Winnebago Chalet 22BR Owner's Manual
  1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. Chalet 22BR
  6. Owner's manual
Winnebago Chalet 22BR Owner's Manual

Winnebago Chalet 22BR Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Occupant and Cargo Carrying Capacity Label ................................................................................. 1-3
Vehicle Certification Label ............................................................................................................... 1-4
Specifications and Capacities ........................................................................................................... 1-5
Owner and Vehicle Information ....................................................................................................... 1-6
General Warnings ............................................................................................................................. 2-1
Driving Safety ................................................................................................................................... 2-1
Fuel and Propane Gas ....................................................................................................................... 2-1
Propane Gas Leaks ............................................................................................................................ 2-2
Propane Gas Leak Detector .............................................................................................................. 2-3
Carbon Monoxide Warning .............................................................................................................. 2-3
Carbon Monoxide Alarm .................................................................................................................. 2-3
Smoke Alarm .................................................................................................................................... 2-4
Fire Extinguisher ............................................................................................................................... 2-5
Electrical ........................................................................................................................................... 2-5
Loading ............................................................................................................................................. 2-5
Maintenance ...................................................................................................................................... 2-6
Emergency Exits ............................................................................................................................... 2-6
Power Sofas and Beds ....................................................................................................................... 2-7
Slideout Rooms ................................................................................................................................. 2-7
Formaldehyde Information ............................................................................................................... 2-7
Mold, Moisture, and Your Motor Home ........................................................................................... 2-8
Roof and Ladders .............................................................................................................................. 2-8
Roadside Emergency ........................................................................................................................ 2-9
Jump Starting .................................................................................................................................. 2-10
Engine Overheat ............................................................................................................................. 2-10
Seats - Driver/Co-Pilot ..................................................................................................................... 3-1
Fold-Down Dinette Seat ................................................................................................................... 3-1
Seat Belts .......................................................................................................................................... 3-1
Child Restraints ................................................................................................................................. 3-2
Keys .................................................................................................................................................. 3-3
Rev. 1307130128

TABLE OF CONTENTS

Copyright 2012 Winnebago Industries, Inc. All rights reserved.
Part No. 161500-13-024

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Chalet 22BR and is the answer not in the manual?

Questions and answers

Related Manuals for Winnebago Chalet 22BR

Summary of Contents for Winnebago Chalet 22BR

  • Page 1: Table Of Contents

    3 – DRIVING YOUR MOTOR HOME Seats – Driver/Co-Pilot ........................3-1 Fold-Down Dinette Seat ........................3-1 Seat Belts ............................3-1 Child Restraints ..........................3-2 Keys ..............................3-3 Rev. 1307130128 Part No. 161500-13-024 Copyright 2012 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table Of Contents Hazard Warning Flashers ........................3-3 Mirrors – Power Sideview Exterior ....................3-3 Mirrors – Power Sideview Exterior ....................3-5 Battery Boost Switch ........................3-5 Air Conditioner/Heater – Automotive (Dash) .................. 3-5 Radio In-Dash/Rearview Monitor System ..................3-6 Radio –...
  • Page 3 Table Of Contents House/Coach Battery Disconnect Switch ..................6-6 Battery Access ..........................6-6 Battery Care ............................6-7 Circuit Breakers and Fuses – House 12-Volt DC ................6-8 7 – PLUMBING Fresh Water System .......................... 7-1 Water Pump ............................7-2 Disinfecting Your Fresh Water System .................... 7-3 Shower Hose Vacuum Breaker ......................
  • Page 4 Roller Shades (Manual) - Solar Day/Night ..................9-9 Wood Furniture and Cabinetry ......................9-9 10 – SLIDEOUT ROOMS Slideout Room Keylock ........................10-1 Slideout Room Operation – Electric ....................10-1 Slideout Room – Extreme Weather Precaution ................10-3 Slideout Room Troubleshooting (Lippert) ..................10-3 Slideout Emergency Retraction ......................
  • Page 5 Power Roof Ventilator ........................12-7 Effects of Prolonged Occupancy ....................12-8...

  • Page 7: Introduction

    The instructions included in this manual are intended as a guide, and in no way DANGER indicates a hazardous situation extend the responsibilities of Winnebago which, if not avoided, will result in death or Industries beyond the standard written serious personal injury.

  • Page 8: Pre-Delivery Inspection

    National Highway Traffic Safety Administration delivery inspection of the chassis and all (NHTSA) in addition to notifying Winnebago motorhome components. Industries, Inc. As a part of the pre-delivery inspection...

  • Page 9: Occupant And Cargo Carrying Capacity Label

    SECTION 1 – INTRODUCTION or go to their website at http://www.safercar.gov or write to: Administrator, NHTSA 1200 New Jersey Avenue S.E. Washington, D.C. 20590 You can also obtain other information about motor vehicle safety from the NHTSA website at http://www.safercar.gov OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to...

  • Page 10: Vehicle Certification Label

    These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.

  • Page 11: Specifications And Capacities

    SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITIES 24VR 22BR 26QR 31CR 31JR 31RR Standard Optional ® ® ® ® ® Chalet Ford E350 Ford E450 Ford E450 Ford E450 Ford E450 ® ® Ford E350 Ford E450 Chassis Chassis Chassis Chassis Chassis Chassis...

  • Page 12: Owner And Vehicle Information

    Motorhome Serial Number ___________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...

  • Page 13: Safety And Precautions

    SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...

  • Page 14: Propane Gas Leaks

    SECTION 2 – SAFETY AND PRECAUTIONS WARNING Propane gas containers, gasoline, or other flammable liquids shall not be placed or stored onboard the vehicle because a fire or explosion may result. Propane gas containers are equipped with safety valves, which relieve Unlike homes, the amount of oxygen supply is excessive pressure by discharging gas limited due to the size of the recreational vehicle,...

  • Page 15: Propane Gas Leak Detector

    SECTION 2 – SAFETY AND PRECAUTIONS battery during storage periods when the house PROPANE GAS LEAK battery will not be charged regularly by the DETECTOR engine or shoreline. Your coach is equipped with a Propane Gas Further Information Leak Detector, similar to the one shown below. See the manufacturer’s user guide provided in The leak detector sounds an alarm if an unsafe your InfoCase for further instructions.

  • Page 16: Smoke Alarm

    RV application. We that is also listed for RV application. We recommend obtaining a replacement from your recommend obtaining a replacement from your ® Winnebago Industries dealer. ® Winnebago Industries dealer. Further Information...

  • Page 17: Fire Extinguisher

    Extinguisher, the replacement must be the same type and size as the one originally supplied in your coach. We recommend obtaining a replacement only from your Winnebago ® Industries dealer or a reliable RV parts supplier.

  • Page 18: Maintenance

    SECTION 2 – SAFETY AND PRECAUTIONS MAINTENANCE • Do not remove the radiator cap while engine and radiator are still hot. Always check coolant level visually at the see-through coolant reservoir. • Never get beneath a vehicle that is held up by a jack only.

  • Page 19: Power Sofas And Beds

    SECTION 2 – SAFETY AND PRECAUTIONS place, the cord can be replaced using a blunt instrument, preferably one made of plastic. We recommend you contact your dealer for WARNING assistance. Keep all persons clear of the slideout POWER SOFAS AND BEDS room and moving parts while extending or retracting.

  • Page 20: Mold, Moisture, And Your Motor Home

    If Mold Is Present, What Will reproduce by means of tiny spores. Those spores Winnebago Industries ® are invisible to the naked eye and float If Winnebago Industries determines that mold throughout the outdoor and indoor air. Because ® ® is present in the Winnebago...

  • Page 21: Roadside Emergency

    SECTION 2 – SAFETY AND PRECAUTIONS The ladder on your motorhome is provided for • Never allow children on the ladder. limited access to the roof. • Do not transport items anchored to the Walking or working on the roof should be left ladder.

  • Page 22: Jump Starting

    If you see or hear steam escaping from the ® engine compartment or have any other reason to Winnebago Industries does not assume suspect an extreme engine overheating condition, responsibility for damage incurred while towing pull the vehicle over to the roadside as soon as it this vehicle.
  • Page 23 SECTION 2 – SAFETY AND PRECAUTIONS NOTICE Operating a vehicle under a severe overheating condition can result in damage to the vehicle. For information on what to do in case of overheating, consult your chassis manual. 2-11...

  • Page 25: Driving Your Motor Home

    SECTION 3 – DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach.

  • Page 26: Child Restraints

    SECTION 3 – DRIVING YOUR MOTOR HOME Lap/Shoulder Belts one person use the same safety belt at any one time, and do not let the safety belts become See your chassis manual for instructions on damaged by pinching them in the doors or in the proper fastening, adjustment, and releasing of seat mechanism.

  • Page 27: Keys

    SECTION 3 – DRIVING YOUR MOTOR HOME Further Information 3. Be certain that it is appropriate for the child's height, weight, and development. The See the child seat manufacturer’s specific instructions and/or the regulation label instructions for proper attachment and attached to the restraint typically provides this adjustment of the tether and seat belts.
  • Page 28 SECTION 3 – DRIVING YOUR MOTOR HOME Mirror Heat Switch Mirror Adjustment Control Mirror Pivot Lock • Mirror surface tilts in direction of arrow button • Unscrew protective cap and loosen Allen head pressed. set screw to pivot mirror head. •...

  • Page 29: Battery Boost Switch

    SECTION 3 – DRIVING YOUR MOTOR HOME Mirror Head Adjustment MIRRORS – POWER SIDEVIEW If you cannot adjust a mirror properly using EXTERIOR the control switch, the mirror may need a coarse adjustment by rotating the mirror head. –If Equipped Always adjust mirrors for maximum rear Further Information visibility before traveling.

  • Page 30: Radio In-Dash/Rearview Monitor System

    SECTION 3 – DRIVING YOUR MOTOR HOME NOTE: The dash air conditioner is not designed • AUDIO - Press and Hold to access AUDIO to cool the entire interior of the coach, MENU. Press to return to current playback but is intended only to provide cooling mode.

  • Page 31: Radio - In-Dash

    SECTION 3 – DRIVING YOUR MOTOR HOME Radio Power Switch (Located on dash) iPod Cable • Press HOUSE to listen to the radio while -Typical View parked without the ignition key on. • Press ENGINE to listen while driving. See the manufacturer’s information in your InfoCase for operating instructions.

  • Page 32: Engine Access - Interior

    SECTION 3 – DRIVING YOUR MOTOR HOME Satellite Radio by house batteries. If the House/Coach Battery Disconnect switch is OFF, the –If Equipped speakers will not emit sound. ® Your coach may be equipped with a Sirius satellite radio receiver that plays through your radio.

  • Page 33: Engine Cooling System

    SECTION 3 – DRIVING YOUR MOTOR HOME WARNING Make sure all replacement tires are of the same size and rating as those shown on your Vehicle Certification Label. SUSPENSION ALIGNMENT AND TIRE BALANCE The front suspension and steering system of this vehicle was factory aligned using highly accurate equipment prior to delivery to the Front Engine Latches...

  • Page 34: Air Springs - Rear Helper

    SECTION 3 – DRIVING YOUR MOTOR HOME AIR SPRINGS – REAR HELPER LIGHTS (AIR BAGS) All exterior lights should be checked for proper operation each time the vehicle is –If Equipped prepared for a trip. Any bulbs which fail to light The rear air helper springs (air bags) are an should be checked and replaced, when necessary, enhancement to the standard suspension system...

  • Page 35: Appliances And Systems

    SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motorhome are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. See Section 2 - Safety and Precautions of this manual for any safety and precautions you need to take regarding the operation of your appliances.

  • Page 36: Refrigerator Service Access Compartment

    SECTION 4 – APPLIANCES AND SYSTEMS To Open 1. Use a screwdriver or coin to turn the latch knobs to the vertical position as shown. Refrigerator Access Door Latches • Gas- Refrigerator will operate on gas from the propane tank if the main valve is open and the 2.

  • Page 37: Avoiding Asphyxiation

    SECTION 4 – APPLIANCES AND SYSTEMS WARNING IT IS NOT SAFE TO USE COOKING APPLIANCES FOR COMFORT HEATING Cooking appliances need fresh air for safe operation. Before operation: 1. Open overhead vent or turn on exhaust fan. 2. Open window. FAILURE TO COMPLY COULD RESULT IN To Light Range Top Burners DEATH OR SERIOUS INJURY...

  • Page 38: Microwave Oven

    SECTION 4 – APPLIANCES AND SYSTEMS pump and water heater. Indicator lights tell you if MICROWAVE OVEN the water pump is on or if the water heater pilot light is out. -If Equipped Refer to the manufacturer’s user guide located Water And Holding Tank Levels inside the appliance for complete operating Press and Hold the Levels Test switch to show...

  • Page 39: Water Heater - Gas/ Electric

    SECTION 4 – APPLIANCES AND SYSTEMS Tank Capacities See “Tank Capacities” in Section 1 - Introduction. Propane Gas Level Press and Hold the Levels Test switch to show approximate propane tank level. The propane level is registered by a sending unit on the tank.
  • Page 40 SECTION 4 – APPLIANCES AND SYSTEMS Further Information Read the operating and safety information provided in the Water Heater Operation Manual in your InfoCase. WATER HEATER - GAS/ ELECTRIC -If Equipped (with Motoraid water heating system) The gas/electric water heater has a dual power Gas Water Heater Switch feature.

  • Page 41: Pressure-Temperature Relief Valve

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information Read the operating and safety information provided in the Water Heater Operation Manual in your InfoCase. PRESSURE-TEMPERATURE RELIEF VALVE On occasion, water may be seen seeping from the water heater pressure temperature relief valve.

  • Page 42: Propane Gas Furnace

    SECTION 4 – APPLIANCES AND SYSTEMS 2. Open a faucet in the motorhome to relieve water pressure. 3. Pull the handle of the P-T valve straight out and allow water to flow until it stops. Thermostat/Switch Room Temperature •Move from OFF to Thermometer desired temperature •Lift handle straight out to open P-T valve...

