Bajaj Pulsar 150 CC DTS-i User Manual page 14

Periodic Maintenance & Lubrication Chart
Sr.
Operation
Servicing
No.
Kms
16. Throttle grip play C, A C, A
17. Rear brake pedal free play C, A C, A
18. Brake lining or pad wear CL, R
19. Brake fluid level / Top up / Replace C, A, R C, A
20. Master cylinder cup and dust seal R
21. Caliper piston seal and dust seal R
22. Brake hose pipe C, R
23. Brake cam & pedal pivot pin L
24. Steering play C, A C, A
25. Steering stem bearing C, L, R
26. All fasteners tightness C, T C, T
27. Rear sprocket fasteners C, T C, T
28. Rear wheel rubber shock damper C, R
29. Silencer drain hole cleaning CL
30. Cylinder head de-carbonising,
valve lapping & Replace valve oil seals CL
31. Engine air breather tube R
32. Drive chain slackness adjustment C, A, L C,A,L C,A,L C,A,L C,A,L C,A,L C,A,L C,A,L Lubricate at every 500km
& lubrication
RECOMMENDED FREQUENCY
1st 2nd 3rd 4th 5th 6th 7th
750 5000 10000 15000 20000 25000 30000
C, A C, A C, A C, A C, A C, A
C, A C, A C, A C, A C, A C, A
CL CL CL, R CL CL CL, R Replace at every 15000km
C, A C, A C, A C, A C, A R Replace at every 30000km
R Replace at every 30000km
R Replace at every 30000km
C, R Replace at every 30000km
L L
C, A C, A C, A C, A C, A C, A
C,L,R C,L,R C,L,R
C, T C, T C, T C, T C, T C, T
C, T C, T C, T C, T C, T C, T
C, R C, R C, R Replace at every 10000km
CL CL CL CL CL CL CL Clean at every 5000km
CL CL Clean at every 15000km
R Replace at every 20000km
A-slackness whenever reqd.
23
Periodic Maintenance & Lubrication Chart
Sr.
Operation
Servicing
No.
Kms
33. Drive chain 'O' ring type (If applicable) L
34. Drive chain remove, clean, inspect'
& lubricate (O/H) CL, L
35. Drive chain link lock R
36. Wheel brg (for non sealed brgs only) C, L
37. Tyre tread wear C, R
38. Front fork oil R
39. Auto choke, Thermal sensor (If appli.) C, A
40. TPS (If applicable) C, A
41. RSA - Check gas pressure (If applicable) C, A
42. Starter clutch bush kit (If applicable) CL, R
43. Clutch switch cleaning (If applicable) CL
44. General lubrication L
45. Swing arm pivot pin lubrication L
46. Eng foundation silent bush (If applicable) R
C : Check, A : Adjust, CL : Clean, R : Replace, T : Tighten, L : Lubricate
* It is strongly recommended to use only "Bajaj DTS-i 10000" Genuine engine oil. In case any other engine oil of same specifications is used, the
frequency of Sr. No. 4, 5 & 6 will be every 5000 Kms.
Note : Periodic parts / lubricants to be replaced as per Periodic Maintenance and Lubrication Chart are mandatory and the same are chargeable to customer.
RECOMMENDED FREQUENCY
1st 2nd 3rd 4th 5th 6th 7th
750 5000 10000 15000 20000 25000 30000
At every 500 Kms
CL, L CL, L CL, L At every 10000km
R R R Replace at every 10000km
C, L At every 20000km
C, R C, R C, R C, R C, R At every 5000kms i.e. at
every service after 2nd ser.
R Replace at every 20000km
C, A C, A C, A C, A C, A C, A C, A At every 5000km
C, A C, A C, A C, A C, A C, A C, A C, A At every 5000km
C, A C, A At every 20000km
CL, R CL,R (If applicable)
CL CL CL
L L L L L L L
L Lubricate at every 20000km
R R Replace at every 15000km
24