Driving Safety ................................................................................................................................... 2-1

Fuel and Propane Gas ....................................................................................................................... 2-1

LP Gas Leaks .................................................................................................................................... 2-2

Propane Gas Leak Detector .............................................................................................................. 2-2

Carbon Monoxide Warning .............................................................................................................. 2-3

Carbon Monoxide Alarm .................................................................................................................. 2-3

Smoke Alarm .................................................................................................................................... 2-4

Fire Extinguisher ............................................................................................................................... 2-4

Electrical ........................................................................................................................................... 2-5

Loading ............................................................................................................................................. 2-5

Maintenance ...................................................................................................................................... 2-5

Emergency Exits ............................................................................................................................... 2-5

Power Sofas and Beds ....................................................................................................................... 2-6

Slideout Rooms ................................................................................................................................. 2-6

Formaldehyde Information ............................................................................................................... 2-7

Mold, Moisture, and Your Motor Home ........................................................................................... 2-7

Roof and Ladders .............................................................................................................................. 2-8

Roadside Emergency ........................................................................................................................ 2-8

Jump Starting .................................................................................................................................... 2-9

Engine Overheat ............................................................................................................................. 2-10

3 - DRIVING YOUR MOTOR HOME

Seats - Driver/Co-Pilot ..................................................................................................................... 3-1

Seat Belts .......................................................................................................................................... 3-3

Child Restraints ................................................................................................................................. 3-4

KeyOne™ Lock System ................................................................................................................... 3-5

Rev. 1223131217

Part No. 161500-12-024

Table of Contents

Need help?

Do you have a question about the Tour 2012 and is the answer not in the manual?

