Introduction; Ansi Safety Definitions; Rules For Safe Operation - North Star 6500 DPG Owner's Manual

The reset button must be pushed to reset the
receptacle.
Reference 20 - 120 Volt-30 Amp Tw istlock
Receptacle. The control panel is equipped with
one NEMA L5-30R receptacle.
accepts only NEMA L5-30P plugs, one of which is
shipped with the generator.
Reference 21 -
Tw istlock Receptacle.
equipped with one NEMA L14-30R receptacle.
This receptacle accepts only NEMA L14-30P plugs,
one of which is shipped with the generator. This
receptacle is popular for connection to a transfer
switch for home standby power. See item #16412 in
the NORTHERN catalog.
Reference 22 - Ignition Sw itch. To start the
engine turn the key to the START position. To stop
the engine turn the key to the OFF position. See
the section on starting for further details.
Reference 23 - Charging Lamp. The charging
lamp will glow when the engine charging system is
not functioning correctly. The lamp will glow when
the ignition key is in the run position and the
engine is not running.
Reference 24 - Hour Meter. The hour meter
allows for monitoring of engine maintenance
schedules.
Reference 25 -
allows for monitoring of the generator. The needle
should be in the green area for all load conditions.
GENERATOR FEATURES NOT SHOWN
Low Oil Pressure Shutdow n.
engine is protected against damage resulting from
a low oil level. As the oil falls below the safe level,
the engine automatically shuts off (the engine
ignition switch remains in the on position). The
engine will not start until the oil is refilled to above
the safe level.
Fuel Shut Off Valv e. The fuel tank is equipped
with a fuel shut off valve. Always turn the fuel valve
to the off position when the generator is not in use.
The valve is located underneath the fuel tank.
Fuel Drain Valv e. The fuel tank is equipped
with a unique feature. A fuel drain valve is installed
to drain diesel fuel
disconnecting the fuel feeding line from
engine. Always make sure this valve is closed prior
to filling the fuel tank.
This receptacle
120/240 Volt-30
The control panel is
Voltmeter. The voltmeter
The Yanmar
from the tank without
Before starting your generator, thoroughly study
the instructions and cautions in this manual to
assure you are fully acquainted with the operation
of all
preparation, operation and maintenance will result
Amp
in operator safety, best performance and long life of
the generator. For detailed engine operation and
maintenance always refer to the Yanmar engine
owner's manual
(Yanmar refers to the 10 HP engine as a L100AE-
DE).
NorthStar is constantly improving its products.
The specifications outlined herein are subject to
change without prior notice or obligation.
purchaser and/or user assumes liability of any
modification and/or alterations on this equipment
from original design and manufacture.
Before using, the user shall determine the
suitability of this product for its intended use and
assumes liability therein.

ANSI SAFETY DEFINITIONS

DANGER
situation which, if not avoided, will result in death
or serious injury. This signal word is to be limited
to the most extreme situations.
WARNING
situation which, if not avoided, could result in a
death or serious injury.
CAUTION
situation, which if not avoided, may result in
minor or moderate injury. It may also be used to
alert against unsafe practices.
RULES FOR SAFE OPERATIONS
Safety precautions are essential when operating
this generator. Respectful and cautious operation
will considerably lessen the possibilities of a
personal injury. This manual will warn of specific
personal
designated by the symbol:
the
5

INTRODUCTION

components of this generator.
furnished with the
indicates an imminently hazardous
indicates a potentially hazardous
indicates a potentially hazardous
injury potential, and these will
Proper
generator
The
be