Summary of Contents for Windsor Saber Cutter SCX326
Page 1
Walk Behind Scrubber Operating instructions (ENG) MODELS: SCX326 10052400 SCXN326 10052850 BSCSCX326 10052880 Prior to Serial Number (Ref No. 6*) See Serial number page or call manufacturer. Read these instructions before using the machine. 86039100-BJ 07/06/15...
Warranty Registration Thank you for purchasing a Windsor product. Warranty registration is quick and easy. Your registration will allow us to serve you better over the lifetime of the product. To register you product go to : www.windsorind.com/WarrantyRegistration.aspx...
How To Use This Manual This manual contains the following sections: The SAFETY section contains important information regarding hazardous or unsafe practices of the • How to Use This Manual machine. Levels of hazards are identified that could • Safety result in product damage, personal injury, or severe •...
Safety Important Safety Instructions When using this machine, basic precaution must always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE. To reduce the risk of fire, electric shock, or injury: Use only indoors. Do not use outdoors or expose to rain. Use only as described in this manual.
WHEN SERVICING MACHINE: Avoid moving parts. Do not wear loose clothing; jackets, shirts, or sleeves when working on the machine. Use Windsor approved replacement parts. Batteries emit hydrogen gas. Explosion or fire can result. Keep sparks and open flame away. Keep top cover in raised position when charging. Keep sparks and flames away from the batteries.
Safety Safety Label Location NOTE: These drawings indicate the location of safety labels on the machine. If at any time the labels become illegible, promptly replace them. SAFETY DECAL 86252530 BATTERY CAUTION 86252520 SEE MANUAL CIRCUIT BREAKER DECAL 86243610 2% GRADE WARNING 86039100 CUTTER 36V...
Operations Technical Specifications ITEM DIMENSION/CAPACITY Nominal power 2160 W Rated Voltage 36 Volt DC Rated Amperage 60 amps Batteries 6 x 6 volt 250-305-335 AH @ 20 Hr rate Scrub Brush Motors 2 x .75 hp (.56 kW) Vacuum Motor 3 Stage .75 hp (.56 kW) Propelling Motor .75 hp (.56 kW)
Page 9
Operations Technical Specifications ITEM MEASURE Height 46 in (117 cm) Length with 32 in. (81 cm) scrub head 71 in (180) Width without squeegee and scrub head 28 in (71 cm) Width of squeegee for 32 in. (81 cm) scrub head 39 in (99 cm) Width of scrub path for 32 in.
Operations How The Machine Works The function of the directional control system is to control the direction and speed of the machine. The The Saber Cutter is a battery powered, self-propelled, directional control system consists of the propel control buttons, reverse button, speed control knob/potentiom- hard floor scrubber intended for commercial use.
Operations Components 1. Control Panel 2. Front Cover 3. Recovery Tank 4. Recovery Tank Drain Hose 5. Scrub Head Shrouds 6. Solution Tank 7. Solution Tank Cover 8. Solution Tank Drain Hose 9. Solution Strainer 10. Squeegee 11. Aqua-Mizer 12. Top Cover 13.
Page 13
Operations 1. Key Switch 3. SPEED CONTROL KNOB 2. Emergency Shut Off Switch (Optional) Controls the speed of the machine. 3. Speed Control Knob To increase speed, rotate knob clockwise. 4. Propel Control Lever To decrease speed, rotate knob counterclockwise 5.
Page 14
Operations 7. ACTUATOR SWITCH 10. SQUEEGEE LIFT LEVER Adjusts the amount of brush pressure to the floor by Raises and lowers the squeegee. raising or lowering the scrub deck. To lower the squeegee, lift the lever from its raised To increase brush pressure, press the bottom of the position.
Page 15
Operations 13. BATTERY CHARGE LEVEL INDICATOR Indicates the charge level of the batteries. The meter display is divided into 10 vertical bars. Bar illuminated on the far right indicate full charge. Bars flashing near the left side indicate the batteries should be recharged.
Operations Machine Operation Filling Solution Tank FOR SAFETY: Before leaving or servicing Pre-Run Machine Inspection machine; stop on level surface, turn off machine and remove key. Do a pre-run inspection to find possible problems that could cause poor performance or lost time from break- 1.
Operations Normal Scrubbing To Begin Scrubbing Plan the scrubbing pattern in advance. The longest track is around the perimeter of the area to be cleaned. For efficient operation, the runs should be the longest When operating the machine around people, pay possible without turning, stopping, or raising and close attention for unexpected movement.
