Lenovo ThinkPad T560 Hardware Maintenance Manual
  1. Manuals
  2. Brands
  3. Lenovo Manuals
  4. Laptop
  5. T560
  6. Hardware maintenance manual

Lenovo ThinkPad T560 Hardware Maintenance Manual

Hide thumbs Also See for ThinkPad T560:
Table of Contents

Advertisement

Quick Links

See also: User Manual , Manual
ThinkPad T560 and P50s
Hardware Maintenance Manual

Advertisement

Table of Contents
loading

Related Manuals for Lenovo ThinkPad T560

Summary of Contents for Lenovo ThinkPad T560

  • Page 1 ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 2 Appendix A “Notices” on page 103. First Edition (February 2016) © Copyright Lenovo 2016. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant to a General Services Administration “GSA” contract, use, reproduction, or disclosure is subject to restrictions set forth in Contract No.

  • Page 3: Table Of Contents

    Checkout guide ....Undetermined problems ..Lenovo Solution Center ..Quick test programs...
  • Page 4 1110 dc-in bracket and dc-in cable ..Trademarks ....1120 Built-in battery or dummy battery . . . ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 5: About This Manual

    Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively. Before servicing a ThinkPad product, be sure to read all the information under Chapter 1 “Safety information” on page 1 and Chapter 2 “Important service information” on page 19. © Copyright Lenovo 2016...
  • Page 6 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 7: Chapter 1. Safety Information

    Do not use this type of mat to protect yourself from electrical shock. © Copyright Lenovo 2016...

  • Page 8: Safety Inspection Guide

    If any unsafe conditions are present, you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 9: Handling Devices That Are Sensitive To Electrostatic Discharge

    0.1 ohm or less between the external ground pin and the frame ground. b. The power cord should be the authorized type specified for your computer. Go to: http://www.lenovo.com/serviceparts-lookup c. Insulation must not be frayed or worn. 4. Check for cracked or bulging batteries.

  • Page 10: Grounding Requirements

    The safety notices in this section are provided in the following languages: • English • Arabic • Brazilian Portuguese • French • German • Hebrew • Japanese • Korean • Spanish • Traditional Chinese DANGER DANGER DANGER ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 11 DANGER DANGER DANGER DANGER DANGER Chapter 1 Safety information...
  • Page 12 ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 13 PERIGO PERIGO PERIGO PERIGO Chapter 1 Safety information...
  • Page 14 PERIGO PERIGO PERIGO PERIGO DANGER ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 15 DANGER DANGER DANGER DANGER DANGER DANGER Chapter 1 Safety information...
  • Page 16 DANGER VORSICHT VORSICHT VORSICHT VORSICHT ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 17 VORSICHT VORSICHT VORSICHT VORSICHT Chapter 1 Safety information...
  • Page 18 ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 19 Chapter 1 Safety information...
  • Page 20 ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 21 Chapter 1 Safety information...
  • Page 22 ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 23 Chapter 1 Safety information...
  • Page 24 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 25: Chapter 2. Important Service Information

    Lenovo Support Center are available at: http://www.lenovo.com/support/phone • Service training documents for Lenovo authorized service technicians are available at the following Web site. The disassembly and reassembly videos that show the FRU removal and replacement procedures are contained in the documents.

  • Page 26: Important Notice For Replacing A System Board

    Dynamic configure-to-order (CTO) model This model provides the ability for a customer to configure a Lenovo solution from a Web Site, and have this configuration sent to fulfillment, where it is built and shipped directly to the customer. The machine label and eSupport will load these products as the 4-character MT, 4-character model, and 2-character country code.
  • Page 27 To identify the major FRUs for a product, do the following: 1. Go to http://support.lenovo.com/ibasepartslookup. 2. Type the Machine Type and Serial Number in the corresponding fields. 3. Click Submit. eSupport also can be used to view the general FRU list for a product. The FRU list is a general list of components and does not contain specific model information.
  • Page 28 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 29: Chapter 3. General Checkout

    This chapter introduces following information: • “What to do first” on page 23 • “Checkout guide” on page 24 – “Lenovo Solution Center” on page 24 – “Quick test programs” on page 24 – “UEFI diagnostic program” on page 25 –...

