Table of Contents
Advertisement
MAINTENANCE AND LUBRICATION
Recoil Housing
Water will enter the recoil housing if
the starter handle is disengaged from
the rope or if the handle is not
securely seated when under water.
Drain the recoil housing any time the
vehicle has been operated in very wet
conditions and also before storage.
The drain screw (1) is located at the
bottom of the recoil housing, above
the front propshaft. Remove the
screw with a 10 mm wrench. Reinstall the screw after the housing has
been drained.
NOTE: Do not open the crankcase drain (2) unless the engine has
ingested water. On 4-cycle engines, some engine oil will be lost if
crankcase drain is opened.
Battery
Keep the battery terminals and connections free of corrosion. If
cleaning is necessary, remove the corrosion with a stiff wire brush.
Wash with a solution of one tablespoon baking soda and one cup water.
Rinse well with tap water and dry off with clean rags. Coat the
terminals with dielectric grease or petroleum jelly.
Be careful not to allow cleaning solution or tap water into the battery.
Battery electrolyte is poisonous. It contains sulfuric acid. Serious
burns can result from contact with skin, eyes or clothing.
Antidote:
External: Flush with water.
Internal: Drink large quantities of water or milk. Follow with milk
of magnesia, beaten egg, or vegetable oil. Call physician
immediately.
Eyes: Flush with water for 15 minutes and get prompt medical
attention.
Batteries produce explosive gases. Keep sparks, flame,
cigarettes, etc. away. Ventilate when charging or using in an
enclosed space. Always shield eyes when working near batteries.
KEEP OUT OF REACH OF CHILDREN.
WARNING
2
1
97
Hide quick links:
Advertisement
Table of Contents