Questions and answers

Summary of Contents for Winnebago Tour 2012

Page 1: Table Of Contents
Engine Overheat ..........................2-10 3 – DRIVING YOUR MOTOR HOME Seats – Driver/Co-Pilot ........................3-1 Seat Belts ............................3-3 Child Restraints ..........................3-4 KeyOne™ Lock System ........................3-5 Rev. 1223131217 Part No. 161500-12-024 Copyright 2011 Winnebago Industries, Inc. All rights reserved.
Page 2 Table Of Contents Power Door Locks ..........................3-5 Mirrors – Power Electric ........................3-6 Front Drop-Down Solar/Night Shade (12-Volt) ................3-7 Radio In-Dash/Rearview Monitor System ..................3-8 Infotainment Center/GPS ........................ 3-10 CB Radio Power Wiring ......................... 3-13 Parking Brake ..........................3-13 Engine Brake System ........................
Page 3 Table Of Contents Microwave Oven/Range Hood ......................4-6 OnePlace® Systems Monitor Panel ....................4-6 Solar Charger Panel .......................... 4-7 Power Control System (PCS) ......................4-8 Electronic Thermostat ........................4-8 Hydronic Heating System ....................... 4-11 Air Conditioner Filters ........................4-14 Washer/Dryer - Stackable ....................... 4-15 Washer/Dryer - Prep Package ......................
Page 4 Table Of Contents Exterior Shower/Wash Station ......................7-9 Toilet ..............................7-9 Toilet - Electric Flush ........................7-9 Drainage System (P-Traps) ......................7-10 Waste Water System ........................7-10 Utility Light ............................ 7-13 WaterLine and Tank Drain Valves ....................7-13 Winterizing Procedure ........................7-14 Winterizing Optional Appliances ....................
Page 5 Table Of Contents Slideout Emergency Retraction - Bedroom ..................10-8 General Slideout Care ........................10-9 Leveling System ..........................10-9 Checking Hydraulic Oil Level ...................... 10-11 11 – MAINTENANCE AND STORAGE Sealants – Inspection and General Information ................11-1 Roof ..............................11-1 Undercarriage ..........................
Page 6 Table Of Contents Compartment Lights Switch ......................12-14 Power Awning ..........................12-14 Air Hose Connector ........................12-16 Effects of Prolonged Occupancy ....................12-17...
Page 7: Introduction
The instructions included in this manual are intended as a guide, and in no way extend the responsibilities of Winnebago Industries beyond the standard written warranty as presented in this manual. The descriptions, illustrations, and...
Page 8: 2012 New Vehicle Limited Warranty
Winnebago Industries, Inc. Except as noted in the paragraph entitled, “Factory Repair,” to (“Winnebago”) and provides coverage so long as the motor home is obtain warranty repairs, you must, at your own cost, present your used exclusively for recreational purposes in the U.S.A.
Page 9 Winnebago does not own or control, and shall not be warranty disputes for recreational vehicles. This program reviews...
Page 10: Safety Messages Used In This Manual
If you need warranty repairs while traveling, you may take your vehicle to any authorized ® Winnebago Industries dealership and request NOTICE their assistance. See the Service Dealer Directory in your NOTICE is used to address practices not InfoCase.
Page 11: Occupant And Cargo Carrying Capacity Label
SECTION 1 – INTRODUCTION National Highway Traffic Safety Administration (NHTSA) in addition to notifying Winnebago Industries, Inc. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
Page 12: Vehicle Certification Label
These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.
Page 13: Specifications And Capacities
SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITIES 42AD 42JD 42QD ® ® ® Freightliner Freightliner Freightliner Winnebago Tour Maxum Tag Maxum Tag Maxum Tag 44,600 lb. 44,600 lb. 44,600 lb. Chassis Chassis Chassis Feature Number Length 42' 10.3" 42' 10.3"...
Page 14: Owner And Vehicle Information
Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...
Page 15: Safety And Precautions
SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...
Page 16: Lp Gas Leaks
SECTION 2 – SAFETY AND PRECAUTIONS • All pilot lights must be extinguished and asphyxiation is greater when the appliance is appliances turned off while refilling the fuel used for long periods of time. Failure to comply tank or LP gas tank. could result in death or serious injury.
Page 17: Carbon Monoxide Warning
SECTION 2 – SAFETY AND PRECAUTIONS The best protection against carbon monoxide entry into the vehicle body is a properly WARNING maintained engine exhaust and ventilation system. It is recommended that the exhaust system and body be inspected by a qualified EXPLOSION HAZARD: DO NOT use an motor home service center: open flame to test for gas leaks.
Page 18: Smoke Alarm
InfoCase for further instructions. that is also listed for RV application. We Replacement recommend obtaining a replacement from your ® Winnebago Industries dealer. When replacing this alarm, we recommend replacing only with the same model, or with one Further Information that is also listed for RV application.
Page 19: Electrical
• Do not remove the radiator cap while engine your coach. We recommend obtaining a and radiator are still hot. Always check replacement only from your Winnebago coolant level visually at the see-through ® Industries dealer or a reliable RV parts supplier.
Page 20: Power Sofas And Beds
SECTION 2 – SAFETY AND PRECAUTIONS POWER SOFAS AND BEDS WARNING Keep people away from operating mechanism and pinch hazard areas during use. Failure to do so could cause injury. Escape Window SLIDEOUT ROOMS (Lift latch handles upward to open) Using Slider Windows As WARNING Emergency Exits...
Page 21: Formaldehyde Information
SECTION 2 – SAFETY AND PRECAUTIONS Mold is a plant and requires its own special FORMALDEHYDE environment to grow. That environment includes INFORMATION organic materials, nutrients, moisture, and proper temperature. Some of the materials used in this recreational vehicle emit formaldehyde. Eye, nose, and throat How Can I Avoid Mold? irritation, headache, nausea, and a variety of To reduce the ability for mold to grow, you...
Page 22: Roof And Ladders
® while in use. Never use the ladder when it is Winnebago Industries raining, snowing, or icy. The rungs can If Winnebago Industries determines that mold become slippery. Do not step onto the rungs if ® ® is present in the Winnebago...
Page 23: Jump Starting
We recommend that you ask for an underlift (wheel lift or frame lift) type towing assembly for safe towing. ® Winnebago Industries does not assume responsibility for damage incurred while towing this vehicle.
Page 24: Engine Overheat
SECTION 2 – SAFETY AND PRECAUTIONS ENGINE OVERHEAT If you see or hear steam escaping from the engine compartment or have any other reason to suspect an extreme engine overheating condition, pull the vehicle over to the roadside as soon as it is safe to do so, stop the engine, and get all passengers out of the vehicle.
Page 25: Driving Your Motor Home
The information in this section refers only to Lumbar Lift to Swivel features installed or adapted to the dash and Tension driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach.
Page 26: Heated Seats
SECTION 3 – DRIVING YOUR MOTOR HOME Chair Heat Control Switch (Located on driver and passenger side trim panels) * Passenger side shown Heated Seats -Typical View The driver and co-pilot seats are heated for • These switches illuminate when the House/Coach Battery your personal comfort.
Page 27: Seat Belts
SECTION 3 – DRIVING YOUR MOTOR HOME +Lounger 1- Insert tab into buckle (Co-Pilot Seat) slot until it “clicks” and is -If Equipped locked Your coach may be equipped with a +Lounger, which is featured with heated seats, an extendable footrest (see previous operation 3- Press to instructions), and a convenient built-in release...
Page 28: Child Restraints
SECTION 3 – DRIVING YOUR MOTOR HOME Unfastening may have a greater chance of being injured in an accident if they are seated in a child restraint Press the release button in the buckle. Hold system which is not properly secured. onto the tongue when you release it from the buckle to keep it from retracting too rapidly.
Page 29: Keyone Lock System
The key number for your coach is registered in our factory database, so if you ever lose your ® keys, any Winnebago Industries dealership can order a new key for you. Power Door Locks - Entry Door...
Page 30: Mirrors - Power Electric
SECTION 3 – DRIVING YOUR MOTOR HOME To access the keyless entry control box, remove four screws and open the panel carefully to avoid damage or disconnection of wiring looms. Power Door Locks - Entry Door (Located on dash) -Typical View Keyless Entry Control Box Keyless Remote Entry System with (Located in 12-volt electrical compartment)
Page 31: Front Drop-Down Solar/Night Shade (12-Volt)
SECTION 3 – DRIVING YOUR MOTOR HOME Mirror Heater Switch (Located on driver side trim panel) Mirror Adjustment Control -Typical View The mirror control is mounted along sidewall below driver side window. The ignition key must Turn Signal Indicator Lights be on to adjust the mirrors.
Page 32: Radio In-Dash/Rearview Monitor System
• EJECT - Press to EJECT Should the Automatic Safety Retraction feature deploy, go to your nearest Winnebago ® Industries dealer for service before operating the shade again.
Page 33 SECTION 3 – DRIVING YOUR MOTOR HOME • DAY/NIGHT - Press to phone number to call and procedure to switch between stored access the Sirius Tuner ID Number DAY/NIGHT user settings. (ESN). Press and Hold to access iPod Cable AUTO DAY/NIGHT adjust. Your coach may be equipped with a cable to •...
Page 34: Infotainment Center/Gps
SECTION 3 – DRIVING YOUR MOTOR HOME Radio Power Switch The Radio Power switch lets you connect the dash radio to the coach batteries with the ignition switch turned off for listening while parked. This prevents accidental draining of the chassis battery with prolonged use of the radio.
Page 35 SECTION 3 – DRIVING YOUR MOTOR HOME The radio monitor automatically changes to camera mode when transmission is shifted into reverse. A microphone built into the rear camera lets you hear warning sounds or verbal directions from an assistant. Dash Radio/ GPS Remote Sideview Cameras The sideview cameras (built into the driver and...
Page 36: Radio Power Switch
SECTION 3 – DRIVING YOUR MOTOR HOME Steering Wheel Radio Remote Control An additional hand-held remote allows these same conveniences for the passenger. The hand- iPod Connection held radio remote is included in your InfoCase. (Located on dash between Radio Power Switch steering wheel and key ignition) - Open cover to access iPod connection The Radio Power switch lets you connect the...
Page 37: Cb Radio Power Wiring
SECTION 3 – DRIVING YOUR MOTOR HOME NOTE: It is normal to hear an occasional burst CB RADIO POWER WIRING of air pressure from the rear of the vehicle. This is an automatic moisture Your coach is pre-wired for CB radio power purging feature of the air brake system.
Page 38: Tag Axle Suspension System
SECTION 3 – DRIVING YOUR MOTOR HOME TAG AXLE SUSPENSION Engine Brake Operation SYSTEM • Low – Press for normal braking on level or shallow grades and in-town and city driving. ® Freightliner Chassis This shuts down three of the six cylinders when -If Equipped engaged and provides about 130-hp of braking power.
Page 39: Hazard Warning Flashers
SECTION 3 – DRIVING YOUR MOTOR HOME Auto Dump Position Further Information • This mode is activated automatically when in See the chassis manual in your InfoCase for reverse gear, when the Tag Axle switch is in instructions on activating, operating, and the MIDDLE position.
Page 40: Steering Column Adjustment
SECTION 3 – DRIVING YOUR MOTOR HOME WARNING Do not adjust the steering column or tilt wheel while the vehicle is in motion. Doing so may cause loss of vehicle control resulting in death or personal injury. Further Information BRAKE/ACCELERATOR See your chassis manual in your InfoCase for PEDALS - ADJUSTABLE further information on this switch.
Page 41: Smartwheel Steering Wheel Control System
SECTION 3 – DRIVING YOUR MOTOR HOME Headlight Courtesy Flash WARNING Do not adjust the brake/accelerator pedals while the vehicle is in motion. Doing so may cause loss of vehicle • Press and release to blink or flash the control resulting in death or personal headlights.
Page 42: Cruise Control Functions
SECTION 3 – DRIVING YOUR MOTOR HOME Cruise Control Functions Wiper Functions On/Off (Cruise System On/Off) There are four wiper control buttons: • Wiper On - HI/LO • Press to turn cruise control system on or off. • Wiper Off •...
Page 43: Battery Boost Switch
SECTION 3 – DRIVING YOUR MOTOR HOME How it works: CAUTION • During a light rain or mist, when your windshield needs a clearing wipe, press the button once and the wiper will swipe back and Do not operate engine at low idle for long forth once at Lo speed.
Page 44: Air Conditioner/Heater - Automotive (Dash)
SECTION 3 – DRIVING YOUR MOTOR HOME Further Information See the manufacturer’s user guide provided in your InfoCase for complete operating instructions. DEFROST FANS -If Equipped The two-speed auxiliary fans are intended to assist the automotive windshield defroster system in clearing fog and frost in cold weather or humid conditions.
Page 45: Fuel Selection - Diesel Engine
SECTION 3 – DRIVING YOUR MOTOR HOME FILLING THE FUEL TANK – DIESEL ENGINE Diesel fuel can foam up while being pumped into the tank. Sometimes this foam can cause the pump nozzle to shut off before the tank is actually full.
Page 46: Engine Block Heater - Diesel Engine
SECTION 3 – DRIVING YOUR MOTOR HOME ENGINE BLOCK HEATER – DIESEL ENGINE Your diesel engine is equipped with an engine coolant heater to assist starting in freezing temperatures. The power cord is located in the rear cargo compartment on the driver side of the coach.
Page 47: Engine Top Access Covers - Rear
SECTION 3 – DRIVING YOUR MOTOR HOME Take precautions to protect carpet and interior furnishings when removing Engine Access Covers. The undersides of the covers could contain deposits of oil and fuel or other engine fluids and substances that could damage fabrics and interior furnishings.
Page 48 SECTION 3 – DRIVING YOUR MOTOR HOME Aluminum Tube Step Cover Screw Locations (Shown with Metal Engine Covers removed) -Typical installation shown Steel Frame • If your bed is equipped with a front panel, there are two screws that need to be removed in order to take off the step cover (after front panel is removed).
Page 49: Engine Top Access Covers - Rear Bath Models
SECTION 3 – DRIVING YOUR MOTOR HOME ENGINE TOP ACCESS COVERS – REAR BATH MODELS (Typical View - Your coach may differ in appearance according to floorplan) Models 42JD and 42QD These covers are only removed if a complete view of the engine is needed for inspection, or for replacement or adjustment of upper engine parts.
Page 50 SECTION 3 – DRIVING YOUR MOTOR HOME • Remove bottom cabinet panel before Access Panels removing Engine Access Cover (Located below lavatory cabinet) * Model 42QD * Model 42JD only • Remove fasteners from Metal Engine Cover 4. Remove fasteners from Metal Engine Cover and set cover aside.
Page 51: Fuel/Water Separator - Diesel
SECTION 3 – DRIVING YOUR MOTOR HOME FUEL/WATER SEPARATOR – DIESEL ® Freightliner Chassis Diesel fuel often contains small quantities of water, which can damage the engine if not filtered out. The Fuel/Water Separator traps this water and prevents it from reaching the engine. The harmful water deposits must be drained from the separator canister during normal periodic service and maintenance to keep the fuel...
Page 52: Engine Cooling System
SECTION 3 – DRIVING YOUR MOTOR HOME Further Information Refer to the chassis manual provided in your InfoCase for complete information and precautions. ENGINE COOLING SYSTEM Do not remove the radiator cap while engine and radiator are still hot. Always check coolant level visually at the see-through coolant reservoir.
Page 53: Front Service Access
SECTION 3 – DRIVING YOUR MOTOR HOME 12-Volt Automotive Fuse Panel Fuse Diagram (inside of cover) Further Information 12-Volt Automotive Breaker Panel See your chassis manual in your InfoCase for further information about chassis supplied fuses and relays. FRONT SERVICE ACCESS (HOOD) The front hood panel can be opened for access to the air hose connector and service items such...