  • Page 30: Checkout Guide

    The Lenovo Solution Center program is available for download at http://www.lenovo.com/diags. To run the Lenovo Solution Center program, go to Control Panel and click System and Security ➙ Lenovo - System Health and Diagnostics, and then follow the instructions on the screen.

  • Page 31: Uefi Diagnostic Program

    If the computer you are servicing is not installed with the UEFI diagnostic program, you can download a bootable diagnostic program from the Lenovo Support Web site. The bootable diagnostic programs enable you to test computer memory and internal storage devices, view system information, and check and recover the internal storage devices.

  • Page 32: Power System Checkout

    Ground (20V) Note: Output voltage of pin 2 of the ac power adapter might differ from the one you are servicing. 3. If the voltage is not correct, replace the ac power adapter. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 33: Checking The Battery And Operational Charging

    Checking the battery and operational charging Checking the battery This system supports only batteries specially designed for this specific system and manufactured by Lenovo or an authorized builder. The system does not support unauthorized batteries or batteries designed for other systems.
  • Page 34 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 35: Chapter 4. Related Service Information

    “Symptom-to-FRU index” on page 40 Service Web site: When the latest maintenance diskette and the system program service diskette become available, they will be posted on http://www.lenovo.com/support Restoring the factory contents by using the product Recovery Disc Set When the main storage drive is replaced because of a failure, no product recovery program is on the new drive.

  • Page 36: Recovery Overview For The Windows 7 Operating System

    To create recovery media, click Start ➙ All Programs ➙ Lenovo PC Experience ➙ Lenovo Tools ➙ Factory Recovery Disks. Then, follow the instructions on the screen.

  • Page 37: Performing Backup And Recovery Operations

    This section provides instructions on how to perform a backup operation using the Rescue and Recovery program. 1. From the Windows desktop, click Start ➙ All Programs ➙ Lenovo PC Experience ➙ Lenovo Tools ➙ Enhanced Backup and Restore. The Rescue and Recovery program opens.

  • Page 38: Using The Rescue And Recovery Workspace

    This section provides instructions on how to perform a recovery operation using the Rescue and Recovery program. 1. From the Windows desktop, click Start ➙ All Programs ➙ Lenovo PC Experience ➙ Lenovo Tools ➙ Enhanced Backup and Restore. The Rescue and Recovery program opens.

  • Page 39: Creating And Using A Rescue Medium

    Creating a rescue medium This section provides instructions on how to create a rescue medium. 1. From the Windows desktop, click Start ➙ All Programs ➙ Lenovo PC Experience ➙ Lenovo Tools ➙ Enhanced Backup and Restore. The Rescue and Recovery program opens.

  • Page 40: Reinstalling Preinstalled Programs And Device Drivers

    Attention: If you need updated device drivers for your computer, do not download them from the Windows Update Web site. Obtain them from the Lenovo Web site at http://www.lenovo.com/ThinkPadDrivers. Solving recovery problems...

  • Page 41: Recovery Overview For The Windows 10 Operating System

    • Use recovery media if all other methods of recovery have failed and you need to restore the storage drive to the factory default settings. See “Creating and using a recovery media” on page 30. Note: If you are unable to access the Rescue and Recovery workspace or the Windows environment from a rescue medium or recovery media, you might not have the rescue device (an internal storage drive, a disc, a USB hard disk drive, or other external devices) set as the first boot device in the startup device sequence.

  • Page 42: Creating And Using A Recovery Usb Drive

    The computer does not start until the password is entered. Note: If only a supervisor password is set, the password prompt will not be displayed when the operating system is started. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 43: Power-On Password

    If it has, it can be used for access to the hard disk drive. If no master hard disk password is available, neither Lenovo nor Lenovo authorized service technicians provide any services to reset either the user or the master hard disk password, or to recover data from the hard disk drive. The hard disk drive can be replaced for a scheduled fee.

  • Page 44: How To Remove The Hard Disk Password

    To put the system back to operational status, the only Lenovo and Lenovo-authorized service solution would be to replace the hard disk drive or solid-state drive with a scheduled fee.

  • Page 45: Sleep Mode

    To put the computer into screen blank mode, do the following: 1. Right-click the battery gauge in the task bar. 2. Select Power off display. To end screen blank mode and resume normal operation, press any key. Sleep mode When the computer enters sleep mode, the following events occur in addition to what occurs in screen blank mode: •...

  • Page 46: Symptom-To-Fru Index

    EAIA data access error—The access to EEPROM is failed. 0188 System board Invalid RFID Serialization Information Area. 0189 System board Invalid RFID configuration information area—The EEPROM checksum is not correct. 0190 1. Charge the battery. Critical low-battery error 2. Battery ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 47: Error Messages

    Table 1. Numeric error codes (continued) Symptom or error FRU or action, in sequence 0191 1. Run the ThinkPad Setup program, and then save System Security—Invalid Remote Change requested. current setting by pressing F10. 2. System board 0199 1. Run the ThinkPad Setup program, and then save System Security—Security password retry count the current setting by pressing F10.

  • Page 48: Beep Symptoms

    However, if the LCD has three or more visible defective pixels, it will be deemed as defective by Lenovo and it should be replaced. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 49: Intermittent/Undetermined Problems

    • This policy applies to all ThinkPad notebooks purchased on 1 January, 2008 or later. • Lenovo will not provide warranty replacement if the LCD is within specifications because we cannot guarantee that any replacement LCD will have zero pixel defects.
  • Page 50 7. If the problem remains, replace the following FRUs one at a time (do not replace a nondefective FRU): a. System board b. LCD assembly ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 51: Chapter 5. Function Keys

    • When the Fn Lock function is disabled: The Fn Lock indicator is off. To initiate the special function printed as an icon on each key, press the function key directly. To input F1- F12, press the Fn key and the corresponding function key. © Copyright Lenovo 2016...
  • Page 52 Has the same function as the Pause key. Fn+S Has the same function as the SysRq key. Fn+4 Puts your computer into sleep mode. To return to normal operation, press the Fn key only. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 53: Chapter 6. Locations

    Power button with system-status indicator Security-lock slot ® Fan louvers Mini DisplayPort connector USB 3.0 connector Always On USB 3.0 connector Trackpad Fingerprint reader (available on some models) ® TrackPoint pointing device Screen (multi-touch screen on some models) © Copyright Lenovo 2016...

  • Page 54: Left-Side View

    Speakers Emergency-reset hole Status indicators This topic helps you locate and identify the various status indicators on your computer. Note: Depending on the model, your computer might look different from the following illustrations. ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 55 Table 7. Status indicators Indicator Meaning Speaker-mute indicator On: The speakers are muted. Microphone-mute indicator On: The microphones are muted. Camera-status indicator On: The camera is in use. Chapter 6 Locations...

  • Page 56: Locating Frus And Crus

    CRUs, you can either install the CRU yourself or you can request that a Service Provider install the CRU according to the warranty service for your product. If you intend on installing the CRU, Lenovo will ship the CRU to you. CRU information and replacement instructions are shipped with your product and are available from Lenovo at any time upon request.

  • Page 57: Major Frus

    Major FRUs Table 8. Major FRUs Descriptions Self-service CRU Optional-service LCD unit (see “LCD FRUs” on page 53) Keyboard bezel assembly System board assembly Power button card Chapter 6 Locations...
  • Page 58 Lenovo recovery disc set are used to restore the Microsoft Windows operating system. They might not come with the computer, and a user might order them from http://www.lenovo.com/lenovorecovery, though additional shipping and handling fees might apply. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 59: Lcd Frus

    LCD FRUs Table 9. LCD FRUs No. Descriptions Self-service CRU Optional-service LCD bezel assembly Camera/microphone card* Chapter 6 Locations...

  • Page 60: Miscellaneous Parts And Other Frus

    • Battery latch R (1) • Battery knob L (1) • Battery knob R (1) • Front rubber foot (1) • Rear rubber foot (1) • Base cover ESD sponge (1) • Battery latch spring (1) ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 61: Connector And Cable Guide

    Available on some models Connector and cable guide This topic provides information to help Lenovo authorized service technicians identify connectors and cables for replacement purpose. To view each FRU and the exploded illustration of the computer, see “Major FRUs” on page 51 and “LCD FRUs” on page 53.
  • Page 62 Connect the cable to this connector. LCD connector (internal) LCD cable Connect one end to the LCD panel and the other end to this connector. USB 3.0 connector (external) Connect USB-compatible devices to this connector. ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 63 Table 11. System board connector and cable guide (continued) Item Connector (location) Internal cable required Cable connection HDMI connector (external) Connect a compatible digital audio device or video monitor to this connector. Audio connector (external) Connect headphones or a headset with 3.5-mm (0.14-inch) 4-pole plug to this connector.
  • Page 64 Smart card reader connector Smart card cable Connect one end to the smart card (internal) reader connector on the system board and the other end to this connector. Wireless-WAN card connectors and cables ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 65: Looking Up Fru Information

    Connect one end of the (internal) wireless-LAN black antenna to the A-cover and the other end to this connector. Looking up FRU information For detailed FRU information, including part numbers, descriptions, and substitution part numbers, go to http://www.lenovo.com/serviceparts-lookup. Chapter 6 Locations...
  • Page 66 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 67: Chapter 7. Fru Replacement Notices

    Lenovo will ship the CRU to you. CRU information and replacement instructions are shipped with your product and are available from Lenovo at any time upon request. You can find a list of CRUs for your product in this Hardware Maintenance Manual. An electronic version of this manual can be found at http://www.lenovo.com/support.

  • Page 68: Retaining Serial Numbers

    If you replace the system board, you must restore the serial number of the system unit to its original value. The serial number of the system unit is written on the label attached to the bottom of the computer. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 69: Retaining The Uuid

    ThinkPad Setup program is set to UEFI Only. 1. Connect a USB memory key to the computer. 2. Go to http://www.lenovo.com/maintenanceutilities and follow the instructions on the screen to create a Maintenance Key. Note: Only an authorized Lenovo service technician can access the above Web site.

  • Page 70: Reading Or Writing The Eca Information

    If the system board is being replaced, try to read the ECA information from the old system board and transfer the information to the new system. If the system board is inoperable, this will not be possible. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 71: Chapter 8. Removing Or Replacing A Fru

    Lenovo will ship the CRU to you. CRU information and replacement instructions are shipped with your product and are available from Lenovo at any time upon request. You can find a list of CRUs for your product in this Hardware Maintenance Manual. An electronic version of this manual is available for downloading at http://www.lenovo.com/support.

  • Page 72: Before Servicing The Computer

    For access, remove this FRU: • “1010 Removable battery” on page 67 If the computer has a micro SIM card installed, you also must remove the micro SIM card before you start the servicing. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 73: Removing A Major Fru

    The only exception to this is if the battery pack is physically damaged or a customer is reporting a possible safety issue. If the Lenovo Solution Center program is not installed on the computer, the customer should download and install the program to diagnose the battery pack, before getting a non-physically damaged battery pack replaced.

  • Page 74: 1020 Base Cover Assembly

    1020 Base cover assembly For access, remove this FRU: • “1010 Removable battery” on page 67 Removal steps of the base cover assembly ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 75: Applying Labels To Base Cover

    Applying labels to the base cover: The new base cover assembly is shipped with a kit containing labels of several kinds. Apply those labels when you replace the base cover assembly. For the labels that are not shipped with the new base cover assembly, peel them from the old base cover assembly, and adhere them to the new one.

  • Page 76: 1030 Keyboard

    Indonesia Rating label (for Indonesia) Postel label (for Indonesia and Malaysia), and MCMC label (for Malaysia) INDIA BIS label (for India) 1030 Keyboard For access, remove this FRU: • “1010 Removable battery” on page 67 ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 77 Removal steps of the keyboard 1. To reveal the screw heads beneath the keyboard frame, slide the keyboard frame forward by 2.5 mm (0.1 inch) with the flat end of the keyboard multi-tool. 2. Loosen the screws that secure the keyboard with the cross end of the keyboard multi-tool. Chapter 8 Removing or replacing a FRU...
  • Page 78 3. Pivot the keyboard slightly upward until you can see the connectors on the bottom side of the keyboard . Then turn over the keyboard 4. Gently put the keyboard on the palm rest and detach the connectors. Then remove the keyboard. ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 79 Installing the new keyboard 1. Attach the connectors and then turn over the keyboard. 2. Insert the keyboard into the space under the frame of the keyboard bezel as shown. Ensure that the front edge of the keyboard (the edge that is close to the display) is under the frame of the keyboard bezel. Chapter 8 Removing or replacing a FRU...
  • Page 80 3. Reveal the screw heads by sliding the keyboard frame forward with the flat end of the keyboard multi-tool. Ensure that the screw heads are exposed completely. 4. Tighten the screws with the cross end of the keyboard multi-tool to secure the keyboard in place. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 81: 1040 Storage-Drive Stabilizer Bar, Internal Storage Drive, And Hard Disk Drive Cable

