The interlock mechanism mentioned above becomes invalid in this mode. u163 2. When the cover is open, close viewing through the objective lens with the naked eye will cause exposure to the laser beam. ∗ : See page 51. DV-565A-S http://www.xiaoyu163.com...
Page 3
Dolby Laboratories. • “DTS” and “DTS Digital Out” are registered trademarks of Digital Theater Systems, Inc. • TruSurround and the symbol are trademarks of SRS Labs, Inc. TruSurround tech- nology is incorporated under license from SRS Labs, Inc. u163 DV-565A-S http://www.xiaoyu163.com...
Warranty card ......1 u163 • The specifications and design of this product are subject to change without notice, due to improvement. DV-565A-S http://www.xiaoyu163.com...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING L 13942296513 u163 DV-565A-S http://www.xiaoyu163.com...
Page 7
VRD1184 (Spanish / Dutch) NSP 9 Warranty Card ARY7065 Polyethylene Bag VHL1051 (2) CONTRAST TABLE DV-565A-S/WYXU and DV-565A-K/WYXU are constructed the same except for the following : DV-565A-S/ DV-565A-K/ Mark No. Symbol and Description WYXU WYXU 14 Packing Case VHG2361...
2.2 EXTERIOR SECTION 3 7 63 1515 0 Refer to "2.4 LOADING MECHA. ASSY". L 13942296513 u163 Refer to "2.3 FRONT PANEL SECTION". DV-565A-S http://www.xiaoyu163.com...
Page 9
See Contrast table (2) Horogram Sheet VEC2359 NSP 15 Base Chassis VNA2614 Caution Label VRW1872 (2) CONTRAST TABLE DV-565A-S/WYXU and DV-565A-K/WYXU are constructed the same except for the following : DV-565A-S/ DV-565A-K/ Mark No. Symbol and Description WYXU WYXU 14 Rear Panel VNA2580...
2.3 FRONT PANEL SECTION 3 7 63 1515 0 L 13942296513 u163 DV-565A-S http://www.xiaoyu163.com...
Page 11
Hologram Label ARW7239 FP Angle VNE2300 Front Panel Assy See Contrast table (2) (2) CONTRAST TABLE DV-565A-S/WYXU and DV-565A-K/WYXU are constructed the same except for the following : DV-565A-S/ DV-565A-K/ Mark No. Symbol and Description WYXU WYXU 10 Front Panel Assy...
Z39-019 Flexible Cable (24P) VDA1945 Tray VNL1920 Connector Assy 2P VKP2253 Floating Rubber VEB1351 Belt VEB1330 Stabilizer VNE2253 Loading Base VNL1917 u163 Float Base DVD VNL1918 Drive Cam VNL1919 Gear Pulley VNL1921 Loading Gear VNL1922 Drive Gear VNL1923 DV-565A-S http://www.xiaoyu163.com...
Page 13
Daifree No. 23 No. 23 GEM1036 GEM1036 Tray Tray Concave of unevenness Concave of unevenness Inner side of a ditch Daifree GEM1036 Top View Bottom View u163 Side of the rib Concave of unevenness Daifree Daifree GEM1036 GEM1036 DV-565A-S http://www.xiaoyu163.com...
SUPPLY FL DC+ FL DC+ Microcomputer UNIT FL DC- FL DC- V+3E EV+3.3V V+3E LIVE SW+1.8V FL101 V+1R8 CN105 CN104 AC IN FL Tube EV+6V(A) (21P) (21P) V+1R8_BED V-28 EV+6V(B) V+1R8_D NEUTRAL V+12 SW+12V V+1R8_FEA FLKY ASSY V+1R8_FED DV-565A-S http://www.xiaoyu163.com...
Page 17
RY904 IC902 MM1507XN V/Y OUT V+5V V IN V+5V V+12V RY901 V+12V R OUT u163 RY905 R IN CN901 L OUT (19P) L IN B IN G IN R/C IN V OUT SCRB ASSY JA902 V IN (21P) DV-565A-S http://www.xiaoyu163.com...
3.2 LOAB ASSY and OVERALL WIRING DIAGRAM 3 7 63 1515 0 SCRB ASSY (VWV1939) Note : When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". L 13942296513 JCKB ASSY (VWV1944) u163 DV-565A-S http://www.xiaoyu163.com...
Page 19
: STEPPING SERVO LOOP LINE FLKY ASSY PWSB ASSY (VWG2428) (VWG2429) PICKUP ASSY-S (OXX8005) L 13942296513 DVDM ASSY SPINDLE STEPPING MOTOR (VWS1563) MOTOR : VXM1101 : VXM1099 LOAB ASSY LOADING MOTOR ASSY (VWG2426) : VXX2872 POWER SUPPLY UNIT (VWR1366) u163 DV-565A-S http://www.xiaoyu163.com...
