Cushman 626501 Owner's Manual page 16

GENERAL SPECIFICATIONS
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
2
MODEL: SHUTTLE™ 8
TYPE: ELECTRIC POWERED PERSONNEL CARRIER
MODEL YEAR: 2012
Part No:. 626500
Precision Drive System™ (PDS):
Solid State continuously variable seperately excited speed controller
z
Dash mounted direction selector switch (Forward-Neutral-Reverse)
z
Anti-roll back, walkaway braking and alarm
z
Anti-stall motor protection
z
Regenerative 'Pedal Down' and/or 'Pedal Up' braking
z
Battery Charger: Delta Q, 48 VDC. H120/230 VAC 50/60 Hz. Underwriters Laboratories (U.L.) Listed, (C.S.A. Certified)
Motor: 48 volt DC shunt wound, brazed armature, solid copper windings. Intermittant Horsepower 18.1 hp (13.5 kW) at 1900 rpm (1hour)
Drive Train:
Direct motor shaft connected to transaxle pinion shaft
Electrical System: 48 Volt DC, eight, 6 volt deep cycle storage batteries (107 minute, 225 amp-hour @ 20 hr. discharge rate)
Transaxle: Differential with helical gears
Brakes: 4 Wheel Hydraulic Brakes, Front Disk, Rear Drum, Floor Mounted Manual set/released Park Brake w/ Warning Buzzer
Dimensions
Overall Length
Overall Width
Overall Height (No Canopy)
Overall Height (With Canopy) 76.0 in (193 cm)
Wheel Base
Front Wheel Track
Rear Wheel Track
Gnd Clearance @ Differential 4.3 in (11 cm)
Vehicle Power
Power Source
Motor Type
Continuous Horsepower (kW) 2.5 hp (1.9 kW)
Intermittent Horsepower (kW) 18.1 hp (13.5 kW) @ 1900 rpm
Electrical System
Batteries (Qty, Type)
Key or Pedal Start
Battery Charger
Speed Controller
Drive Train
Transaxle
Gear Selection
Rear Axle Ratio
Noise & Vibration
Noise Sound pressure; continued A-weighted equal to or less than 70 db(A)
Vibration, WBV The RMS value of weighted acceleration is less than 2.5 m/s
Vibration, HAV The RMS value of weighted acceleration is less than 2.5 m/s
The uncertainty of measurement is 0.69 m/s
Measurement methods were applied per the ISO 2631 and ISO 5349 standards under conditions of typical vehicle surfaces.
2012 Shuttle 8 E
Released: 01/12/2012
Revised: 01/12/2012
2 - 2
PRODUCT SPECIFICATION
CONFIGURATION HIGHLIGHTS
Factory programmable to application
PRODUCT OVERVIEW
167.5 in (425.5 cm)
49.5 in (125.7 cm)
45.5 in (115.6 cm) (Top of steering wheel)
123.4 in (313.7 cm)
36.0 in (91.4 cm)
38.0 in (97 cm)
48 Volts DC
Shunt Wound
48 Volt
Eight, 6 Volt Deep Cycle
Pedal Start
48 VDC Delta Q, 120/230 VAC, UL & CSA
400 Amp Precision Drive System (PDS)
Motor Shaft Direct Drive
Differential with helical gears
Dash Mounted Forward-Neutral-Reverse
14.7:1
2
Some items shown may be optional equipment
Specifications are subject to change without notice
* Field installed accessories may require installation charges
Eight, 6 Volt Deep Cycle
z
Full torque, reduced speed reverse
z
Inductive throttle sensor
z
Diagnostic indicator
z
Performance
Seating Capacity 8 Person using Flip/Flop (base config)
Seating Capacity option 6 Person using Cargo Deck w/ stake side
Dry Weight 1142 lb (519 kg) (Without Batteries)
Curb Weight 1632 lb (742 kg)
Cargo Deck Capacity 400 lb.
Vehicle load capacity 1600 lb (727 kg)
Outside Clearance Circle 33 ft (10.1 m)
Speed (Level Ground) 13 mph ± 0.5 mph (21 kph ± 0.8 kph)
Towing Capacity N/A
Steering & Suspension
Steering Self-compensating rack and pinion
Front Suspension Leaf springs with hydraulic shock absorbers
Rear Suspension Leaf springs with hydraulic shock absorbers
Service Brake 4 Wheel hydraulic Brakes, Disk/Front, Drum/Rear
Parking Brake Floor Mounted Manual Set/Release w/Warning Buzzer
Front Tires Kenda Load Star, 50 psi
Rear Tires Kenda Load Star, 70 psi
Body & Chassis
Headlights Halogen Headlights std
Brake Lights Rear Brake lights std
Frame Welded steel. DuraShield™ powder coat
Body & Finish Injection molded TPO
Seat Pod Fiberglass & Gelcoat
Standard Color Hunter Green
2
2