    5. Slide the keyboard frame backward by 2.5 mm (0.1 inch) with the flat end of the keyboard multi-tool. Hide the latches of the keyboard frame under the keyboard bezel by pushing the latches with your finger as shown. 6. Adjust the keyboard frame in place with the flat end of the keyboard multi-tool to ensure that all the latches are secured under the keyboard bezel.
  • Page 82 Screw (quantity) Color Torque M2 × L3.5 mm, flat-head, nylon-coated (2) Silver 0.181 Nm (1.85 kgf-cm) Step Screw (quantity) Color Torque 0.181 Nm M2 × L3.5 mm, flat-head, nylon-coated (1) Silver (1.85 kgf-cm) ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 83: 1050 Memory Module

    When installing: Ensure that the internal storage drive is firmly attached. 1050 Memory module For access, remove this FRU: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 Chapter 8 Removing or replacing a FRU...

  • Page 84: 1060 Wireless-Lan Card

    Note: This information is only for the user-replaceable modules. For access, remove this FRU: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 Removal steps of the wireless-LAN card ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 85: 1070 Wireless-Wan Card

    Step Screw (quantity) Color Torque Bronze 0.181 Nm M2 × L3.5 mm, flat-head, nylon-coated (1) (1.85 kgf-cm) When installing: Plug the gray cable into the main connector and the black cable into the auxiliary connector. 1070 Wireless-WAN card Note: This information is only for the user-replaceable modules. For access, remove this FRU: •...

  • Page 86: 1080 Coin-Cell Battery

    When installing: Plug the orange cable into the main connector and the blue cable into the auxiliary connector. 1080 Coin-cell battery For access, remove this FRU: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 87: 1110 Dc-In Bracket And Dc-In Cable

    Removal steps of the coin-cell battery When installing: Ensure that the connector is attached firmly. 1110 dc-in bracket and dc-in cable For access, remove these FRUs: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 Removal steps of the dc-in bracket and dc-in cable Chapter 8 Removing or replacing a FRU...

  • Page 88: 1120 Built-In Battery Or Dummy Battery

    1120 Built-in battery or dummy battery Important notices for replacing a battery Attention: Lenovo has no responsibility for the performance or safety of unauthorized batteries, and provides no warranties for failures or damage arising out of their use. ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 89 The only exception to this is if the battery is physically damaged or a customer is reporting a possible safety issue. If the Lenovo Solution Center program is not installed on the computer, the customer should download and install the program to diagnose the battery, before getting a non-physically damaged battery replaced. Note that the replacement of a physically damaged battery is not covered by the warranty.

  • Page 90: 1130 Thermal Fan

    For access, remove this FRU: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 Removal steps of the thermal fan When installing: Ensure that the fan connectors are attached firmly. ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 91 Loosen the screws in ascending alphabetical order as illustrated. Note: The thermal fan on your computer might look differently. For some models, you might not have to perform steps in the following illustration. Chapter 8 Removing or replacing a FRU...

  • Page 92: 1140 Speaker Assembly

    Removal steps of the speaker assembly Step Screw (quantity) Color Torque Black 0.181 Nm M2 × L2.5 mm, flat-head shoulder, nylon-coated (3) (1.85 kgf-cm) When installing: Ensure that the connector is attached firmly. ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 93: 1150 Smart Card Reader Or Dummy Smart Card Reader, And Smart Card Cable

    Cable routing: When you install the speaker assembly, route the cables as shown in the following illustration. 1150 Smart card reader or dummy smart card reader, and smart card cable Depending on the model, your computer might have a smart card reader or a dummy smart card reader installed.
  • Page 94 (1.85 kgf-cm) Removal steps of the smart card cable Removal steps of the dummy smart card reader Step Screw (quantity) Color Torque Black 0.181 Nm M2 × L3 mm, flat-head, nylon-coated (1) (1.85 kgf-cm) ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 95: 1160 System Board Assembly

    1160 System board assembly Important notices for handling the system board When handling the system board, read the following: • The system board has an accelerometer, which can be broken when several thousands of G-forces are applied. Note: Dropping a system board from a height of as little as six inches so that it falls flat on a hard bench can subject the accelerometer to as much as 6000 G's of shock.

