PIONEER Also test with Service Manual. A subscription to, or additional copies plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used. L 13942296513 u163 XW-HTD640 http://www.xiaoyu163.com...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING SECTION Transmitter L 13942296513 Wireless Speaker u163 XW-HTD640 http://www.xiaoyu163.com...
Page 7
AHG1180 > AC Power Cord ADG7021 • • • • • • • • Polyethylene Bag VHL1051 Packing Sheet (large) AHG7010 Pad L AHA7430 Pad R AHA7431 Packing Case AHD8288 NSP 13 Warranty Card ARY7045 L 13942296513 u163 XW-HTD640 http://www.xiaoyu163.com...
3.4 MAIN, POWER, OP, PRI and SW ASSYS 3 7 63 1515 0 CN3301 CN3303 CN3302 L 13942296513 POWER ASSY (AWU8230) POWER TRANSFORMER ATS7366 POWER CORD ADG7021 SW ASSY (AWU8233) u163 REK1110 1.6A • NOTE FOR FUSE REPLACEMENT CAUTION PRI ASSY (AWU8234) B C F XW-HTD640 http://www.xiaoyu163.com...
Page 21
3 7 63 1515 0 : AUDIO SIGNAL ROUTE (L ch) MAIN ASSY (AWU8229) L 13942296513 OP ASSY (AWU8231) Switches u163 S5901 : SURROUND/STEREO S5902 : Ch.select : The power supply is shown with the marked box. XW-HTD640 http://www.xiaoyu163.com...
Page 23
3 7 63 1515 0 : The power supply is shown with the marked box. : AUDIO SIGNAL ROUTE (L ch) AMP ASSY (AWU7968) CN3306 L 13942296513 CN3304 u163 XW-HTD640 http://www.xiaoyu163.com...
Page 29
3 7 63 1515 0 1/3,2/3 DTL1067 DTL1067 IC23 L 13942296513 DTL1067 u163 : The power supply is shown with the marked box. XW-HTD640 http://www.xiaoyu163.com...
V : 2V/div. H : 10µsec/div. V : 2V/div. H : 10µsec/div. IC9-Pin12 IC28-Pin1 V : 2V/div. H : 200nsec/div. V : 2V/div. H : 200nsec/div. L 13942296513 IC9-Pin9 IC28-Pin2 V : 2V/div. H : 1µsec/div. V : 2V/div. H : 2µsec/div. u163 XW-HTD640 http://www.xiaoyu163.com...
Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B P.C.Board Chip Part transistor Resistor array 3-terminal regulator L 13942296513 u163 XW-HTD640 http://www.xiaoyu163.com...
SIDE A SIDE A TX ASSY CN8201 (ANP7509-A) L 13942296513 SIDE B SIDE B TX ASSY CN8201 CN8201 TX ASSY PNE-1B1 IC8101 Q8504 Q8504 Q8503 Q8106 Q8505 Q8503 Q8506 Q8505 Q8502 Q8501 Q8502 Q8501 IC8501 u163 IC8501 (ANP7509-A) XW-HTD640 http://www.xiaoyu163.com...
SW ASSY OP ASSY AWU8231 W171 AWU8236 S5901 W170 W111 GNDA W110 VR3051 W109 PNE-1B1 OP ASSY POWER TUNED CN3052 CN3052 (ANP7509-A) (ANP7509-A) CN3051 L 13942296513 SIDE B SIDE B OP ASSY SW ASSY CN3052 (ANP7509-A) u163 (ANP7509-A) XW-HTD640 http://www.xiaoyu163.com...
V POWER ASSY TRANS. PRIMARY CAUTION AC IN REPLACE WITH SAME TYPE AND RATINGS OF FUSE. tekan tekan PRI ASSY AWU8232 u163 W169 AWU8234 W168 ATTENTION REMPLACER PAR LE FUSIBLE PAR UN MODELE IDENTIQUE EN INTENSITE PNE-1B1 (ANP7509-A) XW-HTD640 http://www.xiaoyu163.com...
Page 45
3 7 63 1515 0 SIDE B SIDE B CN12 POWER CN12 ASSY VDET CN11 POWER ASSY PNE-1B1 L 13942296513 (ANP7509-A) ASSY LIVE PRIMARY NEUTRAL PNE-1B1 PRI ASSY u163 (ANP7509-A) XW-HTD640 http://www.xiaoyu163.com...
