Door Glass Replacement; Screen Replacement - Napoleon NZ7000 Installation And Operating Instructions Manual

26
6.3

DOOR GLASS REPLACEMENT

EN
CARE MUST BE TAKEN WHEN REMOVING AND DISPOSING OF ANY BROKEN DOOR GLASS OR
DAMAGED COMPONENTS. BE SURE TO VACUUM UP ANY BROKEN GLASS FROM INSIDE THE
DO NOT STRIKE, SLAM OR SCRATCH GLASS. DO NOT OPERATE APPLIANCE WITH GLASS
A. Lift the screen up into the appliance.
B. Lower the glass door down and unlatch. Swing
the glass door open.
C. Remove the 5 top and bottom retainer screws
securing the glass in place.
D. Replace the glass and retainers. Reverse to
reinstall.
6.4

SCREEN REPLACEMENT

WARNING: Risk of injury! Removing the screen will result in the counter weight to be out of balance,
this will cause the screen door to immediately rise after the frame is removed.
NOTE: It is recommended to have two people assist in removing the screen frame from the appliance.
A. Insert the handle and lift the screen slightly up to
remove the 2 screws on the bottom inside of the
screen frame, see Figure 1.
B. Removing the screen will result in the screen door
immediately rising, use caution. It is recommended to
have another person assist in holding the screen door
while the screen frame is removed.
C. Remove the 10 top and bottom screws and the 6 side
screws, see Figure 2.
D. Remove the screen from the frame and replace.
E. Reverse these steps to reinstall the screen frame onto the
appliance.
F. If the screen door becomes unbalanced, refer to the
"COUNTER WEIGHT ADJUSTMENT" section.
NOTE: Do not leave the doors slightly open. Ensure your
counter weights are balanced and the doors close properly.
FIG 2:
W415-1277 / 08.12.15
!
DO NOT USE SUBSTITUTE MATERIALS.
GLASS MAY BE HOT, DO NOT TOUCH GLASS UNTIL COOLED.
APPLIANCE BEFORE OPERATION.
REMOVED, CRACKED, BROKEN OR SCRATCHED.
WARNING
FIG 1: