Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Nilfisk-ALTO NEPTUNE SB
Summary of Contents for Nilfisk-ALTO NEPTUNE SB
-
Page 1: Operating Instructions
Operating instructions NEPTUNE SB 301002177 B... - Page 2 NEPTUNE SB...
-
Page 3: Table Of Contents
Set the brake ................7 Install Crank handle for high pressure hose reel/cord reel ...8 Fill up detergent tanks ............8 Fill up tank for Nilfisk-ALTO AntiStone (Anti-Scale) ....8 Antiscale ................8 Fill up fuel tank ..............9 Connecting the high pressure hose ........9 Connecting the water supply ..........10... -
Page 4: Important Safety Instructions
NEPTUNE SB Safety instruc- Symbols used to mark This indicates tips and tions in these op- instructions to simplify instructions erating instruc- work and to en sure tions which must safe operation. be observed to prevent risks to persons are marked with this danger symbol. - Page 5 NEPTUNE SB Do not damage the power cord CAUTION! Never operate the cleaner with- (e.g. by driving over it, pulling or High-pressure water jets can out water. Even brief shortages of crushing it). water result in severe damage to be dangerous if misused. The Disconnect the power cord by the pump seals.
-
Page 6: Purpose
NEPTUNE SB fications to the high-pressure ance, the insulation resistance Do not touch, cover or place cleaner. and the leakage current must hose or cord over the chimney. be measured. Furthermore, a Danger for persons, risk of Ensure that the machine is regu- visual inspection of the mains overheating and fi... -
Page 7: Operating Elements
NEPTUNE SB See page at front of these 17. Detergent metering knob Operating elements operating instructions. 18. Pressure gauge 19. Power ON 1. Spray lance 20. Castor with parking brake 2. Cylinder lock 21. Water supply connection 3. Cover for control panel 22. -
Page 8: Install Crank Handle For High Pressure Hose Reel/Cord Reel
For compatibility reasons, use only the tested Nilfisk-ALTO AntiStone (Anti-Scale) which is available as a six-pack of 1 liter bottles by ordering part number 8466. -
Page 9: Fill Up Fuel Tank
• Maximum storage time in high pressure cleaner diesel tank: 1 month. • Diesel stored externally for more than 6 months is not allowed to be filled into Nilfisk-ALTO high pressure cleaners. • Diesel EN 590 is not recommended for use in HPW's at an ambient temperature below 0°C. -
Page 10: Connecting The Water Supply
NEPTUNE SB 1. Attach quick connect adapter Connecting the water found with Owners Manual to supply the water supply hose. NOTE! 2. Rinse the water supply hose See Technical Data for required briefl y in order to prevent sand quantity of water and water pres- an other dirt particles entering sure. -
Page 11: Connections
NEPTUNE SB 4 Control / Operation Connections 1. Pull the blue quick-release grip (A) of the spray gun back- 4.1.1 Connecting the spray wards. lance to the spray gun 2. Insert the nipple of the spray NOTE! lance (B) into the quick-re-... -
Page 12: Self-Service Mode
NEPTUNE SB Mode Setting Note Manual mode is activated, while the switch SB Manual is not set to mode position ON. The switch HW may be set to any position. Self-service mode Cold water Self-service mode Hot water 0 0 0 4 3 2... - Page 13 NEPTUNE SB 4.3.1 Daily tasks 1. Empty coin box. Check coin box for correct mounting position (see ar- rowhead mark). 2. Read off counter for coins (F): Display shows the number of coins inserted. 3. Check niveau of consuma- bles: •...
-
Page 14: Manual Mode
NEPTUNE SB Manual mode 1. Turn the main switch to posi- 4.4.1 Cold water operation / tion (cold water). Hot water operation (up to 100°C) Control electronics accomplishes a self check. The Display shows for approx. 1 second „---“. The motor starts. -
Page 15: Techniques
NEPTUNE SB 5 Applications and methods Techniques Effi cient high pressure cleaning is achieved by following a few guide- lines, combined with your own personal experience of specifi c clean- ing tasks. Accessories and detergents, when correctly chosen, can increase the effi ciency of your pressure washer. Here is some basic information about cleaning. -
Page 16: Some Typical Cleaning Tasks
NEPTUNE SB Some typical cleaning tasks 5.2.1 Agriculture Task Accessories Method Stables Chemical Foam Injec- 1. Soaking – apply foam to all surfaces (bottom to top) Pig Pens, Sties tors and wait for approx. 30 minutes. Foam lance 2. Remove the dirt from surfaces with the high pressure... - Page 17 NEPTUNE SB 5.2.3 Buildings and Equipment Task Accessories Method General surfaces Foam injectors Stand- 1. Apply thick foam over the surfaces to be cleaned. Apply ard lance on dry surfaces. Apply from top to bottom on vertical Metallic equipment Curved lances surfaces.
-
Page 18: Switching Off The Cleaner
NEPTUNE SB 6 After using the cleaner Switching off the 1. Turn the main switch to posi- cleaner tion „OFF“. 2. Turn off water supply at faucet. 3. Squeeze the spray gun trigger until the pressure has bled off. 4. Slide trigger lock to the locked position. -
Page 19: Maintenance Schedule
NEPTUNE SB 7 Maintenance Maintenance Schedule Every six After the fi rst 50 months or Weekly operating hours 500 operating required hours 7.2.1 Water fi lters 7.2.2 Oil fi lter 7.2.3 Checking the pump oil quality ... - Page 20 NEPTUNE SB 7.2.3 Checking the pump oil 1. Check color of pump oil. If the oil has a grey or white quality shade, change the oil (see chapter 7.2.4) 2. Top off oil level with fresh oil if necessary. Oil type see Technical Data.
-
Page 21: Indications On Display
NEPTUNE SB 8 Troubleshooting Indications on Display Indication Cause Remedy on Display Contact Nilfi sk-ALTO Service > Flow sensor fault Cold water operation possible > Water supply turned off or inadequate supply • Required volume fl ow and pressure see to machine chapter 9.4 Technical Data... -
Page 22: Indication Lights On Control Panel
NEPTUNE SB Indication lights on control panel Indication light Cause Remedy see FLO see FLO > • fl ashing > Low fuel level • Fill fuel tank Cold water operation possible > Low Nilfi sk-ALTO AntiStone • Fill Nilfi sk-ALTO AntiStone (Anti-... -
Page 23: Recycling The Cleaner
Inc. original spare parts The guarantee is invalidated if the and/or accessories. machine is not operated in ac- The burner coil on all Nilfisk-ALTO cordance with these instructions Cleaning Systems, Inc. hot water/ or otherwise abused. The guaran- steam cleaners is under warranty... -
Page 24: Eu Declaration Of Conformity
NEPTUNE SB EU Declaration of Conformity EU Declaration of Conformity Product: High Pressure Washer Type: NEPTUNE SB Description: 400 V 3~ 50 Hz IPX5, 400/230 V 3~ 50Hz IPX5, 230-240 V 1~ 50Hz IPX5 The design of the unit corre sponds to... - Page 25 HEAD QUARTER HOLLAND PORTUGAL DENMARK Nilfi sk-Advance B.V. Nilfi sk-Advance, Lda. Nilfi sk-Advance A/S Versterkerstraat 5 Sintra Business Park Sognevej 25 1322 AN ALMERE Zona Industrial Da Abrunheira DK-2605 Brøndby www.nilfi sk.nl Edifi cio 1, 1o A Tel.: (+45) 4323 8100 Sintra, P-2710-089 www.nilfi...