  • Page 43: Ducted Roof Air Conditioning System

    SECTION 4 – APPLIANCES AND SYSTEMS To Shut Down NOTE: If heat does not come out of the heat ducts after a minute or so the burner is • Move Thermostat switch to OFF position. not lit. • Close Propane Gas Tank valve if coach will be Turn thermostat off for 3-5 minutes, stored for a period of time.

  • Page 44: Air Conditioner Filter

    SECTION 4 – APPLIANCES AND SYSTEMS NOTE: The ducted roof air conditioning system has ceiling registers that can be closed if necessary to force more cool air toward a specific area of the coach or to route cool air away from a specific area. If too many vents are closed, however, it can cause the air conditioner unit to shut down, particularly in high humidity...

  • Page 45: Propane Gas

    SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.

  • Page 46: Safe Use Of The Propane Gas System

    SECTION 5 – PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk dealerships. DAN G E R NOTE: If you travel outside the U.S. with your motorhome, you may find butane or DO NOT FILL CONTAINER TO MORE propane/butane mixtures available in THAN 80 PERCENT OF CAPACITY.

  • Page 47: Propane Gas Warnings And Precautions

    SECTION 5 – PROPANE GAS • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...

  • Page 48: Propane Gas Pressure Regulator

    SECTION 5 – PROPANE GAS WARNING WARNING Propane cylinders shall not be placed or Visually inspect the pressure regulator stored inside the vehicle. Propane vent periodically for blockage by cylinders are equipped with safety accumulated debris or insect nests, etc. devices that relieve pressure by Vent obstruction could result in excessive discharging propane to the atmosphere.

  • Page 49: Propane Vaporization In Cold Weather

    SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.

  • Page 51: Electrical

    SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motorhome that is • 12-volt DC system (battery current);...

  • Page 52: Power Center

    SECTION 6 – ELECTRICAL 30 Amp Receptacle The power cord is designed to ground the electrical system through the receptacle. It is also designed to carry the amperage output of most • Route power cord through passage campground outlets. If the electrical receptacle to and close door while shoreline is be used is designed to mate with the prongs of the connected to outlet.

  • Page 53: Circuit Breakers - House 120-Volt Ac

    SECTION 6 – ELECTRICAL condition of the battery. If it is below “full 12-Volt 120-Volt charge”, the Charging Section will start charging House Fuses Circuit Breakers the batteries. If the house batteries have been extremely discharged, they will accept charge at a relatively high amperage rate.

  • Page 54: Electrical Outlets - House 120-Volt Ac

    SECTION 6 – ELECTRICAL “Off” and back to “On”. If the breaker is If the GFCI keeps tripping, have the electrical continually tripped and no overload is evident, system checked and repaired, if necessary, before have the system checked for a short in the wiring using again.

  • Page 55: Electrical System - House 12-Volt Dc

    SECTION 6 – ELECTRICAL To use the 120-volt generator, plug the power Refer to the hourmeter to determine when cord into the generator receptacle within the periodic maintenance is due and to record utility compartment before starting the generator. services which have been performed. Operation Warnings and Cautions WARNING The exhaust of all internal combustion...

  • Page 56: House/Coach Battery Disconnect Switch

    SECTION 6 – ELECTRICAL Converter Always leave this switch ON while using the coach. See “Power Center.” NOTE: Some electronic displays and memory Chassis Battery functions may need to be reset after The chassis battery is used to operate the power has been reconnected.

  • Page 57: Battery Care

    SECTION 6 – ELECTRICAL energy is removed from the battery, it should be replaced by the engine alternator or the coach converter system. If a battery sits unused for 30 days or more, especially during warm weather, it can develop a deposit of sulfate crystals on the metal plates inside the battery.

  • Page 58: Circuit Breakers And Fuses - House 12-Volt Dc

    If your coach is going to be unoccupied for in the motorhome is off and the power ® two weeks or more, Winnebago Industries cord has been disconnected. Be sure to recommends disconnecting the chassis battery in replace the battery terminal boot, if your coach to avoid battery discharge.

  • Page 59: Battery Charge Meter

    SECTION 6 – ELECTRICAL Automotive Chassis and House 12-Volt Circuit Breakers (Located inside passenger compartment) -Typical View House 12-Volt Fuses (Located on the right-hand side of the power converter) -Typical View The fuse panel accepts only blade type plug-in fuses. Always replace fuses with those of the same amperage rating.

  • Page 61: Plumbing

    SECTION 7 – PLUMBING FRESH WATER SYSTEM The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water heater. Water may be supplied by either of two sources: • a fresh water tank and water pump located within the motorhome, or Water Tank Gravity Fill •...

  • Page 62: Water Pump

    SECTION 7 – PLUMBING NOTE: Always keep the tank fill valve in Normal position unless you are filling the tank. If this valve is left in the Tank Fill position while using the city water, water will keep flowing into the tank and out the tank vent tube onto the ground and the water pump will run without delivering water to faucets.

  • Page 63: Disinfecting Your Fresh Water System

    SECTION 7 – PLUMBING 2. Turn water pump switch to “OFF” position. system, one that has not been used for a period of time, or one that could have become 3. Fill water tank. contaminated. 4. Open all faucets, hot and cold. This procedure is also recommended before 5.

  • Page 64: Shower Hose Vacuum Breaker

    SECTION 7 – PLUMBING open for some time to flush the water heater EXTERIOR SHOWER/WASH with clean water. You may also want to turn STATION the water heater off until this is done to avoid wasting energy trying to heat “unused” –If Equipped water).

  • Page 65: Drainage System (P-Traps)

    SECTION 7 – PLUMBING Dumping Holding Tanks the holding tank. Toilet tissue made specifically for use in RV toilets and holding tanks is available at most RV supply centers. • Don’t dispose of sanitary napkins or other non-dissolving items in the toilet. •...

  • Page 66: Waste Water System - Waste Pump (Model 26Q)

    SECTION 7 – PLUMBING 7. Rinse sewage drain hose thoroughly with Sewage Drain water and stow. Outlet/Dust Cap NOTE: We recommend that you dump all holding tanks before traveling to avoid carrying unnecessary weight. Using On-Site Sewer Hook-Ups The sewage drain hose may remain attached to the dump outlet and be routed out the bottom of the compartment while the motorhome is parked and connected to an on-site sewage hook-up.

  • Page 67: Dumping Holding Tanks

    SECTION 7 – PLUMBING water holding tank contains the waste water from 2. Remove dust cap from sewage drain outlet the galley sink, shower, and may include and connect sewage drain hose. Be sure it is bathroom lavatory. firmly attached. See “Specifications”...
  • Page 68 SECTION 7 – PLUMBING sewage back-up into gray tank. Gray water also rinses any black water solids from the sewage drain hose. 5. Open the Gray Waste Tank Drain valve (located beneath driver side of coach ahead of rear wheel) and press and hold the Waste Pump switch (located near the exterior shower.) Release the Waste Pump switch and close the Gray Waste Tank Drain valve as...

  • Page 69: Holding Tank Heater

    SECTION 7 – PLUMBING Holding Tank Level Indicators batteries would not support overnight heating without a supplemental charging See “Systems Monitor Panel” in Section 4– source. Appliances for further information on the monitor panel and checking tank levels. WATERLINE & TANK DRAIN See “Specifications”...

  • Page 70: Water Heater Bypass Valve

    SECTION 7 – PLUMBING Normal By-Pass Flow Mode Water Tank Drain Valve (Typical) CAUTION Leave bypass valve handle in NORMAL FLOW position if draining water and blowing out waterlines. Place in BYPASS position ONLY when using antifreeze solution in waterlines. WINTERIZING PROCEDURE You can winterize the water and plumbing system of your coach using one of the following...
  • Page 71 ® ® Leave open after water stops flowing. purchased at any Winnebago or Itasca dealer. 5. Drain Toilet. Press the toilet flush pedal and hold until water stops flowing in the toilet.
  • Page 72 SECTION 7 – PLUMBING 8. Let air flow for five minutes until water is and prevent entry and contamination by completely drained out of faucets and drain airborne debris, insects, and rodents. valves. Then close faucets one at a time. 9.
  • Page 73 SECTION 7 – PLUMBING NOTE: Ensure that all drain valves are CLOSED before pumping RV antifreeze WARNING into the water system. Refer to the “Water System Drain Valve Locations” chart at the end of this NEVER use automotive antifreeze/ section for valve locations on your coolant in your RV water system.
  • Page 74 SECTION 7 – PLUMBING and prevent entry and contamination by airborne debris, insects, and rodents. Your drainage and fresh water systems are now winterized. See instructions for removal from storage in Section 11 - Maintenance and Storage. To Winterize the Waste Pump Water Heater Drain Plug -If Equipped (Remove with socket)

  • Page 75: Water System Drain Valve Locations

    SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS 24VR Waterlines • Two (2) valves beneath shower. Access through removable panel on lower front of shower cabinet. • Two (2) valves beneath the bed. Lift mattress to expose access hole.
  • Page 76 SECTION 7 – PLUMBING 31CR Waterlines • Three (3) valves under galley sink. Remove bottom drawer to access. Also, place the tip of your finger inside the city water connection and gently press the backflow valve (small “button” in center of connector) to drain any water left in the city waterline.
  • Page 77 SECTION 7 – PLUMBING 31RR Waterlines • Two (2) valves beneath the bed. Lift mattress to expose access hole. Also, place the tip of your finger inside the city water connection and gently press the backflow valve (small “button” in center of connector) to drain any water left in the city waterline.