Page 23
: S-VIDEO OUT Y/Y SIGNAL ROUTE S-Y/Y : R/Cr SIGNAL ROUTE R/Cr : G/Y SIGNAL ROUTE S-C/C : B/Cb SIGNAL ROUTE B/Cb : AUDIO DATA SIGNAL ROUTE : AUDIO(DIGITAL) SIGNAL ROUTE S-Y/Y L 13942296513 B/Cb S-C/C S-Y/Y B/Cb R/Cr R/Cr u163 DV-565A-S http://www.xiaoyu163.com...
: B/Cb SIGNAL ROUTE B/Cb : AUDIO(DIGITAL) SIGNAL ROUTE : AUDIO SIGNAL ROUTE S-C/C S-Y/Y B/Cb R/Cr : The power supply is shown with the marked box. L 13942296513 S-C/C S-C/C S-Y/Y S-Y/Y B/Cb B/Cb R/Cr R/Cr u163 DV-565A-S http://www.xiaoyu163.com...
: V SIGNAL ROUTE : C SIGNAL ROUTE : Y SIGNAL ROUTE : R SIGNAL ROUTE : G SIGNAL ROUTE Buffer : B SIGNAL ROUTE : AUDIO SIGNAL ROUTE Buffer L 13942296513 Video Amp. with SW Video Amp. with SW u163 DV-565A-S http://www.xiaoyu163.com...
Page 33
3 7 63 1515 0 : The power supply is shown with the marked box. RY901-RY905: Relay SW L 13942296513 68 (F) 68 (F) 68 (F) u163 68 (F) DV-565A-S http://www.xiaoyu163.com...
Foot of R732 (IC701 - pin 31) [Component Video out -Pb] [S Video out -C] V: 2V/div. H: 10µsec/div. V: 1V/div. H: 10µsec/div. Foot of R737 (IC701 - pin 21) [Component Video out -Pr] V: 2V/div. H: 10µsec/div. DV-565A-S http://www.xiaoyu163.com...
SIDE A FLKY ASSY (VNP1901-B) CN102 D102 D101 PYKC F4X S102 FL DIM D104 S104 >> S103 FL101 << PWSB ASSY (VNP1901-B) L 13942296513 SIDE B PWSB ASSY (VNP1901-B) C154 R138 PWSB VWG2424- CN103 VWG2425- FLKY ASSY (VNP1901-B) u163 DV-565A-S http://www.xiaoyu163.com...
Page 43
S108 EJECT IR101 /STOP VNP1901- /PLAY S110 S117 S118 S119 DC FC PLAY/>> PAUSE/<< DOWN RETURN S107 S106 C101 HOME MENU/PAUSE STOP/EJECT CN101 CN104 S105 CN104 CN105 L 13942296513 SIDE B CN104 C N 1 0 1 u163 DV-565A-S http://www.xiaoyu163.com...
Electrical adjustments are not required. L 13942296513 6.2 JIGS AND MEASURING INSTRUMENTS Test mode remote control Screwdriver (large) Screwdriver (medium) TV monitor unit (GGF1381) Screw tight (GYL1001) u163 DVD test disc Precise screwdriver Soldering iron (GGV1025) DV-565A-S http://www.xiaoyu163.com...
Electric point ∗ After adjustment, screw locks Mechanical Ÿ Exchange the Spindle Motor point with the Screw tight. Electric point Exchange PCB Assy Mechanical Exchange PC Board L 13942296513 point LOAB and DVDM ASSYS Electric point u163 DV-565A-S http://www.xiaoyu163.com...
< When playback with the target address of disc (DVD)> For example, when playback with # 30000 During PLAY CHP/TIM Press keys in order 030000 TEST MODE: OFF POWER u163 GGF1381 Test mode remote control unit DV-565A-S http://www.xiaoyu163.com...
(Refer to "6.1 ADJUSTMENT ITEMS AND LOCATION".) Spacer for Height adjustment Note: Turn a flat side into bottom Before removing the flexible cable for the pickup, soldering of the pickup circuit is necessary. For details, see "7.1.10 DISASSEMBLY". L 13942296513 u163 DV-565A-S http://www.xiaoyu163.com...
Page 53
J : Min If error rate is OK, Disc playback normally. locks a root of • The measurement of block error rate tangential and radial adjustment screws with the Screw tight. Screw tight: GYL1001 Test mode end u163 DV-565A-S http://www.xiaoyu163.com...
Perform only trace, video and audio outputs are nothing. = Screen display ON/OFF 1. Turn off the display by pressing the [AUDIO] (A8-1E) key of the remote control unit. 2. Turn on the display by pressing the [DISPLAY] (A8-43) key of the remote control unit. u163 DV-565A-S http://www.xiaoyu163.com...