  • Page 96: 1170 Lcd Unit

    M2 × L3.5 mm, flat-head, nylon-coated (6) Silver 0.181 Nm (1.85 kgf-cm) 1170 LCD unit For access, remove these FRUs in order: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 97 Removal steps of the LCD unit When installing: When you route the cables, ensure that they are not subject to any tension. Tension could cause the cables to be damaged by the cable guides, or a wire to be broken. Chapter 8 Removing or replacing a FRU...

  • Page 98: 1210 Power Button Card And Power Button Card Cable

    1210 Power button card and power button card cable For access, remove these FRUs in order: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 • “1170 LCD unit” on page 90 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 99: 1220 Keyboard Assembly

    Removal steps of the power button card and power button card cable Torque Step Screw (quantity) Color M2 × L3 mm, flat-head, nylon-coated (2) Black 0.181 Nm (1.85 kgf-cm) When installing: Ensure that the connector is attached firmly. 1220 Keyboard assembly Removal steps of the keyboard assembly To replace the keyboard assembly, remove these FRUs in order: •...

  • Page 100: Removing An Lcd Fru

    For access, remove these FRUs in order: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 • “1170 LCD unit” on page 90 • “2010 LCD bezel assembly” on page 94 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 101: 2030 Lcd Panel And Lcd Cable

    Removal steps of the hinges Step Screw (quantity) Color Torque M2.5 × L2.5 mm, big-head, nylon-coated (6) Silver 0.294 Nm (3 kgf-cm) 2030 LCD panel and LCD cable For access, remove these FRUs in order: • “1010 Removable battery” on page 67 •...

  • Page 102: 2040 Camera/Microphone Card

    For access, remove these FRUs in order: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 • “1170 LCD unit” on page 90 • “2010 LCD bezel assembly” on page 94 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 103: 2050 Led Cable Assembly

    Removal steps of the camera/microphone card When installing: Ensure that the connector is attached firmly. 2050 LED cable assembly For access, remove these FRUs in order: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 •...

  • Page 104: 2060 Antenna Kit

    Removal steps of the antenna kit For access, remove these FRUs in order: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 • “1170 LCD unit” on page 90 ThinkPad T560 and P50s Hardware Maintenance Manual...
  • Page 105 • “2010 LCD bezel assembly” on page 94 • “2020 Hinges” on page 94 • “2030 LCD panel and LCD cable” on page 95 Chapter 8 Removing or replacing a FRU...
  • Page 106 Ensure that the cables are not subject to any tension. Tension could cause the cables to be damaged by the cable guides, or a wire to be broken. Blue cable (WWAN auxiliary) Black cable (WLAN auxiliary) Red cable (WWAN main) Gray cable (WLAN main) ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 107: 2070 Hinges Brackets

    Antenna locations WLAN auxiliary antenna (black) WWAN auxiliary antenna (blue) WWAN main antenna (red) WLAN main antenna (gray) 2070 Hinges brackets For access, remove these FRUs in order: • “1010 Removable battery” on page 67 • “1020 Base cover assembly” on page 68 •...

  • Page 108: 2080 Lcd Rear Cover Assembly

    “2030 LCD panel and LCD cable” on page 95 • “2040 Camera/microphone card” on page 96 • “2050 LED cable assembly” on page 97 • “2060 Antenna kit” on page 98 • “2070 Hinges brackets” on page 101 ThinkPad T560 and P50s Hardware Maintenance Manual...

  • Page 109: Appendix A. Notices

    Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo product, program, or service may be used. Any functionally equivalent product, program, or service that does not infringe any Lenovo intellectual property right may be used instead.

  • Page 110: Electronic Emissions Notices

    For electronic emission information on Class B digital devices, refer to the corresponding information in the User Guide. Trademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Lenovo Lenovo logo Rescue and Recovery...
  • Page 112 Part Number: SP40K04930 (1P) P/N: SP40K04930 *1PSP40K04930*...

This manual is also suitable for:

Thinkpad p50s

Table of Contents