Page 54: Windshield Washers And Wipers
SECTION 3 – DRIVING YOUR MOTOR HOME NOTE: As a safety feature, the hood will only extend partially after disengaging the Release lever. Continue with Step 2 for full extension procedure. 2. Lift Security T-Pin straight UP while simultaneously pulling hood out to the fully extended position.
Page 55: Lights
SECTION 3 – DRIVING YOUR MOTOR HOME Alignment can be affected by worn steering/ suspension parts or by incidents which happen during driving, such as hitting a curb, pothole, or railroad track, etc. Improper alignment can cause tires to roll at an angle and wear unevenly. It may also cause the vehicle to “pull”...
Page 57: Appliances And Systems
SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motor home ON position. This will ensure that water are manufactured by reputable RV appliance does not discharge from the water makers and have been tested by independent dispenser when power is reconnected to laboratories to meet all applicable standards and the appliance.
Page 58: Refrigerator
SECTION 4 – APPLIANCES AND SYSTEMS It is recommended to replace the water filter where it creates cooling by evaporation. The when the indicator light changes to red, or earlier ammonia circulates back into the water solution if the flow of water to your water dispenser or ice and the cooling cycle continues.
Page 59: Ice Maker
SECTION 4 – APPLIANCES AND SYSTEMS Basic Operation temperature in the freezer compartment, then adjust warmer as necessary after cold food has • Press the ON/OFF button to start the been added. refrigerator. NOTE: The refrigerator will retain temperature • If the display code reads “No”, there is no more efficiently if food is already cold electricity or gas available to operate the...
Page 60: Refrigerator Service Access Compartment
SECTION 4 – APPLIANCES AND SYSTEMS Refrigerator Access Compartment Residential Refrigerator Access Compartment -Typical View REFRIGERATOR/FREEZER - PORTABLE -If Equipped REFRIGERATOR SERVICE Your coach may be equipped with a 12/24- ACCESS COMPARTMENT volt DC Portable Refrigerator/Freezer, which is mounted on a slide tray in a passenger side (Exterior) storage compartment.
Page 61: Range Top
SECTION 4 – APPLIANCES AND SYSTEMS Avoiding Asphyxiation The following warning label has been located in the cooking area to remind you to provide an adequate supply of fresh air for combustion. • To store refrigerator/freezer, push unit in fully until the lock mechanism engages.
Page 62: Microwave Oven/Range Hood
SECTION 4 – APPLIANCES AND SYSTEMS Further Information Water And Holding Tank Levels See the appliance manufacturer’s operation Press the Tank Level switch to show manual in your InfoCase for complete range approximate levels on the LCD screen. features, operating instructions, and safety precautions.
Page 63: Solar Charger Panel
SECTION 4 – APPLIANCES AND SYSTEMS Battery Charge Meter Press the Battery Level switch to check the level of charge (voltage) in the chassis and house batteries. Water Pump Switch NOTE: Some models may be equipped with a Water Pump switch in the water service center on the outside of the coach or Battery Level Switch within the bathroom area for your...
Page 64: Power Control System (Pcs)
SECTION 4 – APPLIANCES AND SYSTEMS Further Information not completely compensate for continuous low amperage draw from Refer to the manufacturer’s user guide components such as the propane gas leak provided in your InfoCase for important detector, the clock in the dash radio and information on how this system operates under the radio station memory circuitry, for several conditions, whether 20-amp, 30-amp, or...
Page 65: Heat Pump
SECTION 4 – APPLIANCES AND SYSTEMS 5. Adjust the temperature setpoint to personal preference if needed. See “Changing Temperature Setpoints.” Cooling (A/C) 1. Select Zone. 2. Slide the Thermostat switch to Cool position. 3. Press the “Mode” side of the Mode/Zone button and toggle to your desired setting: •...
Page 66 SECTION 4 – APPLIANCES AND SYSTEMS extract heat from the outside air on a cold day and NOTE: The temperature setpoint cannot be carry it to the inside of the coach to maintain a adjusted in the following situations: comfortable temperature. When the Thermostat switch is set to OFF, when the zone is turned off for The efficiency of a Heat Pump decreases as...
Page 67: Hydronic Heating System
Expansion Fill Tank safety overflow of the air conditioner(s). See ® your Winnebago Industries dealer for service Hydronic Heating System and proper cleaning of the drain lines. (Located in driver side compartment...
Page 68 SECTION 4 – APPLIANCES AND SYSTEMS Exterior Electronic Controller Expansion Fill Tank • Red and green lights indicate the • Check antifreeze/water heating solution status of your Hydronic Heating level monthly. When the system is at System. See manufacturer’s maximum operating temperature (i.e. operating manual for further immediately after the diesel burner cycles information.
Page 69 SECTION 4 – APPLIANCES AND SYSTEMS Engine Preheating/Motoraid NOTE: Please note that the diesel burner is the primary heat source for heating both the Also included in this system is a motoraid interior and the domestic hot water (such feature, which uses heat generated by the RV as when cool ambient temperatures exist engine during travel to transfer heat to the water and/or when there is a high demand for...
Page 70: Air Conditioner Filters
SECTION 4 – APPLIANCES AND SYSTEMS Fuel Nozzle See “Winterizing Procedure” in Section 7 - Plumbing (ANTIFREEZE FILL PROCEDURE) for complete instructions in winterizing your Hydronic Heating System. The Aqua-Hot will be winterized along with the rest Hydronic Heating System of the RV water systems.
Page 71: Washer/Dryer - Stackable
SECTION 4 – APPLIANCES AND SYSTEMS Before using the Stackable Washer/Dryer, please spend a few moments reading the manufacturer’s user guide provided in your InfoCase for complete operating instructions, troubleshooting and maintenance tips, as well as safety precautions. Return Air Vent (Press tabs inward to remove air vent) It is recommended to use mild soap and warm water to clean the air filters.
Page 72 SECTION 4 – APPLIANCES AND SYSTEMS Model 42JD Water Supply Faucets Water Supply Faucets (Located in lower linen cabinet along left- (Located along left-hand side of hand side of Stackable Washer/Dryer) Stackable Washer/Dryer cabinet - remove panel to access) * Shown with slideout room extended Model 42QD See “Winterizing Optional Appliances”...
Page 73: Washer/Dryer - Prep Package
• Remove vertical wood trim on each side of the Stackable Washer/Dryer Cabinet. for the Washer/Dryer installation from your • Remove entire cabinet face to access the cover ® ® Winnebago or Itasca dealer. panel on the lower front of the Washing Machine. * Model 42JD DISHWASHER...
Page 74: Central Vacuum Cleaner
SECTION 4 – APPLIANCES AND SYSTEMS To Use The Vacuum Plug the hose into the hose outlet. The Central Power Vacuum Cleaner will start automatically. When Button you remove the hose, the vacuum will stop. Start/Pause Lock Button Button 1. Press the Power button (left side of touch panel).
Page 75 SECTION 4 – APPLIANCES AND SYSTEMS If The Vacuum Will Not Start Check for a tripped circuit breaker. Also be sure that the vacuum unit is plugged into the electrical outlet in the exterior storage compartment, and the shoreline is connected. To Change Filter Bags Pull the cover from the square metal canister.
Page 77: Propane Gas
SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.
Page 78: Propane Accessory Connection
SECTION 5 – PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk DAN GE R dealerships. NOTE: If you travel outside the U.S. with your DO NOT FILL CONTAINER TO MORE motor home, you may find butane or THAN 80 PERCENT OF CAPACITY.
Page 79: Safe Use Of The Propane Gas System
SECTION 5 – PROPANE GAS See Section 2 - Safety and Precautions in this Propane gas also contains an odor additive manual for other safety and precautions you need that you can smell if propane is present in the air. to be aware of related to propane.
Page 80: Propane Gas Warnings And Precautions
