Related Manuals for PACIFIC RIM INT’L WEST PST150-18
Summary of Contents for PACIFIC RIM INT’L WEST PST150-18
- Page 1 PST150-18 PST150-7 MANUAL HUZHOU DAIXI ZHENHUA TECHNOLOGY TRADE CO., Ltd. PACIFIC RIM INT’L WEST INC.
- Page 2 PREFACE To my dear customers: We’d like express our gratitude for your choosing ZHENGHUA motorcycles. ZHENGHUA motorcycles are sold overseas for its reasonable design, advanced technique and beautiful appearance. The quality of our products enjoys good reputation among new and old customers. As an ideal foot-substitute and transport tool, ZHENGHUA motorcycles will offer you more convenience to your work and bring more pleasure to your life.
-
Page 3: Table Of Contents
TABLE OF CONTENTS TOOLS…………………………………………23 CONSUMER INSTRUCTION……………………3 STORAGE BATTERY……………………………23 PARTS LOCATION………………………………6 AIR CLEANER…………………………………24 OPERATING …………………………………9 SPARK PLUG……………………………………24 KEY … …… … …… … …… …… … …… … …… 9 ENGINE OIL……………………………………25 IGN IT I ON SW I T CH … … …… … … … …… … 9 CARBURETOR…………………………………27 D A S H B O A R D …... - Page 4 CONSUMER INFORMATION AND BREAK-IN tion, the words “WARNING”, “CAUTION” and INFORMATION FOR YOUR MOTORCYCLE “NOTE” carry special meaning and should be The first 1600 km is the most important in the carefully reviewed. life of your motorcycle. Proper break-in operation WARNING! during this time will ensure maximum life and The personal safety of the rider may be...
-
Page 5: Consumer Instruction
CONSUMER INFORMAION in; unfastened equipment will cause the diversion PRECAUTIONS ABOUT ADDING ACCESS- from the center of the gravity and inviting ORIES AND PREPARATION BEFORE RIDING unnecessary trouble. You may buy all kinds of accessories to add (2) Checking the off-ground height of accessory your Zhenhua motorcycle, but unnecessary and and the angle, the improper adding will make the two unsuitable accessories would invite trouble for your... - Page 6 When adding the accessories, it should fasten to the DRESS body of the motorcycle; the improper adding would The slack and curious clothing will make you invite trouble for your driving and manipulating. The uncomfortable and unsafe, so please choose the good size of the accessory would affect the air-resistance quality and tight clothing.
- Page 7 machine. of motorcycle, therefore, it is best to wear bright or KNOW YOUR OWN SCOPE OF SKILL reflective clothing and take care while turning. You The riding should be always controlled in the should turn on the front and rear light to remind scope of your riding skill, never try the risky riding.
-
Page 8: Parts Location
Please write down the numbers here for reference: Frame NO.: Engine NO.: PARTS LOCATION... -
Page 11: Operating
When all the electricity working, you may ignite at STEERING SYSTEM any time, the key can not be pulled out there are two keys to the motorcycle. The keys can control sparking switch, steering- lock, cap FUEL TANK CAP lock and helmet-pole lock. SPARK SWITCH ⑴FUEL TANK CAP ⑵IGNITION KEY... -
Page 12: Left、 Right Handlebar
kilometers the motorcycle has driven. WARNING! Neutral indicator ③ Do not overfill the fuel tank to When the transmission is in the neutral, the prevent the fire caused by fuel overflowing to hot engine. indicator is lighted up. In other gears, the indicator will be extinguished. -
Page 13: Horn Button
lighted up. If these lights are unnecessary, push the RIGHT STEERING SYSTE button of right light on “·” position. LEFT-RIGHT TURNING SIGNAL BUTTON Turn the “←” button left , the left signal can be lighted up . Turn the “→” button right, the right signal can be lighted up . -
Page 14: Fuel Tank Cap
increase the engine speed. Turn it away from CIRCUIT. yourself to decrease the engine speed. Turn it away FUEL COCK from yourself to decrease the engine speed. LIGHT BUTTON④ “ ”: in this position, the headlights, backlights, parking lights and dashboard lights are lighted up. “... -
Page 15: Rear Shock Absorder
“RES” position REAR SHOCK ABSORBER If the fuel level in the fuel tank is too low, turn the cock to the “RES” position to use the 1.6 L reserve fuel. “OFF” position If the engine stops for a few minutes, put the fuel lever to “OFF”... - Page 16 TAIL HOOK FUEL AND ENGINE OIL RECOMMENDA- To haul the baggage car or other small car. TION FUEL Please use unleaded [GB17930-1999] petrol with a octane number of 91 or high. Using the unleaded high quality oil can prolong the life of your motorcycle and can also contribute to environmental protection.
-
Page 17: Fuel & Engine Oil Recommendation- S
The following items are the different engine oil guidelines explain proper running-in procedures. use in sphere of application. The following table shows the maximum recommended throttle opening during the break-in period: Initial 800 km less than 1/2 To 1600km less than2/3 VARY THE ENGINE SPEED The engine speed should be varied and not hold at a constant speed. - Page 18 AVOID CONSTANT LOW SPEED sufficiently. All adjustments will be restored, all Operating the engine at constant low speed (light fasteners will be tightened, and the dirty oil will be load) for a long time can cause parts to graze and replaced.
-
Page 19: Inspection Before Riding
INSPECTION BEFROE RIDING Before riding the motorcycle, be sure to check the following items. Never ignore the importance of these checks. Perform all of them before riding the machine. WHAT TO CHECK IMPORTANT ITEMS Steering 1) Smoothness 2) No restriction of movement. 3) No play or looseness Brakes 1) the fluid level in brake fluid reservoir should be higher than the “LOWER”... -
Page 20: Riding Essentials
RIDING ESSENTIALS STARTING THE ENGINE WARNING WARNING 1: if you ride this motorcycle for the first time, Never start the engine in the narrow position we suggest that you practise riding your to avoiding danger motorcycle in a non-traffic situation without obstacles until you are thoroughly familiar with When the engine is “COLD”, the procedure is as your machine. - Page 21 NOTES: In some cold area, push the electric button on “OFF” position before starting the machine, closed down the chock valve, open the throttle NOTES: then press the starting lever for several times to Do not race your engine when you are not make the engine easy to start.
-
Page 22: Riding
RIDING: rear brake system. NOTES: It is dangerous to stop your motorcycle by only using Preview the related riding knowledge before the front or rear brake, this method will make your riding. motorcycle out of control for the skidding. Take more care and use the brake system slightly in the rainy and smooth road. - Page 23 as continuous full throttle operation, or is operated in NOTES: a dusty climate, certain service should be perform You will change one or several parts in the period more often to insure reliability of the machine as of checking and maintenance. We suggest that you explained in the maintenance section.
- Page 24 INTENANCE CHART Period 1000 3000 8000 Item Month *Exhaust pipe bolts, cylinder head nuts *Crankcase drive chain Air cleaner —— *Valve clearance Check every 12000 km Spark plug —— *Fuel line —— *Replace every 4 years Engine oil Oil filter ——...
-
Page 25: Tools
TOOL sealed cap at any time. There is a set of tool with the motorcycle for your 2) The condition of electrification can be inspected inspection by the voltmeter. ACCUMULATOR (The normal voltage is more than 12.8v) Open the seat, the accumulator can be seeing. CAUTIONS: Although the accumulator is totally sealed, the improper operation will invite trouble. -
Page 26: Air Cleaner
Constant-voltage charging by current limiting, the CAUTION: charging voltage is between 13.8v and 14.5v, the If driving under dusty conditions, the filter must current limiting is between 1.5A and 2.5A, the be cleaned and replaced more frequently. charging time is between 9 and 12 hours. NOTES CAUTION: The red line is connecting anode and the black line is... -
Page 27: Engine Oil
2) Remove the spark plug with a plug wrench and 2) The spark plug in this motorcycle is elaborate clean all the dusty on the bottom. selected and can meet most working. If the color of spark plug is quite different from the standard plug, Remove the carbon deposits from the spark you’d better contact with the Zhenhua dealer. - Page 28 until it seats, but not screw it in. the oil should be drain pan under the engine. between the upper lever mark ② and the lower 2) Unscrew and remove the oil drain bolt ① lever mark ③. If necessary, add the recommended under the engine to drain the dirt oil.