  • Page 79: Entertainment

    SECTION 8 – ENTERTAINMENT VIDEO SELECTION SYSTEM –If Equipped The Video Selection System allows you to • The Video Selection System allows you to switch the antenna, AUX/VCR, cable TV, watch DVD’s from either the lounge area satellite TV, or DVD signal to any TV set (main TV), bedroom, or the exterior location in the coach.

  • Page 80: Tv - (Swing-Out)

    SECTION 8 – ENTERTAINMENT Further Information TV – (SWING-OUT) See the television manufacturer’s user guide –If Equipped provided in your InfoCase for complete operating (Typical View - your coach may vary in instructions. appearance according to floorplan) Your coach may be equipped with a TV SWING-OUT TV MOUNT swivel/telescoping mechanism, which allows (FRONT BUNK)

  • Page 81: Tv/Dvd Master Power Switch (12-Volt)

    SECTION 8 – ENTERTAINMENT The available DVD home theater system TV/DVD MASTER POWER operates from 120-volt AC household current SWITCH (12-VOLT) only, so you must have either the shoreline connected, the generator running, or the inverter (Swing-Out TV) turned on (if equipped). –If Equipped The TV is connected to the home theater The TV and DVD player unit on models with...

  • Page 82: Dvd Player

    SECTION 8 – ENTERTAINMENT • Press FUNCTION button on DVD player or • The TV screen will display remote to set DVD player to TV CABLE. the DVD player logo when the correct input is selected. • Use TV Menu button to set TV audio output to “Variable Audio Output”.

  • Page 83: Flip-Down Screen Video Players

    SECTION 8 – ENTERTAINMENT 12-Volt Master Power FLIP-DOWN SCREEN VIDEO • The Video Players operate on PLAYERS 12-volt DC current. Turn on the (Rear Bunk models only) 12-volt master power (TV) switch shown, located on the –If Equipped backwall of the top bunk. The flip-down LCD screen DVD Video NOTE: To avoid drain on the 12-volt house Players are mounted overhead in each of the bunk...

  • Page 84: Electrical Inverter

    SECTION 8 – ENTERTAINMENT • Insert the CD label side down (facing you) into the slot on the side of the player. The player will automatically switch to proper mode to play audio or video CD. To Connect Game Systems or Other A/V Components •...

  • Page 85: Tv Signal Amplifier

    SECTION 8 – ENTERTAINMENT Operating the Digital Antenna Further Information See the antenna manufacturer’s user guide 1. Turn the Video Selection box ON. provided in your InfoCase for complete operating and maintenance information. TV SIGNAL AMPLIFIER The TV Signal Amplifier is built into the Video Selection Box antenna and can be turned on or off with a power (Located near entertainment center cabinet)

  • Page 86: Exterior Cable Tv - 12V Connection

    A second connection may be included inside a cabinet in the bedroom for the rear TV (if equipped). ® See your authorized Winnebago Industries dealer for proper installation and sealing of roof mounted components.

  • Page 87: Furniture And Softgoods

    SECTION 9 – FURNITURE AND SOFTGOODS SLEEPING FACILITIES WARNING Do not exceed 225 lbs. maximum weight capacity. Misuse of ladder could result in death or serious injury. See Operators Manual before using ladder. WARNING • Maximum Capacity: 225 lbs. Sleeping facilities are not intended for use while vehicle is in motion.

  • Page 88: Sofa/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS •Lower ladder to floor. •Make sure top of ladder is properly engaged onto retainer brackets and ladder is resting firmly on floor before using. Security Latch (Located on front of sofa) - Pull OUT to release •...

  • Page 89: Dinette/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS DINETTE/BED CONVERSION –If Equipped (Typical view – your coach may differ) Security Latch Handle accessible through front sofa opening Dinette to Bed 1. Release the catch on the table leg brace and fold the leg up against the bottom of the table. Security Latch Handle (Shown with sofa seat lifted) - Press DOWN to release...

  • Page 90: Dinette/Bed Conversion - Dream Dinette

    SECTION 9 – FURNITURE AND SOFTGOODS 3. Arrange dinette cushions to cover bed area. DINETTE/BED CONVERSION - DREAM DINETTE ™ –If Equipped (Typical view – your coach may differ) Dinette to Bed 1. Release the lock rod (located on the bottom of the table) by turning the lock rod clockwise.