SECTION 5 – PROPANE GAS PROPANE GAS WARNINGS AND PRECAUTIONS WARNING It is illegal for vehicles equipped with propane tanks to travel on certain roadways or through Propane cylinders shall not be placed or certain tunnels in the U.S. To avoid stored inside the vehicle.
Page 81: Propane Vaporization In Cold Weather
SECTION 5 – PROPANE GAS WARNING Visually inspect the pressure regulator vent periodically for blockage by accumulated debris or insect nests, etc. Vent obstruction could result in excessive pressure causing fire or explosion, which could result in death or serious injury. If an obstruction exists, have the regulator serviced by a qualified service center.
Page 82 SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.
Page 83: Electrical
SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...
Page 84: Power Cord Reel
SECTION 6 – ELECTRICAL be used is designed to mate with the prongs of the power cord plug, the electrical connection can be expected to carry rated load. Connecting The Power Cord To connect to an external source, remove the cord from the utility compartment and plug it into a suitable 50-amp power receptacle to provide external power to the coach and converter/...
Page 85: Inverter/Charger Unit - 2800W (Pure Sine Wave)
SECTION 6 – ELECTRICAL Further Information See the manufacturer’s user guide provided in your InfoCase for complete features, operating instructions, and precautions. INVERTER/CHARGER UNIT – 2800W (PURE SINE WAVE) –If Equipped (For models equipped with Residential- Style Refrigerator) The 2800-watt inverter/charger has an AC input circuit breaker to protect the inverter/ charger from overloads.
Page 86: Charging Section
SECTION 6 – ELECTRICAL maintenance, especially in cold weather. See “Battery Care” at the end of this NOTICE section for additional information. Inverter/Charger Control Panel Do not store items too closely around the The inverter/charger has a wall-mounted inverter unit in the storage compartment. The inverter generates heat while control panel that can be programmed for several operating and needs unrestricted airflow...
Page 87: Inverter/Charger Unit - 2000W
SECTION 6 – ELECTRICAL INVERTER/CHARGER UNIT – 2000W NOTICE –If Equipped The 2000-watt inverter/charger has an AC Do not store items too closely around the input circuit breaker to protect the inverter/ inverter unit in the storage compartment. charger from overloads. The inverter/charger The inverter generates heat while also has “built in”...
Page 88: Circuit Breakers - House 120-Volt Ac
SECTION 6 – ELECTRICAL Inverter/Charger Control Panel CIRCUIT BREAKERS – HOUSE The inverter/charger has a wall-mounted 120-VOLT AC control panel that can be programmed for several The breaker panels protect all 120-volt charging options. It will also display warnings for components in the motor home from either an overload conditions or other operating failure overload on the circuit or a short in the wiring or...
Page 89: Ground Fault Circuit Interrupter
SECTION 6 – ELECTRICAL GROUND FAULT CIRCUIT ELECTRICAL GENERATOR INTERRUPTER Bath, galley, and exterior outlets are WARNING connected to a GFCI (Ground Fault Circuit Interrupter), which is an extremely sensitive circuit breaker that will help to protect against Careless handling of the generator and severe electrical shock if a ground fault develops.
Page 90 SECTION 6 – ELECTRICAL The following label is located near the 120- volt house circuit breaker panel and at the Generator to warn you to disconnect specific electrical connections before servicing the Generator and storing the coach. Automatic Power Transfer Box See the AGS user guide provided in your (Located inside or behind utility compartment)
Page 91: Generator Hourmeter
SECTION 6 – ELECTRICAL Control Pad, the dash instrument panel, Check Generator oil level frequently during or on the Generator itself, depending on periods of use. Refer to the Generator model. manufacturer’s user guide provided in your InfoCase for specific recommendations. Generator Hourmeter Generator Access The Generator Hourmeter is located on the...
Page 92: Electrical System - House 12-Volt Dc
SECTION 6 – ELECTRICAL House Batteries House batteries are “deep-cycle” type batteries specially designed for recreational vehicle use. They will provide longer lasting power than standard automotive starting batteries and will withstand the frequent drain-and- recharge cycles that occur under the demanding conditions of a camping outing.
Page 93: House/Coach Battery Disconnect Switch
SECTION 6 – ELECTRICAL The circuitry within the device prevents back feeding of electricity from the chassis to coach battery so if 120-volt power is interrupted, the chassis battery will not be discharged. House Batteries The house batteries supply current to 12-volt equipment located in the living area of the coach.
Page 94: Battery Care
SECTION 6 – ELECTRICAL NOTICE Always refasten battery retainers when returning a battery to the compartment. Removable Floor Panel (Access through mid-coach driver and BATTERY CARE passenger side compartment doors) • Unlatch the twist-locks and remove floor Lead-acid type batteries are electro-chemical panel to access batteries.
Page 95 SECTION 6 – ELECTRICAL WARNING WARNING California Proposition 65 Warning: Before removing any battery cables or Battery posts, terminals, and related battery, make sure all 12-volt equipment accessories contain lead and lead in the motor home is off and the power compounds, chemicals known to the cord has been disconnected.
Page 96: Circuit Breakers - House 12-Volt
Chassis Batteries If your coach is going to be unoccupied for ® two weeks or more, Winnebago Industries recommends disconnecting the chassis batteries in your coach to avoid battery discharge. Turn the Chassis Battery Disconnect switch (located near the entrance door) to the OFF position to disconnect batteries.
Page 97: Plumbing
SECTION 7 – PLUMBING The tank is filled through the city water FRESH WATER SYSTEM connection (Fresh Water Inlet), water hose reel (if equipped), or the fresh water fill port on the The Fresh Water System provides water to the water tank itself (remove carpeted panel in first galley sink, shower, bathroom lavatory, and passenger side compartment to access).
Page 98 SECTION 7 – PLUMBING 3. Turn city water supply ON. 4. Use the level display on the monitor panel to oversee filling of the tank, or when the tank is full, water will flow from tank vent tube beneath coach. NOTICE Fresh Water Valve in Normal use position Do not leave fresh water connection...
Page 99: Water Pump
SECTION 7 – PLUMBING NOTE:Ensure the Fresh Water valve is in Normal position to use the water pump. If the valve is in Tank Fill position, the pump will run continuously without delivering water. WATER PUMP When your coach is not connected to a city water supply, water is supplied from the fresh Unscrew bowl water tank by a water system demand pump.
Page 100: Filtered Water Faucet
SECTION 7 – PLUMBING 2. Turn water pump switch to “OFF” position. 3. Fill water tank. 4. Open all faucets, hot and cold. 5. Turn on water pump switch. 6. Close each faucet as it begins to deliver a steady stream of water (close cold water first). Leave hot water faucets on until they also deliver a steady stream of water.
Page 101: Ice Maker Water Filter
SECTION 7 – PLUMBING • Purge a new filter cartridge before using for Filtered Water Faucet drinking. Run a few gallons of water through -Typical View the filter and discard the water (or use for watering plants) to avoid ingesting carbon dust or particles that may have been present in the new filter cartridge.
Page 102: Full-Coach Water Filtration System
SECTION 7 – PLUMBING FULL-COACH WATER FILTRATION SYSTEM –If Equipped The full-coach water filtration system is connected to the cold water lines throughout the coach. It uses a flow-through filter that removes chlorine, cloudiness, and sediments, resulting in clear, odorless and taste-free clean water for drinking, cooking, and personal care.
Page 103: Disinfecting Your Fresh Water System
SECTION 7 – PLUMBING • Turn the Fresh Water Valve to Normal position. Next open a faucet inside the coach or the exterior shower, then turn city water on SLOWLY to allow the canister to fill with water. • Thoroughly flush the filtration system by running the water for twenty (20) minutes.
