,46,64) RS1/10SR224J R 321 (A,61,87) RS1/10SR4R7J R 207 (A,65,60) RS1/8SQ0R0J R 322 (A,73,87) RS1/10SR4R7J R 208 (B,27,71) RS1/8SQ0R0J R 325 (A,68,87) RS1/10SR4R7J R 209 (A,57,16) RS1/8SQ0R0J PD-D9MK2-K http://www.xiaoyu163.com...
Page 84
C 246 (B,63,32) CKSRYB104K25 u163 C 249 (B,54,44) CKSRYB104K25 R 940 (A,104,111) RS1/10SR0R0J C 250 (B,64,36) CKSRYB103K50 C 253 (B,64,44) CKSRYB104K25 CAPACITORS C 254 (B,64,48) CCSRCH391J50 C 101 (A,49,120) CEVW101M16 C 255 (B,65,53) CKSRYB474K10 C 102 (A,73,101) CKSRYB105K10 PD-D9MK2-K http://www.xiaoyu163.com...
Page 85
C 738 (A,24,78) CHIP CERAMIC C. DCH1165 CN 1401 (A,45,62) CONNECTOR CKS3382 C 739 (A,21,66) CEVW101M16 CN 1402 (A,151,62) CONNECTOR PKN1033 C 751 (A,32,119) CKSRYB105K10 C 752 (A,34,108) CCSRCH471J50 CN 1501 (A,223,61) CONNECTOR 05R-FJ C 753 (A,30,108) CKSQYB225K10 PD-D9MK2-K http://www.xiaoyu163.com...
Page 86
R 1305 (B,177,114) RS1/10SR0R0J C 1165 (A,83,137) PCH1169 R 1306 (A,178,117) RS1/10SR103J C 1201 (A,109,110) PORYPROPYLENE FILM CPCE1005 R 1401 (B,126,68) RS1/10SR220J C 1202 (A,122,97) PORYPROPYLENE FILM C PCE1004 R 1402 (B,126,70) RS1/10SR220J C 1203 (A,106,125) PORYPROPYLENE FILM CPCE1004 PD-D9MK2-K http://www.xiaoyu163.com...
Page 87
R 2114 (B,83,215) RS1/10SR223J C 1911 (A,101,168) CKSRYB103K50 u163 R 2115 (B,139,195) RS1/10SR221J C 1918 (B,92,93) CKSRYB103K50 R 2117 (B,112,212) RS1/10SR221J R 2120 (B,57,185) RS1/10SR223J R 2121 (B,115,218) RS1/10SR105J LCD ASSY(D9) R 2122 (B,113,232) RS1/10SR221J R 2123 (B,120,227) RS1/10SR221J PD-D9MK2-K http://www.xiaoyu163.com...
Page 89
CAPACITORS IC 1707 (A,107,85) REGULATOR IC NJM78M12FA C 1701 (A,142,82) CFTLA824J50 IC 1801 (A,143,32) PROTECTOR(2A) AEK7013 C 1702 (A,147,75) CFTLA824J50 IC 1802 (A,133,32) PROTECTOR(2A) AEK7013 C 1703 (A,165,83) PCH1161 IC 1803 (A,29,32) IC NJM78M05FA C 1704 (A,165,71) PCH1161 PD-D9MK2-K http://www.xiaoyu163.com...
Page 90
C 1817 (B,25,76) CKSRYB103K50 C 1818 (B,27,70) CKSRYB103K50 C 1819 (B,32,76) CKSRYB103K50 C 1820 (B,43,76) CKSRYB103K50 C 1821 (B,130,46) CKSRYB103K50 C 1822 (B,39,20) CKSRYB103K50 IR ASSY(D9) MISCELLANEOUS 2401 (A,29,180) REMOTE RECEIVER UNIT GP1UM28XK0VF CAPACITORS C 2401 (B,33,182) CKSRYB104K16 u163 PD-D9MK2-K http://www.xiaoyu163.com...