Operations Machine Operation Recovery Tank 1. Unhook the large drain hose from the retainer. Double Scrub Unscrew the T-handle on plug enough to loosen plug, then lower hose in direction of the drain. Do For floors which are heavily soiled or have thick accu- not stand in front of end of hose.
Maintenance Service Schedule MAINTENANCE DAILY WEEKLY MONTHLY 50 HRS Check batteries after charging; add water if necessary Check pad wear to prevent buildup of chemicals Check linkages and connectors for wear and damage Check hoses for wear, blockages, or damage Clean squeegee;...
Page 20
Maintenance 1. Batteries 2. Squeegee 3. Aqua Mizer 4. Scrub Brushes 5. Recovery Tank Float Shut-Off 6. Solution Strainer 7. Brush Motor 8. Traction Motor 9. Circuit Breakers 10. Brush Shroud & Brush Skirts 11. Vacuum Motor 12. Actuator Scrub Deck 86039100 CUTTER 36V...
Maintenance Batteries The batteries provide the power to operate the When servicing machine, avoid contact with machine. The batteries require regular maintenance to battery acid. keep them operating at peak efficiency. The machine batteries will hold their charge for long periods of time, but they can only be charged a certain Batteries emit hydrogen gas.
Maintenance Checking Battery Specific Gravity To Charge The Batteries Use a hydrometer to check the battery specific gravity. When servicing machine, avoid contact with battery acid. Batteries emit hydrogen gas. Explosion or fire can result. Keep sparks and open flame away. Keep covers open when charging.
Maintenance 5. Replace the battery caps, and leave them in place Changing Batteries while charging. Stop the machine in a clean area next to the charger. 6. Unplug the battery connector from the machine. Turn off machine. FOR SAFETY: When charging, connect the FOR SAFETY: Before leaving or servicing the charger to the batteries before connecting the machine;...
Maintenance Squeegee Blades To Remove Squeegee Assembly The front squeegee blade allows solution to pass 1. With the squeegee in the up position, turn key through channels in the blade into the squeegee switch "OFF". assembly while maintaining vacuum to provide lift. The 2.
Maintenance To Adjust Squeegee Pitch To Adjust Amount of Rear Squeegee Deflection 1. Choose a smooth, level surface. Turn "ON" the key switch. Lower the squeegee and drive forward 1. Choose a smooth, level surface. Lower the at least 2 feet (60cm.). squeegee and drive forward at least 2 feet (60cm).
Maintenance Scrub Brushes Replacing or Installing Scrub Brushes There are four different types of brushes available to 1. With the scrub deck up, turn "OFF" the machine. cover applications from cleaning heavily soiled floors to FOR SAFETY: Before leaving or servicing the polishing.
Maintenance Solution Strainer Brush Motor Carbon Brush Replacement The solution strainer is located in front of the left front 1. Scribe alignment mark on motor barrel to motor wheel. The solution strainer protects the solenoid valve cap. Remove two bolts. from debris.
Maintenance Traction Motor Circuit Breakers Circuit breakers interrupt the flow of power in the event of an electrical overload. When a circuit breaker is tripped, reset it by pressing the exposed button. If a Do not use a pressure washer to clean around the circuit breaker continues to trip, the cause of the elec- motors.
6. Remove vacuum motor from mounting bracket. stop in 7. Reverse steps to install. groove. Vacuum Motor Carbon Brushes Replacement (Windsor) Important: End Cap These brushes wear quicker as the length shortens due to increased heat. Spring inside brush housing...
Maintenance Actuator Scrub Deck Removal/ Scrub Deck Actuator Adjustment Replacement The actuator will need to be adjusted when replaced. FOR SAFETY: Before leaving or servicing To adjust the actuator: machine, stop on a level surface, turn off machine 1. While holding actuator barrel to prevent it from and set parking brake (If option is installed).
Maintenance Greasing Axle RECOMMENDED GREASING: 1-2 strokes of Mobiltemp®78 or compatible clay-based or calcium-based grease. NOTE: Use hand operated grease gun only. 86039100 CUTTER 36V...
Maintenance Machine Troubleshooting PROBLEM CAUSE SOLUTION Poor or no water pick-up Squeegee out of adjustment Adjust squeegee Debris caught on squeegee Remove debris Worn squeegee blades Rotate or replace squeegee blades Vacuum hose clogged Clear obstruction from hose Vacuum hose disconnected from Reconnect vacuum hose squeegee or recovery tank Vacuum hose damaged...