Page 55
• After the search, perform only trace and video and audio outputs are nothing. 4. Release the Search address input • Clear the address by pressing the [CLEAR] (A8-45) key. Release the address input mode when pressing the [CLEAR] key once again. L 13942296513 u163 DV-565A-S http://www.xiaoyu163.com...
Kinds of version / firmware of the FE. Scart terminal output [SK – ∗ ∗] RAM or ROM (Display only the WY model which can do the output setting of scart terminal.) VIDEO : [00] u163 S-VIDEO : [01] : [02] DV-565A-S http://www.xiaoyu163.com...
After you press the AUDIO key while holding the ESC key pressed and then input the region number, if the number is different from that set in the unit, an error message is displayed, and the tray opens. DV-565A-S http://www.xiaoyu163.com...
(version of ST core software) softwareVersion . softwareRevision / buildNumber 0 F.E VERSION Version of FRONT END (version of mechanism controller CHIP software) MainVersion / Kinds of firmware RAM or ROM - Remote control code = Key code of Main unit u163 DV-565A-S http://www.xiaoyu163.com...
PLL lost timeout 0x93 DECODER ERROR 0xa∗ DECODER TIMEOUT 0xb∗ Note : 0 x & & ID lost error 0xa3 ID lost timeout 0xb3 FAIL SAFE 0xe∗ u163 code Unexpected error 0xe1 (Only this part is displayed to a display) DV-565A-S http://www.xiaoyu163.com...
1. Stepping motor of the stepping in the test mode? 2. Inside switch Stepping move timeout 0 x 54 Did timeout at stepping movement Do indicate "S-04" at the most inner 3. Driver periphery of the stepping? u163 DV-565A-S http://www.xiaoyu163.com...
Page 62
Are not there a dirt or a scratch in 1. Pickup ID lost timeout 0xb3 Did timeout at ID backup the Disc? 2. Front End IC FAILSAFE (0 x e∗) 1. Hardware broken Unexpected error 0 x e1 Unexpected error L 13942296513 2. Software bug u163 DV-565A-S http://www.xiaoyu163.com...
(The SEARCH key is not accepted after all 9 digits have been entered.) Input ID Number ! [Player's ID Number Setting] ID Number ? > 0 0 0 0 0 0 0 0 1 OK ? <PLAY> Compare Mode <SEARCH> Enter Input ID Number ! u163 DV-565A-S http://www.xiaoyu163.com...
Page 64
[Player's ID Number Setting] ID Number ? [ 0 0 0 0 0 0 0 0 1 ] Compare > 0 0 0 0 0 0 0 0 1 OK? <PLAY> Enter <STOP> Memory Clear Input ID Number ! u163 DV-565A-S http://www.xiaoyu163.com...
Page 65
If no ID data are set after the ID number is changed, the message "NO ID DATA" flashes on the screen and FL display for a few seconds after the power is turned on or during Stop mode. u163 DV-565A-S http://www.xiaoyu163.com...
Check the video signal path between Back End IC (DVDM Assy IC601) displayed on the monitor Video circuit after Back End IC and video-out terminal (see the block diagram) (The FL display lights. The (IC601) mechanism does not work.) u163 DV-565A-S http://www.xiaoyu163.com...
Page 67
Check the waveform (BCK, LRCK, MCLK, DATA). Back End IC (IC601) (Picture is normal) Is signal output from signal (IC201-pin 17, pin 18, pin 13, pin 12) on the JCKB Assy JCKB Assy ? Audio Dac IC (IC201) u163 DV-565A-S http://www.xiaoyu163.com...
If the tray pops out a little, fully pull it out by a hand. Screwdriver (small) Projection Slit Drive Gear Loading Mecha.Assy Tray open u163 Screwdriver (small) DV-565A-S http://www.xiaoyu163.com...
Page 70
Disconnect the flexible cable. Remove the PCB holder. Cutting Pliers Remove the SCRB Assy. ×2 L 13942296513 ×2 JCKB Assy Rear Panel Remove the rear panel by removing the nine screws. ×5 Remove the five screws. u163 JCKB Assy DV-565A-S http://www.xiaoyu163.com...
Page 71
DVDM Assy Jig Cable Exchange the two flexible cables for the two jig (GGD1330) cables. Remove the three screws. L 13942296513 DVDM Assy DVDM Assy Remove the DVDM Assy and stand it against the other parts. Diagnosis u163 DV-565A-S http://www.xiaoyu163.com...
Page 72
Tray Drive Cam Note when reinserting the Tray When reinserting the Tray, first align the triangle printed on the Loading Base and the pin of the Drive Cam, then insert the Tray. Front Side Loading Base Triangle u163 DV-565A-S http://www.xiaoyu163.com...