Page 104 SECTION 7 – PLUMBING This solution will result in a residual chlorine 2. Remove the full-coach filter cartridge from concentration of approximately 50 ppm in the the filter canister to avoid prematurely water system. (If a 100 ppm concentration is “plugging up”...
Page 105: Shower Hose Vacuum Breaker
SECTION 7 – PLUMBING SHOWER HOSE VACUUM BREAKER After using the shower, you may notice water dripping from the shower faucet assembly. The dripping results when vacuum in the shower hose (after closing the shower faucet) slowly releases and allows water remaining in the hose to drain Important “Don’ts”...
Page 106: Drainage System (P-Traps)
SECTION 7 – PLUMBING Further Information Normal Flush Water See the toilet manufacturer’s operation Saver Flush information provided in your InfoCase for complete operating, care, and maintenance information. DRAINAGE SYSTEM (P-TRAPS) Ensure there is an adequate amount of water in the drainage system p-traps to avoid sewer odor from entering your coach.
Page 107 SECTION 7 – PLUMBING NOTE: The sewage drain outlet swivels ensure complete drainage. Close the Black downward when necessary to avoid Waste Tank Drain Valve as soon as the tank is bends in the sewage drain hose, which empty. could trap solids while dumping or to NOTE: DO NOT OPEN BOTH VALVES AT provide more direct drainage while using ONCE.
Page 108 SECTION 7 – PLUMBING Flushing Your Black Waste Holding NOTE: Black and Gray Waste Tank Drain Valve positions may be reversed depending on Tank floorplan and tank location. The black waste holding tank is equipped with 4. Open the Gray Waste Tank Drain Valve with an internal spray head that allows you to rinse the a quick pull.
Page 109: Utility Light
SECTION 7 – PLUMBING NOTE: Always keep service access passage WATERLINE AND TANK DRAIN closed while utility connection is not in VALVES use. When using a sewer hook-up, keep the Black The water drain valves are used to drain water and Gray Waste Tank Drain Valves closed until from the water tank and the water supply lines a tank becomes full or when preparing to leave...
Page 110: Winterizing Procedure
SECTION 7 – PLUMBING WARNING NEVER use automotive antifreeze/ coolant in your RV water system. Auto antifreeze contains ethylene glycol which, if ingested, can cause blindness and can be fatal. Remove Water Filters (if equipped) WINTERIZING PROCEDURE 1. Remove and discard the filter cartridge from the filtered water faucet/ice maker filter assembly below the galley sink.
Page 111 SECTION 7 – PLUMBING After removing filter, remount the empty Locations” chart at the end of this canister onto the filter assembly and continue section for valve locations on your the antifreeze fill procedure. model. 3. Turn Winterization Valve 2 to the “Winterize” Fill Lines position.
Page 112: Winterizing Optional Appliances
SECTION 7 – PLUMBING Dump and Clean Holding Tanks 13. Completely drain the sewage and waste water holding tanks at an approved waste disposal site. Drain the sewage tank first so the following waste water can rinse any waste solids from the sewage drain outlet and sewer hose.
Page 113 SECTION 7 – PLUMBING 5. Ensure the ice bin is in place and the wire shut- off arm is lowered to the ON position. 6. Allow the refrigerator to cool down to ice making temperature. Remember, this can take up to 24 hours. NOTE: Discard the first two batches of ice cubes.
Page 114 SECTION 7 – PLUMBING 6. Allow machine to run through the complete 2. Follow coach winterization instructions for cycle to clean out any remaining antifreeze. using the winterization valve to draw RV Finished. water system antifreeze into the water system so antifreeze can enter the Dishwasher.
Page 115: Water System Drain Valve Locations
SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS SYSTEM DRAIN VALVE LOCATION Waterlines • Remove two (2) waterline caps located in the water pump compartment (second compartment on driver side). • Open exterior shower faucet and lay shower head on ground. Also, to drain any water left in the city waterline, place the tip of your finger inside the city water connection and gently press the backflow valve (small “button”...
Page 117: Entertainment
SECTION 8 – ENTERTAINMENT To Watch Satellite TV (Dish) or HIGH DEFINITION VIDEO Auxiliary AV Component SELECTION SYSTEM -If Equipped • Connect satellite receiver to the accessory connection cable (satellite receiver.) This cable is located near the entertainment center cabinet. High Definition Video Selection Box (Located near entertainment center cabinet) -Typical View...
Page 118: Front Tv Ignition Switch Interlock
SECTION 8 – ENTERTAINMENT AUDIO-VIDEO SYSTEM BASIC OPERATION NOTE: For your convenience, we have also included a handy, tear-out version of this “A/V System Basic Operation” guide in Section 8 of your Operator’s Manual Supplement. See your InfoCase for specific operating guides for audio and video components.
Page 119: Cd/Dvd Player - Bedroom
SECTION 8 – ENTERTAINMENT Further Information • When the main menu ENTER screen appears, use the See the manufacturer’s user guide provided in arrow buttons on the your InfoCase for complete feature descriptions remote to select the and operating instructions. desired entry or press the ENTER or PLAY buttons on the remote (or “Play”...
Page 120: Cd/Dvd Player
SECTION 8 – ENTERTAINMENT • The DVD may load directly to the main title/ The exterior entertainment center TV is menu screen or it may begin to play previews. connected to the exterior DVD player, video You may be able to skip previews if desired by selection box, the rooftop antenna, and the park pressing the NEXT button until you see the cable input.
Page 121: Tv Antenna - Digital
SECTION 8 – ENTERTAINMENT Cable 2. Turn ON the Signal Meter Power switch (located on the side of the Signal Meter). (Park cable input located in power cord compartment) • Signal Meter • Turn Off antenna booster inside coach. See Power Switch above photo.
Page 122: Satellite Dish And Cable Tv Connections
A second connection may be included inside a cabinet in the bedroom for the rear TV (if equipped). ® See your authorized Winnebago Industries dealer for proper installation and sealing of roof mounted components. TV Signal Amplifier Power Switch -Typical View...
Page 123: Tv Digital Satellite System (Automatic/In-Motion)
SECTION 8 – ENTERTAINMENT NOTE: If you are located in the areas shaded in black, or are unable to receive a satellite signal, it may be necessary to re- program your Dish Network satellite system or convert to a different satellite trio.
Page 124: Dish Network Satellite Receiver
SECTION 8 – ENTERTAINMENT Dish Network Receiver (Located in entertainment center cabinet) 4. Power ON the Automatic/In-Motion Satellite Dish Control. See “TV Digital Satellite System (Automatic/In-Motion) information elsewhere in this section for operating Automatic/In-Motion Satellite Dish Control instructions. (Located in overhead cabinet or entertainment center cabinet, depending on model) 4.
Page 125: Exterior Entertainment Center
SECTION 8 – ENTERTAINMENT Dish Network Remote Control (Provided in your InfoCase) Exterior Entertainment Center -Typical View Further Information See the manufacturer’s user guide provided in Further Information your InfoCase for a complete description of Please read the manufacturer’s user guide in features and operating instructions.
Page 127: Furniture And Softgoods
SECTION 9 – FURNITURE AND SOFTGOODS LOUNGE CHAIR - SWIVEL –If Equipped (Typical View - Your coach may differ in appearance, depending on model) This chair is not equipped with a seat belt and is not intended for seating while the vehicle is in motion.
Page 128 SECTION 9 – FURNITURE AND SOFTGOODS 2. Bind chairs together with the provided strap, ensuring the strap goes through the ring Buffet Table Extension located on the bottom side of the buffet table. 1. Grasp the edge of the buffet table and pull all the way out.
Page 129: Sleeping Facilities
SECTION 9 – FURNITURE AND SOFTGOODS 4. Secure both latches at the bottom of the buffet table. NOTE: The buffet table extension is typically 5. Reverse steps to store buffet table extension. located inside a galley storage cabinet. See following photo. SLEEPING FACILITIES WARNING Sleeping facilities are not intended for...