*The AXX7198 on TX MODULE/RX MODULE is a service 3 7 63 1515 0 part containing two EEPROMs,both of which must be re- placed when either needs to be replaced. 6. ADJUSTMENT There is no information to be shown in this chapter. L 13942296513 u163 XW-HTD640 http://www.xiaoyu163.com...
In a case in which no sound is output from the AMP module the test terminals in the module. Besides the failure in the POWER IC, activation of the MUTE function is possible. Check that Pin 6 of CN3304 is "L" and that Pin 4 of CN3304 is "H." XW-HTD640 http://www.xiaoyu163.com...
You can diagnose the amplifier section even if the transmitter section is not available. Input audio signals to the Jumper Wire for service use indicated below. At that time remove the RX MODULE. L 13942296513 Jumper Wire for service for signal input MAIN ASSY SIDE A W195 W194 W193 u163 XW-HTD640 http://www.xiaoyu163.com...
Therefore, Q3654 maintains the OFF state. In the short or open state: The voltage appears at D3664 anode in the short state and appears at D3665 anode in the open state. Q3654 turns ON and XPROTECT becomes low (Active). u163 XW-HTD640 http://www.xiaoyu163.com...
Page 60
Note: When the protection function is activated, as the POWER LED is turned off and the fan does not rotate, it appears as if the power was just shut off. When diagnosing, you can differentiate protection status from power-off status by checking if +8 V power to the FET in the AMP module is on or not. u163 XW-HTD640 http://www.xiaoyu163.com...
Rear view Remove the two screws. Disconnect the one flexible cable. Remove the grille assy. Remove the control panel section. Grille assy. Control panel section L 13942296513 CN3052 Remove the two screws. Control panel section Front panel u163 XW-HTD640 http://www.xiaoyu163.com...
Page 62
CN3701 Remove the three screws. Remove the speaker cable from top barrier. Disconnect the speaker connector. Remove the antenna. Pull out the chassis section. L 13942296513 Chassis section Antenna RX module Top barrier Speaker connector Chassis section u163 XW-HTD640 http://www.xiaoyu163.com...
Page 63
Fans Cleaning paper : GED-008 ULE. (Refer to 7.1.3 DIAGNOSIS FOR AMP SECTION) AMP Module L-2CH MAIN Assy CN3305 CN3306 CN3304 CN3301 REGULATOR Assy CN3303 Connect the jig cable (GGD1335). CN3302 Jig Cable (GGD1335) AMP Assy u163 Diagnosis XW-HTD640 http://www.xiaoyu163.com...
Page 64
− − – − – – − l a i l a i L " : " L " : " " , " L " : " – " , : " – l l u u163 XW-HTD640 http://www.xiaoyu163.com...
Page 65
System Clock System Clock Power Supply Zero Detect Manager L 13942296513 Pin layout Pin function TOP VIEW − − , y l DATA − , y l LRCK DGND PCM1742 − ZEROL/NA − n i l ZEROR/ZEROA AGND u163 XW-HTD640 http://www.xiaoyu163.com...
Page 67
Serial Data Output from Serial EEPROM EEPROM Serial Output Serial Data Input to Serial EEPROM EEPROM Serial Output Serial Clock Input to Serial EEPROM EEPROM Serial Output Chip Select to Serial EEPROM EEPROM (active low) Ground Ground u163 XW-HTD640 http://www.xiaoyu163.com...
Page 68
ADC-MCLK (12.288 MHz) Ground Ground SCLK Output ADC-SCLK (3.072 MHz) AUDIOSTATUS System Output Audio Status Indicate, 0 => Low level audio or no audio Tri-State => Audio present u163 Open Drain Output CHANNELBIT1 System Output Channel Number Bit 1 XW-HTD640 http://www.xiaoyu163.com...
DVD receiver do not match, loud noise may be output from the wireless speaker system. ¶ The STEREO MODE VOLUME control can u163 be used to adjust the volume when W.STEREO is selected. XW-HTD640 http://www.xiaoyu163.com...
Page 74
7 Jigs list 3 7 63 1515 0 Name Jig No. Remarks Jig Cable GGD1335 diagnosis L 13942296513 u163 XW-HTD640 http://www.xiaoyu163.com...