Page 73
Front Side placement. Flexible cable Flexible cable for the pickup for the stepping motor L 13942296513 Bottom View Remove the four hooks. Traverse Mecha. Assy-S × 2 Remove the Traverse Mecha. Assy-S. × 2 u163 DV-565A-S http://www.xiaoyu163.com...
Page 74
Flexible cable for the pickup Bottom View L 13942296513 Adjustment screw Adjustment screw Remove the two adjustment screws and two adjustment springs. (Skew screw) (Skew screw) Remove the Pickup Assy-S. Pickup Assy-S Adjustment spring (Skew spring) Adjustment spring (Skew spring) u163 DV-565A-S http://www.xiaoyu163.com...
Page 75
Joint 03 Silicone Adhesive GEM1037 Arrangement of the flexible cable Arrangement of the flexible cable for the spindle motor for the stepping motor L 13942296513 : Conductive surface : Conductive surface Hook Hook u163 Bottom View Bottom View DV-565A-S http://www.xiaoyu163.com...
Page 76
Hook Fold the flexible cable as indicated in the photo. Fold the flexible cable along the hook. Hook the part folded in Step 1 to the hook. Reference Hook Pass the cable below the hook line Hook u163 DV-565A-S http://www.xiaoyu163.com...
Page 77
• The information shown in the list is basic information and may not correspond exactly to that shown in the schematic diagrams. • List of IC STM6316ATXXA, STI5588CVB, SAA7893HL/C2, M63108FP, PE5374A 7 STM6316ATXXA (DVDM ASSY : IC301) • FRONT END IC ¶ Block Diagram L 13942296513 u163 DV-565A-S http://www.xiaoyu163.com...
Page 78
3 7 63 1515 0 ¶ Pin Function t i c t i c t s i L 13942296513 t s i t s i t s i t s i t i s t i s u163 DV-565A-S http://www.xiaoyu163.com...
Page 79
- t l l i c y t i - t l l i c y t i - t l l i c y t i d l l u163 DV-565A-S http://www.xiaoyu163.com...
Page 80
3 7 63 1515 0 l l i l l i t i c l i b y t i L 13942296513 u163 DV-565A-S http://www.xiaoyu163.com...
Page 90
3 7 63 1515 0 ¶ Pin Function L 13942296513 u163 DV-565A-S http://www.xiaoyu163.com...
Page 91
Destination (of player) Select (Set with a combinaition of this 3 ports) MS1_0 H" : No System Reset mode , "L" : General mode H" : OEM Model , "L" : Pioneer Model MIC IN Detection of Microphone "H" : Microphone connected CHECKER H"...
“JPEG file compatibility” below. DVD-R/RW and CD-R/RW discs (Audio CDs and Video CD/Super VCDs) recorded using a DVD recorder, CD recorder or personal computer may not be playable on this unit. u163 This may be caused by a number of possibili- DV-565A-S http://www.xiaoyu163.com...
Page 94
• This player only displays files that are recognized. named with the file extension .jpg or .JPG. • This player only plays tracks that are named with the file extension .mp3 or .MP3. u163 DV-565A-S http://www.xiaoyu163.com...
3 7 63 1515 0 Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Cleaning tools Pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 L 13942296513 u163 DV-565A-S http://www.xiaoyu163.com...
Press to pause playback. Press again to restart. Press to start or resume playback. This mark indicates compatibility with DVD-RW discs recorded on a DVD recorder in Video Recording mode. OPEN/CLOSE Press to open or close the disc tray. u163 DV-565A-S http://www.xiaoyu163.com...
Page 97
TV, monitor or AV receiver that has For passing remote control signals to other component video inputs. Pioneer components. Connect using a commercially available three-way component video cable. Be careful to match the colors of the jacks and cables for correct connection.
Page 98
Indicates that the character display is Lights when a DTS soundtrack is playing. showing a DVD chapter number. 16 2 D 5.1CH Lights when a Dolby Digital soundtrack is Lights when analog 5.1 channel output is playing. selected. u163 DV-565A-S http://www.xiaoyu163.com...
Page 99
Press to start or resume playback. L 13942296513 Press to jump to the beginning of the current chapter or track, then to previous chapters/ tracks. Press to pause playback; press again to restart. u163 DV-565A-S http://www.xiaoyu163.com...
Page 100
CD/Super VCD, MP3 or JPEG disc is loaded. 19 RETURN L 13942296513 Press to return to a previous menu screen. Use for forward slow motion playback, frame advance and forward scanning. Press to jump to the next chapter or track. u163 DV-565A-S http://www.xiaoyu163.com...