-
Page 29: Carburetor
5) Pour 0.8L recommended oil into the engine. under your care: the idle speed and the gap of throttle Start the engine, let it run at idle speed for 2-3 cable. minutes, shut off the engine and wait for a minute, DRIVE CHAIN check whether the oil is at upper level mark. - Page 30 Therefore the following check of the sprocket is necessary.1) Excessive wore teeth 2) damage or frangible teeth 3) Loose pins The drive chain should be adjusted irregularly as per the riding condition to maintain it in normal status. WARNING! Excessive chain slack could cause the chain to come off the sprockets and result in an accident or A dirty drive chain may not only accelerate the chain serious engine damage.
-
Page 31: Brakes
NOTE: BRAKE FLUID Check the front and rear sprocket for wear when WARNING! replacing the drive chain, replace the sprocket if The brake fluid is poisonous, if swallowed, necessary. forced to spit it. Avoid contact with skin or eyes. In BRAKES case of contact, flush thoroughly with water and call This motorcycle has hydraulic disc front and rear... -
Page 32: Rear Brake Light Switch
used. Never make the brake fluid splash on the “MAINTENANCE SCHEDULE” of this manual surface of painting and rubber. When performing the periodical check, the following state of brake system should be checked. 1) Dripping or not NOTE: 2) Crack tube or not Checking whether the pipe is in poor condition and 3) Keep the certain recovery whether there is enough fluid. - Page 33 when performing the periodic inspection. Tire 130/60-13 205/50-10 NOTE: Specifications This motorcycle is traffic-motorcycle. Riding on Check your tire for both wear and inflation pressure the hill road, desert, rugged road and rainy road will to ensure the riding safety, make sure that there are invite troubles.
-
Page 34: Light Changing
the traction, stability, steering and operating system. whole electrical appliance may be destroyed and the A new front tire should be replaced when the depth burn will burn out. “The specification “and of thread is decreased below 1.6 mm. “electrical appliance” will give you more A new rear tire should be replaced when the depth of information for your consideration. -
Page 35: Inspection And Maintenance
There is a fuse box beside the storage cell. The entire fuel system. electrical appliance is protected by a fuse. Please 3) If the last step has been verified, please check the check the fuse first when your motorcycle is dead. igniting system. -
Page 36: Cheaning
WARNING! CAUTION: Don’t let the spark plug to be near spark plug to Before servicing, you are strongly recommended be near spark plug opening aperture in cylinder head, to contact Zhenghua authorized service center. If because the fuel vapor in cylinder can ignite causing your motorcycle is valid in guarantee period, fire. -
Page 37: Storage Guide
1) Spraying your motorcycle with clean water after gets to rocky and mud road. You‘d better clean and finishing cleaning. Some remains of detergent may dry it with soft cloth. eroded the alloy parts. NOTE: NOTE: To avoid the unnecessary scar, never use the Clean the plastics with soft cloth clean the dirty abrasive detergent and polishing clean your tire. - Page 38 STORAGE cylinder inside: 1: change engine oil. Remove the spark plug cover, fix it to near plastic 2: drain the fuel tank and carburetor into a petrol parts with rubberize fabric or cord, let it separated container. Spray the inside of the fuel tank with from the spark plug.
- Page 39 the ground. REMOVAL FROM STORAGE 1: Uncover and clean the motorcycle. If storage has lasted more than 4 months, replace the engine oil. 2: charge the storage cell if necessary then reinstalls it on the original position. 3: drain the nebulous anti-rusting oil remained in fuel reservoir.
-
Page 40: Specifications
· This manual should be regarded as one · All information, instructions, permanent component of the photographs and specifications motorcycle. Keep it well with the contained in this manual are based on motorcycle when you resell or lend the the latest product information motorcycle to other man.