Table of Contents
Advertisement
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Anets 14GS Series
Summary of Contents for Anets 14GS Series
- Page 1 IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment: Model #: __________________________ Serial #: __________________________ Date Purchased: ___________________ Service & Parts Manual Covering the 14GS Series L22-371 Rev 0 2/13...
- Page 2 FOR YOUR SAFETY DO NOT store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance. Do not spray aerosols in the vicinity of this appliance while it is in operation. WARNING Improper installation, alteration, service or maintenance can cause property damage, injury or death.
-
Page 3: Table Of Contents
TABLE OF CONTENTS Leg Installation and Leveling -------------------------------------------------------------------------------------------------------------- 4 Installation Clearances ------------------------------------------------------------------------------------------------------------------- 4 Gas Connection --------------------------------------------------------------------------------------------------------------------------- 4 Gas Connection and Sealing Compound ------------------------------------------------------------------------------------------- 4 Fuel Supply Line Leak and Pressure Testing -------------------------------------------------------------------------------------- 5 ... -
Page 4: Leg Installation And Leveling
1 Leg Installation and Leveling This appliance must be installed with legs; it cannot be curb mounted. Curb mounting will seriously inhibit this appliances ability to effect proper combustion. WARNING This appliance must be installed with the legs provided by the manufacturer. WARNING Do not install legs or perform leveling procedure when unit is in operation or full of cooking medium. -
Page 5: Fuel Supply Line Leak And Pressure Testing
1.4 Fuel Supply Line Leak and Pressure Testing The fuel supply system must be tested before the appliance is used. If the fuel line is going to be tested at a pressure greater than ½ PISG (3.45 kPa), insure that that appliance is disconnected from the fuel line. If the fuel line is to be tested at a pressure equal to or less than ½... -
Page 6: Main Burner System Adjustment
2.2 Main Burner System Adjustment For the main burners to operate the gas supply valve must be open and the thermostat must be turned on. For models with electric controls, the main power switch must be on. The main burners receive gas from the main gas supply through the thermostatically controlled valve. -
Page 7: Thermostat Calibration
CAUTION If the burners do not shut off at the LOWEST thermostat setting, the thermostat may be defective. Contact your local service company. 2.4 Thermostat Calibration For Gas Operated and Electric Thermostats refer to the following procedure. Remove the tube screen from the tank and place the tip of a digital thermometer in the shortening/oil approximately one inch above the temperature sensor. -
Page 8: Trouble Shooting
14GS-CS Series 3 Trouble Shooting Refer to this section to correct common problems that may be encountered during the course of normal operation. If applicable, a schematic is provided behind the panel containing the electrical components. Appliance does not work. Is the gas Will the Open the gas... -
Page 9: Testing The Thermocouple
14GS-CS Series 3.1 Testing the Thermocouple: You will need a multimeter that can measure millivolts. Make sure that after holding a flame to the thermocouple it produces 30 mv. You can test for this by heating the thermocouple for about a minute and then place one lead on the copper casing of the thermocouple and the other lead on one of terminals of the hi limit wire connection. -
Page 10: 14Gs-Fryer Exploded View
14GS-CS Series 4 14GS-Fryer Exploded View L22-371 Rev 0 2/13... -
Page 11: 14Gs-Fryer Parts List
A3680402 FRONT PANEL END CAP LH A3680404 FRONT PANEL END CAP RH A3680702 FRONT PANEL MIDDLE CAP P9204-75 ANETS NAME PLATE BLACK/YELLOW P0091500 TINNERMAN C-12003-017 #6 B3636705 FRONT PANEL TOP DECK STAND ALONE B3636707 FRONT PANEL TOP DECK DUAL B3636709... -
Page 12: Gas Manifold With Pilot Exploded View
14GS-CS Series 5 Gas Manifold with Pilot Exploded View L22-371 Rev 0 2/13... -
Page 13: Gas Manifold With Pilot Parts List
14GS-CS Series 5.1 Gas Manifold with Pilot Parts List ITEM# PART# PART DESCRIPTION P9313-99 MANIFOLD WELDMENT P7036725 PLUG 1/8 NPT B13624-00 PRESSURE TEST PORT (CE) P9500-54 FLAME RETENTION SPRING P8904-68 CROSSOVER TUBE P8904-69 ORIFICE RUNNER TUBE (NAT) P8904-99 ORIFICE RUNNER TUBE (LP) P8904-74 ORIFICE RUNNER TUBE (CE-LP) P8840-96... -
Page 14: Gas Supply Stand Alone Exploded View
14GS-CS Series 6 Gas Supply Stand Alone Exploded View L22-371 Rev 0 2/13... -
Page 15: Gas Supply Stand Alone Parts List
14GS-CS Series 6.1 Gas Supply Stand Alone Parts List ITEM# PART# PART DESCRIPTION UNION BLACK 1/2 NPT P7036902 ELBOW, STREET 1/2 NPT 90 DEGREE P7037750 NIPPLE, BLACK 1/2 NPT X 3 1/2" P7037096 P7037678 ELBOW, BLACK 90 DEGREE P7037098 NIPPLE, BLACK 1/2 NPT X 4 1/2" 60125901 GAS VALVE VENT TUBE (DOMESTIC ONLY) P7037090... -
Page 16: Gas Supply With Filter Exploded View
14GS-CS Series 7 Gas Supply With Filter Exploded View L22-371 Rev 0 2/13... -
Page 17: Gas Supply With Filter Part List
14GS-CS Series 7.1 Gas Supply With Filter Part List ITEM# PART# PART DESCRIPTION UNION BLACK 1/2 NPT P7036902 ELBOW, STREET 1/2 NPT 90 DEGREE P7037750 NIPPLE, BLACK 1/2 NPT X 3" P7037095 P7037678 ELBOW, BLACK 90 DEGREE P7037099 NIPPLE, BLACK 1/2 NPT X 5" 60125901 GAS VALVE VENT TUBE (DOMESTIC ONLY) 60127401... -
Page 18: Stat Assembly Dom-Exploded View
14GS-CS Series 8 T-STAT Assembly DOM-Exploded View 8.1 T-STAT Assembly DOM-Parts List ITEM# PART# PART DESCRIPTION PP10084 SWITCH, HI-LIMIT 60125401 THERMOSTAT, RX MILLIVOLT 200-400F B14503-00 PIPING, BRACKET THERMOSTAT WITH IGNITOR A8049801 PIPING, BRACKET THERMOSTAT WITHOUT IGNITOR PP10687 SCREW, 6-32 X 5/16 TH PHILLIPS PP10539 KNOB, THERMOSTAT P0007300... -
Page 19: Stat Assembly Exploded Au View
14GS-CS Series 9 T-STAT Assembly Exploded AU View 9.1 T-STAT Assembly AU Parts List ITEM# PART# PART DESCRIPTION PP10084 SWITCH, HI-LIMIT P5047590 THERMOSTAT, GS 190C B14503-00 PIPING, BRACKET THERMOSTAT WITH IGNITOR A8049801 PIPING, BRACKET THERMOSTAT WITHOUT IGNITOR PP10687 SCREW, 6-32 X 5/16 TH PHILLIPS PP10539 KNOB, THERMOSTAT P0007300... - Page 20 14GS-CS Series In the event of problems with or questions about In the event of problems with or questions about your order, please contact the Anetsberger your equipment, please contact the Anetsberger Factory at: Authorized Service and Parts representative (ASAP) covering your area, or contact +001 (603) 225-6684 (World Wide) Anetsberger at the number listed to the left.
Need help?
Do you have a question about the 14GS Series and is the answer not in the manual?
Questions and answers