Page 130: Rest Easy Multi-Position Lounge
SECTION 9 – FURNITURE AND SOFTGOODS REST EASY MULTI-POSITION ® LOUNGE –If Equipped (Typical view - your coach may vary in appearance) Security Latch Handle accessible through front sofa opening NOTICE Do not recline the lounge completely flat unless the footrest section is extended. To Operate •...
Page 131: Bed Conversion
SECTION 9 – FURNITURE AND SOFTGOODS The footrest will lock when in the fully extended position. You must squeeze the • Press to • Press to release latch to retract the footrest. return upright recline Rest Power Easy Switch • Press the switch toward the inboard side of the lounge to recline.
Page 132: Extendable Sectional Sofa
SECTION 9 – FURNITURE AND SOFTGOODS WARNING Stow sectional sofa extension before retracting slide rooms. Failure to observe can cause injury and will cause equipment damage. Extending Sectional Sofa 1. Release and Hold the black lever (located on the arm of the sectional) to release the sectional extension.
Page 133: Digital Sleep Air Bed
SECTION 9 – FURNITURE AND SOFTGOODS 4. Push front of seat cushion down, and then push rearward to secure the seat cushion into Reverse steps to store the sectional extension. place. DIGITAL SLEEP AIR BED ® by Innomax –If Equipped •...
Page 134: Bed - Power Lift
SECTION 9 – FURNITURE AND SOFTGOODS NOTE: If your bed is equipped with the power lift feature, it is recommended to deflate the air mattress to 25 or below when WARNING elevating the bed into the fully upright position. This will help prolong the life Keep people away from operating of your air mattress.
Page 135: Wood Furniture And Cabinetry
No matter which species you choose for your new Winnebago Industries motorhome cabinetry, please keep in mind that no two pieces of wood are exactly the same.
Page 137: Slideout Rooms And Leveling
SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Release SLIDEOUT ROOM TRAVEL • Press and hold the UNLOCK side of the LOCKS - ELECTRIC Slideout Room Travel Lock switch for –If Equipped approximately 7 seconds. (You may be able to hear the lock motor sound stop).
Page 138: Slideout Room Keylock
SECTION 10 – SLIDEOUT ROOMS AND LEVELING SLIDEOUT ROOM RETRACTION (WITH POWER LIFT BED OPTION) -If Equipped Your coach may be equipped with a power lift/lower mechanism that raises and lowers the head of your bed to best suit your comfort needs. This power lift/lower mechanism is equipped with an interlock feature, which will not allow you to retract the bedroom slideout unless the bed...
Page 139: Slideout Room Operation - Electric
SECTION 10 – SLIDEOUT ROOMS AND LEVELING The slideout room system uses 12-volt DC SLIDEOUT ROOM OPERATION motorized mechanisms with an electronic control – ELECTRIC system to provide smooth operation and positive weather seal. NOTE: We recommend that you KEEP THE WARNING ENGINE RUNNING WHILE EXTENDING OR RETRACTING...
Page 140 SECTION 10 – SLIDEOUT ROOMS AND LEVELING compartments, which could be crushed or cause damage to floor covering or cabinets when the room is retracted. NOTICE Release slideout room travel latch before NOTICE attempting to extend slideout room. Secure travel latch before driving vehicle. Because the slideout roof is drawn into Extend Procedure: the interior of the coach when retracted,...
Page 141: Slideout Room - Extreme Weather Precaution
SECTION 10 – SLIDEOUT ROOMS AND LEVELING • Press the Slideout Room “RETRACT/IN” SLIDEOUT ROOM switch and hold until the room is fully TROUBLESHOOTING retracted, then release the switch. • To stop retracting the room during operation, Battery Voltage or Circuit Breaker release the button.
Page 142 SECTION 10 – SLIDEOUT ROOMS AND LEVELING Manual Mode Manual Mode lets you individually move the • Light will flash fault • Light will flash if code if system two room arms by pressing the IN and OUT park brake not set malfunctions buttons on the touchpad.
Page 143: Slideout Emergency Retraction
SECTION 10 – SLIDEOUT ROOMS AND LEVELING SLIDEOUT EMERGENCY • Light will flash fault RETRACTION • Light will flash if code if system park brake not set malfunctions -If Equipped If the slideout mechanism is malfunctioning and the room will not retract using the interior control switch, you may need to access the motor/gear assembly and manually crank the room in to the travel position.
Page 144: Slideout Emergency Retraction - Bedroom
SECTION 10 – SLIDEOUT ROOMS AND LEVELING If help is available, a second person (with a • Disconnect the motor power lead from the duplicate socket and ratchet) cranking the wiring harness. other end simultaneously will greatly speed • Use a 3/4” socket and ratchet wrench on the up the process.
Page 145: General Slideout Care
SECTION 10 – SLIDEOUT ROOMS AND LEVELING GENERAL SLIDEOUT CARE • Keep slideout room seals clean. • Clean the floors inside the coach before retracting the slideout room to avoid floor scratches or carpet pile snags. • Wipe outer slideout room seals occasionally with talc or 303 brand protectant for smooth, quiet operation.
Page 146 SECTION 10 – SLIDEOUT ROOMS AND LEVELING WARNING • Keep all people clear of the coach while the leveling system is operating. • When extending the rear stabilizers, do not lift the wheels beyond ground contact. This makes it possible for the Auto Level Remote Switch vehicle to roll unexpectedly forward (or (Located inside entrance door)
Page 147: Checking Hydraulic Oil Level
SECTION 10 – SLIDEOUT ROOMS AND LEVELING CHECKING HYDRAULIC OIL LEVEL NOTICE See the Leveling System Operation Guide provided in your InfoCase for complete • Do not try to drive vehicle unless maintenance instructions and information. “TRAVEL” light is glowing with ignition All maintenance should be done as part of the switch on.
Page 148 SECTION 10 – SLIDEOUT ROOMS AND LEVELING NOTE: Overfilling the hydraulic reservoir can cause leakage of oil through the breather cap. Hydraulic Fluid Recommendation ® ® Dexron II or Mercon automatic transmission fluid is recommended for use in your Leveling System. DO NOT USE brake fluid or hydraulic jack oil, which can damage the seals and cause leaks.
Page 149: Maintenance And Storage
• Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.
Page 150: Exterior Automotive Paint Finish
SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the initial 60-day cure stage, a coat of wax or amount of cargo you can carry and remain within polish can help protect the surface from these GVWR and GAWR limits.
Page 151 SECTION 11 – MAINTENANCE AND STORAGE Bug Removal to clean heavy road films on semi trailers and are often dirty. They are not • Rinse the loose debris off with water and designed for custom painted RV’s and allow the remaining residues to soak and they will scratch the clearcoat finish.
Page 152: Exterior Graphic Care
1 1/2 feet from the edge of the graphics. ® • Test any cleaning solution on a small section Most Winnebago Industries vehicles have of graphic before using. polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical •...
Page 153: Plastic Parts - Cleaning
SECTION 11 – MAINTENANCE AND STORAGE • Some popular citric acid cleaners may cause bicarbonate lenses to become “hazy” or “foggy”. NOTICE • Do not use a pressure washer to clean headlights. Do not use citrus-based cleaners on • Inspect and operate the lights regularly to polycarbonate finishes.
Page 154: Interior Soft Goods
SECTION 11 – MAINTENANCE AND STORAGE resistance to soils and stains of vinyl fabrics. It is INTERIOR SOFT GOODS also tougher than real calfskin and has superior resistance to punctures, snags, and rips. We recommend a weekly routine of vacuuming all fabrics and carpet throughout the For most soils and stains, the fabric motor home to prevent an accumulation of dirt, manufacturer recommends spot treatment with a...
Page 155: Cabinetry - Cleaning
SECTION 11 – MAINTENANCE AND STORAGE Draperies, Curtains, and If a stain has dried on, allow the cleaner or soapy water time to soften the area, after which Bedspreads the stain will wipe off. These items may be woven from a variety of If the stain is not water-base or oil-base fabrics.
Page 156: Stainless Steel Appliances