Page 33
Maintenance Machine Troubleshooting PROBLEM CAUSE SOLUTION Little or no solution flow to the Solution tank empty Fill solution tank floor Solution flow turned off or set too low Turn on or increase flow setting Solution strainer plugged Clean solution strainer Solution hoses obstructed Clear obstruction from hose Solution solenoid valve obstructed or...
Page 37
Control Handle SERIAL NO. REF PART NO. DESCRIPTION NOTES FROM 86238730 HANDLE, LEFT 86257230 SWITCH, SPST MOM NO W/LEVER 86254920 SPRING, COMP .240D X 1.25 X .018 86231480 BUTTON, PROPEL 86277070 SCREW, 4-40 X .625 PHPNHMS STL ZNPLT 86240990 HOUSING, BUTTON 86277060 SCREW, 8-32 X .875 PHPNHTC 86277050...
Page 39
Cover (Front) & Tank Mount SERIAL NO. REF PART NO. DESCRIPTION NOTES FROM 86073690 BRT, REC TO SOL W/BRAKE 36V 86010670 WASHER, 5/16 X .75 X .04 FLT SS 86276780 SCREW, 5/16-18 X .75 HHCS SS 86062550 COVER, FRONT, 36V, GRY 86377890 KNOB, 1.36"...
Cover (Top) & Tank Mount SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86062560 COVER, TOP, 36V, GRY 86271840 NUT, 5/16-18 HEXTHIN NYLOCK SS 86010670 WASHER, 5/16 X .75 X .04 FLT SS 86239650 HINGE, COVER TO TANK 36V 86276780 SCREW, 5/16-18 X .75 HHCS SS 86069840 BRKT, TANK LEFT 36V 86069850...
Page 47
Lift Handle SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86082910 PLATE LEVER NOTCH DELUXE 36V 86010670 WASHER, 5/16 X .75 X .04 FLT SS 86276780 SCREW, 5/16-18 X .75 HHCS SS 86066860 BAR, SQG LIFT SWING 36V 86006930 SCREW, 5/16-18 X 1 SCHBTNHCS SS 86238360 GRIP, 3/16 X 1.0 ORANGE 86259400...
Page 49
Lift Handle Linkage SERIAL NO. REF PART NO. DESCRIPTION NOTES FROM 86069830 BRKT, LEVER, PIVOT BOTTOM 36V 86238430 GROMMET 1.00 ID 3/16 GRIP 86276920 SCREW, 3/8-16 X 1 HHCS SS NP 86276780 SCREW, 5/16-18 X .75 HHCS SS 86010670 WASHER, 5/16 X .75 X .04 FLT SS 86082890 PLATE, PIVOT TOP 86228840...
Page 51
Recovery Tank SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86274220 SCREW, 6-32 X .625 PHPNHMS SS 86003340 DOME, 13 X 11 86003990 GASKET, DOME 86246080 LANYARD, 18.0 W/LOOP & EYE 86014810 NUT, 6-32 ACORN SS 86032560 TANK REC, 36V,GRY 86276290 SCREW, 10 X .75 PHPNHMS BLK ZNPLT 86001190 BRKT, RECOVERY HOSE MTG...
Page 55
Scrub Deck Aqua-Mizer SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86006930 SCREW, 5/16-18 X 1 SCHBTNHCS SS 86228840 BUSHING, .314 X .502 X .5 FLG 86259420 WASHER, .510 X 1 X .093 THR 86259400 WASHER, .510 X 1 THR 86255060 SPRING, EXT .43D X2.50L X.047W 86249590 PLATE, AQ LOCK LEFT 16 IN...
Page 57
Scrub Deck Motors SERIAL PART NO. DESCRIPTION NOTES NO. FROM 86005340 MOTOR 36VDC 200RPM 3/4HP GEAR 86001890 BRUSH SET, 53632 ASI SERVICE ONLY 86002830 CABLE TIE, .375 X 24.7 86010790 WASHER, 3/8 X .680 X .094 SPL STL ZNPLT 86276970 SCREW, 3/8-16 X .75 HHCS SS 86007020 SCREW, 5/16-18 X 1.25 HHCS SS NP...
Page 59
Scrub Deck Skirt SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86006930 SCREW, 5/16-18 X 1 SCHBTNHCS SS 86070050 BRKT, SHROUD RETAINER LEFT 86271900 NUT, 10-24 HEXTHIN NYLOCK SS (1*) 86010650 WASHER, 10 X .562 X .032 FLT STL PSVT 86062960 SHROUD, SCRUB DECK 32 IN LEFT 86277110 SCREW, 10-24 X .75 PHPNHMS SS...