  • Page 91: Dinette Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS 4. Arrange dinette cushions to cover bed area. 3. Place dinette table(s) securely onto the dinette pedestal leg(s). 5. Reverse steps to convert back into dinette. DINETTE CONVERSION –If Equipped (Typical view – your coach may be featured -Typical View with two dinette tables and pedestal legs, depending on model)
  • Page 92 SECTION 9 – FURNITURE AND SOFTGOODS Sofa to Bed 3. Rotate the lever lock (located on the bottom right-hand side of the sofa air bed) 1. Remove seat back cushions and set aside. “clockwise” to release the bottom section of the sofa air bed.
  • Page 93 SECTION 9 – FURNITURE AND SOFTGOODS 7. Press and Hold the ADJUST button on the hand control to adjust the firmness of your air mattress to the setting that best suits your NOTE: The air mattress is plugged into an AC needs.
  • Page 94 SECTION 9 – FURNITURE AND SOFTGOODS NOTE: If using Deflation Valve to deflate air mattress, pressing down on the mattress itself and forcing air out will speed up the deflation process. 4. Lift up the bottom section of the sofa bed and bring all the way up.

  • Page 95: Roller Shades (Manual) - Solar Day/Night

    People are drawn to the natural beauty of repair information. ® wood. At Winnebago Industries , our craftsmen work with the art found in each piece of wood to ROLLER SHADES (MANUAL) - create cabinets of superior quality, backed by the SOLAR DAY/NIGHT Winnebago Industries warranty.
  • Page 96 No matter which species you choose for your new Winnebago Industries motorhome cabinetry, please keep in mind that no two pieces of wood are exactly the same.

  • Page 97: Slideout Rooms

    SECTION 10 – SLIDEOUT ROOMS Rear slideout switches are typically located on SLIDEOUT ROOM KEYLOCK a wall in the rear of the coach in or near the slideout room. Location varies by model and A Master Slideout Room Keylock is located floorplan.
  • Page 98 SECTION 10 – SLIDEOUT ROOMS To Retract Slideout Room Before Retracting! WARNING • Be sure the coach is level and the Parking Brake is set. CRUSH HAZARD. Keep people and • Ensure exterior compartment doors are closed objects clear of the inside and outside of the slideout room when operating.

  • Page 99: Slideout Room - Extreme Weather Precaution

    SECTION 10 – SLIDEOUT ROOMS • Press the Slideout Room “RETRACT/IN” SLIDEOUT ROOM switch and hold until the room is fully TROUBLESHOOTING retracted, then release the switch. (LIPPERT) • To stop retracting the room during operation, release the button. -If Equipped •...

  • Page 100: Slideout Emergency Retraction

    SECTION 10 – SLIDEOUT ROOMS • (8) - HALL SIGNAL NOT PRESENT. • Motor • Mode Encoder is not providing a signal. This is • Status Direction Button LED’s usually a wiring problem. • (9) - HALL POWER SHORT TO GROUND.
  • Page 101 SECTION 10 – SLIDEOUT ROOMS There are two slideout motors equipped on the end wall of each slideout room. Pull back wipe seal to access motors. Push-In Procedure 1. Pull back wipe seal to access slideout motor. 2. Using a flat-head screwdriver, push bottom of slideout motor UP to disengage (approximately 1/2”...

  • Page 102: General Slideout Care

    SECTION 10 – SLIDEOUT ROOMS 5. See your dealer for service of the slideout motors before using again. Further Information Please refer to the slideout manufacturer’s user guide provided in your InfoCase for further instructions and troubleshooting information. GENERAL SLIDEOUT CARE •...

  • Page 103: Maintenance And Storage

    • Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.

  • Page 104: Exterior Automotive Paint Finish

    SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the • Do not scrape ice or snow from the painted amount of cargo you can carry and remain within surface. Brush off gently with a soft-bristled GVWR and GAWR limits.
  • Page 105 SECTION 11 – MAINTENANCE AND STORAGE Washing NOTE:Avoid aiming water flow from a hose or spray from high-pressure washing • Commercial vehicle wash facilities should be equipment into any appliance intake, as strictly avoided! They will scratch your RV! damage or difficulty in operating Truck-style wash centers have high- appliances may occur.

  • Page 106: Exterior Graphic Care

    SECTION 11 – MAINTENANCE AND STORAGE • Avoid paste waxes. They sometimes have • High pressure water spray may loosen or fillers and additives that give a very short term damage graphics. Keep spray nozzle at least result. Stay away from silicones in polishes 1 1/2 feet from the edge of the graphics.

  • Page 107: Exterior Lights

    EXTERIOR LIGHTS period of time. ® Most Winnebago Industries vehicles have polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical WARNING solvents and cleaners.

  • Page 108: Ceiling Fabric Care

    SECTION 11 – MAINTENANCE AND STORAGE Ultraleather Vinyl Fabrics Leather-Like Upholstery –If Equipped –If Equipped Vinyl should be cleaned with a soft, damp cloth, and a mild detergent only. Do not use Ultraleather synthetic leather fabric material solvents. Solvents may damage the surface of the has the luxurious look and feel of the finest vinyl.