SECTION 11 – MAINTENANCE AND STORAGE Coffee and Tea Stains replacement. If one of these materials does spill or drip onto the counter surface, wipe it up Prepare a sodium bicarbonate solution and hot immediately to avoid damage. water. Apply generously to stain and let sit for 15 minutes.
Page 157: Range And Refrigerator
SECTION 11 – MAINTENANCE AND STORAGE • Never use steel wool. Particles of steel from • Apply solution to surface with mop or sponge the wool pad can embed into the sink surface, (see Aqua Mix label for concentration to then become rusty and unsightly.
Page 158: Doors And Windows
SECTION 11 – MAINTENANCE AND STORAGE NOTE: Do not use steel wool or metal scouring 5. Fully charge the batteries. Batteries must pads. have at least 80% charge to survive freezing temperatures and long period of Mineral-Based Stains. Cleaners designed to non-use.
Page 159: Vehicle Storage - Removal
SECTION 11 – MAINTENANCE AND STORAGE 12. Clean the interior of the coach. Dirt and stains 11. Add water to the holding tank using the toilet are more easily removed when fresh. flush pedal (or the “Normal Flush” switch if your coach is equipped with an electric flush If you are storing your vehicle through the toilet) and galley sink faucet.
Page 160: Chassis Service And Maintenance
SECTION 11 – MAINTENANCE AND STORAGE 4. Let the refrigerator cool down to ice making temperature. Remember, this can take up to 24 hours. 5. Let the ice maker cycle and dump the first batch of ice. CHASSIS SERVICE AND MAINTENANCE Consult the appropriate sections in your chassis manual for specific information...
Page 161 SECTION 11 – MAINTENANCE AND STORAGE on the steering column support plate beneath the dash and in the rear engine compartment as shown in the following photos. Diagnostic plug on steering column support beneath left side of dash -Typical View Diagnostic plug on rear engine compartment shroud -Typical View...
Page 162: Coach Maintenance Chart
SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System ...
Page 163 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: ...
Page 164 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants ...
Page 165: Miscellaneous
SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.
Page 166 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motor home is to weigh each “corner”...
Page 167: Car Or Trailer Towing
SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.
Page 168: Trailer Wiring Connector
SECTION 12 – MISCELLANEOUS Before descending a steep or long grade when TRAILER WIRING towing a trailer, reduce speed and shift into a CONNECTOR lower gear to control vehicle speed. Avoid prolonged or frequent application of brakes Your coach is pre-wired for trailer or car which could cause overheating and brake failure.
Page 169: Fireplace
NOTE: Some Winnebago Industries models traveled. The Department of equipped with a Class 3 hitch may have a Transportation in a given state or...
Page 170: Countertop Extension
SECTION 12 – MISCELLANEOUS Indicator Panel • For flame effect, turn the Power-On/Off switch ON. • LOW/HIGH INDICATORS • For low heat, turn Heat Level I switch ON. • For high heat, turn Heat Level I and II switches ON. •...
Page 171: Entry Step - Electric
SECTION 12 – MISCELLANEOUS -Typical View • To retract galley countertop extension, pull release lever outward while pushing countertop extension back into stored position. Entry Step Switch NOTE: Ensure the countertop extension is in the (Located near entrance door) stored position before retracting the -Typical View slideout room to prevent possible •...
Page 172: Stepwell Cover
SECTION 12 – MISCELLANEOUS This feature is intended to prevent injury or damage by an extended step while the vehicle is moving. Further Information For additional information on the step, see the manufacturer’s user guide provided in your InfoCase. STEPWELL COVER The stepwell cover can be extended to cover the stepwell area and increase usable floor space in the front of the coach while the entrance door...
Page 173: Windows
SECTION 12 – MISCELLANEOUS Stepwell Cover shown in extended position Emergency Retract Lever -Typical View (Located underneath stepwell cover) • Press DOWN for stepwell cover to store CAUTION WINDOWS Crank-Out Windows Stay clear of the entrance step area when the step cover is being extended or •...
Page 174: Power Roof Ventilator - Galley
SECTION 12 – MISCELLANEOUS Vertical Window Catches • To close, crank the window in snugly (by turning the crank-out handle clockwise), then POWER ROOF VENTILATOR – back off 1/4 turn to help avoid glass warping, GALLEY which can result in wind noise. •...
Page 175: Power Roof Ventilator - Bath
SECTION 12 – MISCELLANEOUS To Operate Ceiling Ventilator Temperature Selector/ 1. Press the wall switch to raise the dome about On-Off Switch 3" or more to allow the turbine fan to operate. (A built-in safety switch will not let the fan motor run unless the dome is partially open).
Page 176: Tool And Ladder Storage
SECTION 12 – MISCELLANEOUS To Operate Ceiling Ventilator 1. Press the wall switch to raise the dome about 3" or more to allow the turbine fan to operate. (A built-in safety switch will not let the fan motor run unless the dome is partially open). 2.
Page 177 SECTION 12 – MISCELLANEOUS The ladder on your motor home is provided • Do not transport items anchored to the for limited access to the roof. ladder. You could damage the ladder. Walking or working on the roof should be left To Use the Ladder Extension up to qualified service personnel using proper safety equipment in a safe environment.
Page 178: Storage Compartment Doors
SECTION 12 – MISCELLANEOUS • Slide the open ends of the C-shaped retainer • Press the switch DOWN (Off) to disable brackets over the lowest ladder rung as shown power to the compartment lights. in the following photo. NOTE: The Compartment Lights switch provides power to the compartment lights.
Page 179 SECTION 12 – MISCELLANEOUS Wind Speed (Awning Sensitivity) Switch (High/Low) Low requires the least amount of motion before automatically closing the awning. High requires more motion before the system automatically closes the awning. You may want to experiment first to find the setting that best suits your needs.
Page 180: Air Hose Connector
SECTION 12 – MISCELLANEOUS Further Information • RETRACT - Press and Hold the Door Awning switch UP until the awning is in the Refer to the awning manufacturer’s user guide desired position, then release the switch. provided in your InfoCase for complete operating instructions and safety precautions.
Page 181: Effects Of Prolonged Occupancy
SECTION 12 – MISCELLANEOUS EFFECTS OF PROLONGED OCCUPANCY Your motor home was designed primarily for recreational use and short-term occupancy. If you expect to occupy your coach for an extended period, be prepared to deal with condensation and humid conditions that may be encountered. Humidity and Condensation Moisture condensing on the inside of windows is a visible indication that there is too...
Page 183 INDEX 2012 New Vehicle Limited Warranty ..1-2 Dishwasher ..........4-17 About this Manual ........1-1 Disinfecting Your Fresh Water System ..7-7 Air Conditioner Filters ....... 4-14 Doors and Windows ......... 11-10 Air Conditioner/Heater – Automotive Drainage System (P-Traps) ......7-10 (Dash) ............
Page 184 Index Fuel and Propane Gas ........2-1 Power Sofas and Beds ........2-6 Fuel Selection – Diesel Engine ....3-21 Pre-Delivery Inspection ....... 1-4 Fuel/Water Separator – Diesel ....3-27 Propane Accessory Connection ....5-2 Full-Coach Water Filtration System .... 7-6 Propane Gas Leak Detector ......
Page 185 Index Slideout Rooms ..........2-6 SmartWheel™ Steering Wheel Control System ........3-17 Smoke Alarm ..........2-4 Sofa/Bed Conversion ........9-3 Solar Charger Panel ........4-7 Solid Surface Countertop – Corian® ..11-7 Specifications and Capacities ...... 1-7 Stainless Steel Appliances ......11-8 Starting and Stopping Diesel Engine ..

Winnebago Tour 2012 Operator's Manual

1 Introduction

2 Safety and Precautions

3 Driving Your Motor Home

4 Appliances and Systems

5 Propane Gas

6 Electrical

7 Plumbing

8 Entertainment

9 Furniture and Softgoods

10 Slideout Rooms and Leveling

11 Maintenance and Storage

12 Miscellaneous

Quick Links

TABLE OF CONTENTS

Need help?

Questions and answers

Related Manuals for Winnebago Tour 2012

Summary of Contents for Winnebago Tour 2012