Page 61
Scrub Deck Lift Linkage SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86069860 BRKT, CENTER LINK 36V 86228840 BUSHING, .314 X .502 X .5 FLG 86259400 WASHER, .510 X 1 THR 86271840 NUT, 5/16-18 HEXTHIN NYLOCK SS 86010670 WASHER, 5/16 X .75 X .04 FLT SS 86276780 SCREW, 5/16-18 X .75 HHCS SS 86271870...
Page 63
Scrub Deck Lift Linkage SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86273780 SCREW, 1/4-20 X .75 HHCS SS NP 86070030 BRKT, ANGLE SUPPORT 36V 86010630 WASHER, 1/4 X .625 FLT SS 86273740 SCREW, 1/4-20 X 1.5 HHCS SS 86271870 NUT, 1/4-20 HEXTHIN NYLOCK SS 86228920 BUSHING, .252 X .503 X 1 BRZ 86259400...
Page 65
Scrub Deck Lift SERIAL NO. REF PART NO. DESCRIPTION NOTES FROM 86276920 SCREW, 3/8-16 X 1 HHCS SS NP 86070090 BRKT, SOLUTION FILL 36V 86069800 BRKT, ACTUATOR, BACK 36V 86069810 BRKT, ACTUATOR, FRONT 36V 86272410 PIN, CLEVIS 3/8 X 1.625 STL ZNPLT 86277010 SCREW, 3/8-16 X 7 HHCS SS 86068130...
Page 75
BRKT, VACUUM MOUNT, 36V 86005450 VAC MOTOR ASM, 36VDC 3 STAGE 86230800 BRUSH SET, 36V 3ST VAC AMETEK SERVICE ONLY 86326980 BRUSH SET 24/36V VAC WINDSOR SERVICE ONLY 86010630 WASHER, 1/4 X .625 FLT SS 86273810 SCREW, 1/4-20 X 1 HHCS SS 86091170 TUBE, 2.0 OD X 1.0L...
Page 79
Wiring-Battery SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86008760 CONNECTOR 175 DCA GRY W/O TERMS 86271870 NUT, 1/4-20 HEXTHIN NYLOCK SS 86271910 NUT, 5/16-18 FLEX LK STL GRA CDPLT 86008920 BOOT, RUBBER TERM. ISOLATOR 86009000 WIRE, 4 X 9.5 BK 5/16 RING X 5/16 RING 86010850 WIRE, 4X20RD CTERM X 5/16RING 86010860...
Wiring Group-Control Panel DIAGRAM B DIAGRAM A 51 RED 30 RED 49 BLK 56 RED 18 BLU 48 BLK 52 RED 47 RED 41 BLU 29 YLW 50 BLK 43 BLK 63 BLK 62 RED 63 BLK 26 RED 61 BLK 2/25 BLK 33 RED 28 WHT...
Page 81
Wiring Group-Control Panel PART NO. DESCRIPTION SERIAL NO. FROM NOTES 86238990 HARNESS, PANEL, DELUXE 86261210 DIODE ASM, 76008 X 76008 86003410 DIODE ASM, 76075 X 76075 86267340 WIRE, 22" RED/18 76040 X 76075 86269300 WIRE, 16" RED/18 STRIP X STRIP 86267360 WIRE, 14"...
Wiring Group-Main Harness 74 RED RIGHT BRUSH MOTOR 75 BLK 76 RED LEFT BRUSH MOTOR 77 BLK 72 RED MOTOR 73 BLK 5 BRN DIAGRAM A 73 BLK 6 BLK ACTUATOR 75 BLK 78 RED 79 BLK 76 RED 72 RED 69 RED 77 BLK 74 RED...
Page 83
Wiring Group-Main Harness SERIAL NO. PART NO. DESCRIPTION NOTES FROM 86238980 HARNESS, MAIN 86260400 WIRE ASM, REV POLARITY JUMPER SERVICE ONLY 86039100 CUTTER 36V...
BLADE AQ LEFT 16 INCH 86001420 BLADE AQ RIGHT 16 INCH 86004860 KEY, SWITCH 86007530 SKIRT 32 INCH LEFT 86007540 SKIRT 32 INCH RIGHT 86230800 BRUSH SET, 36V 3ST VAC AMETEK 86326980 BRUSH SET 24/36V VAC WINDSOR 86039100 CUTTER 36V...
Need help?
Do you have a question about the Saber Cutter SCX326 and is the answer not in the manual?
Questions and answers