  • Page 109: Cabinetry - Cleaning

    SECTION 11 – MAINTENANCE AND STORAGE The following cleaning chart is provided as a guideline for care and cleaning of ceiling fabrics used in your coach. CEILING FABRIC STAIN REMOVAL Type of Stain Cleaning Agent How to Remove Mustard Dry-Clean Solvent Scrub-Soak-Blot Dry Ketchup* High Strength Detergent...

  • Page 110: Tables And Countertops

    SECTION 11 – MAINTENANCE AND STORAGE NOTE: Many cabinetry and furniture items the stain. Rinse thoroughly with a sodium throughout this motorhome are bicarbonate and water solution, then follow up by constructed either partially or rinsing with water. Clean carefully. completely of real hardwoods.

  • Page 111: Galley Sink

    SECTION 11 – MAINTENANCE AND STORAGE Marks or Discoloration GALLEY SINK White automotive rubbing compound may be used to remove stubborn marks or discoloration. Care and Cleaning Instructions Use of these products will not damage the solid The galley sink has been designed and surface.

  • Page 112: Bathroom

    SECTION 11 – MAINTENANCE AND STORAGE Pet stains: • Use doormats (that do not contain bitumen) to keep out most of the dirt and dust. • Treat with lukewarm water. If stain remains visible, clean with a soft nylon pad and non- •...

  • Page 113: Vehicle Storage - Removal

    SECTION 11 – MAINTENANCE AND STORAGE Clean and Prep Coach for Storage 10. Close all windows and roof vents. Protect all appliance vent openings from contamination 1. Turn off the propane gas tank. by animals or insects (e.g. bird nest, wasp 2.

  • Page 114: Chassis Service And Maintenance

    SECTION 11 – MAINTENANCE AND STORAGE 10. Check the toilet for proper operation. 11. Add water to the holding tank using the toilet flush pedal and galley sink faucet. Check to be sure dump valves seal tightly. 12. Check around all appliances for obstructions and ensure that all vent openings are clear.

  • Page 115: Coach Maintenance Chart

    SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System ...
  • Page 116 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: ...
  • Page 117 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants ...

  • Page 119: Miscellaneous

    SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motorhome’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motorhome.
  • Page 120 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motorhome is to weigh each “corner”...

  • Page 121: Car Or Trailer Towing

    SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.

  • Page 122: Trailer Wiring Connector

    SECTION 12 – MISCELLANEOUS Before descending a steep or long grade when TRAILER WIRING towing a trailer, reduce speed and shift into a CONNECTOR lower gear to control vehicle speed. Avoid prolonged or frequent application of brakes, Your coach is pre-wired for trailer or car which could cause overheating and brake failure.

  • Page 123: Power Awning

    350 The tow vehicle brakes may be rated for lbs. All Winnebago Industries models operation at GVWR, not GCWR. equipped with a Class IV hitch have a...

  • Page 124: Storage Compartment Doors

    SECTION 12 – MISCELLANEOUS Further Information NOTE: Actual features and locations may vary depending on model, available For complete operating instructions, features, equipment, and storage compartment safety precautions, and maintenance care, refer to configuration. the awning manufacturer’s information provided in your InfoCase. ROOF LADDER STORAGE COMPARTMENT –If Equipped...

  • Page 125: Windows

    SECTION 12 – MISCELLANEOUS Horizontal Slider Windows • Do not overload. Ladder is intended for one person. Swing the latch handle straight out or up • Make sure you are physically capable to (depending on the style of window). Grasp the safely use the ladder.

  • Page 126: Humidity And Condensation

    SECTION 12 – MISCELLANEOUS Further Information Dome Crank Fan Speed Fuse See the power ventilator manufacturer’s Knob Selector operating instructions supplied in your InfoCase for further instructions, care, and cleaning information. EFFECTS OF PROLONGED OCCUPANCY Your motorhome was designed primarily for recreational use and short-term occupancy.
  • Page 127 INDEX About this Manual ........1-1 Engine Cooling System ....... 3-9 Air Conditioner Filter ........ 4-10 Engine Overheat ........2-10 Air Conditioner/Heater – Automotive Exterior Automotive Paint Finish ....11-2 (Dash) ............3-5 Exterior Cable TV - 12V Connection ..8-8 Air Springs –...
  • Page 128 Index Power Sofas and Beds ........2-7 Storage Compartment Cover/Folding Table 12-6 Pre-Delivery Inspection ....... 1-2 Storage Compartment Doors ..... 12-6 Pressure-Temperature Relief Valve ..... 4-7 Suspension Alignment and Tire Balance ..3-9 Propane Gas Furnace ........4-8 Swing-Out TV Mount (Front Bunk) .... 8-2 Propane Gas Furnace ........

This manual is also suitable for:

Chalet 26qrChalet 31crChalet 31jrChalet 31rr

Table of Contents