Rainy Season Care; Daily Safety Checks - Bajaj Pulsar 150 CC DTS-i User Manual

General Maintenance Information
Front Brake Fluid Level
• Front brake fluid master cylinder reservoir is
located near RH switch on handle bar.
• To check oil level, keep the vehicle on Center
stand with handle bar in straight ahead
position.
• Always ensure that brake fluid level is above
'MIN' mark given on inspection window.
• Use only DOT 3 or DOT 4 or equivalent brake
fluid (from sealed container) to top up if reqd.
It is advisable that brake fluid should be
replenished at every 30,000 Km or once in two
years whichever occurs earlier.

Rainy Season Care :

• It is suggested to customer to take
appropriate care in area of high rainfall
area. The appropriate surface preventive
coat to avoid rusting/poor surface finish on
account of adverse atmospheric conditions.
• Vehicle cleaning to be done with soft &
clean wet cloth to avoid scratches on
painted parts.
• Clean & lubricate all the important parts as
detailed in a periodic maintenance chart.
• Do not apply direct water jet on painted,
electrical / electronic parts.
• Do not obstruct engine cooling by adding
mud protection sheet from front.
19

Daily Safety Checks

Before riding the motorcycle be sure to check
the following items. Please give proper
importance to these checks and perform all of
them before riding the motorcycle. If any
irregularities are found during these checks,
refer to the Maintenance chapter and see
Authorised Dealer / Service center for the
action required to return the motorcycle to a
safe operating condition.
WARNING : Failure to perform these
checks every day before you ride may
result in serious damage or severe
accident.
What to check Check for
Fuel Enough fuel for the planned distance of
operation, no leaks in the fuel lines.
Engine Oil Oil level between upper & lower marks.
Throttle 1. Correct play in the throttle cable (2 to
3 mm)
2. Smooth operation & positive return
of throttle grip to the closed position.
What to check Check for
Steering Lock Correct operation.
Brakes 1. Correct pedal play (25~30 mm).
2. Brake lining wear indicator within
'USABLE RANGE'.
3. No dragging.
Drive chain 1. Proper slack (25~35 mm).
2. Adequate lubrication.
Lighting Operation of all lights.
Horn Correct functions.
Steering 1. Smoothness.
2. No restriction of movement.
3. Not Loose / Tight.
Clutch 1. Correct lever play. (2 to 3 mm).
2. Smooth operation of lever.
Side and Return to their fully up position.
Center Stand
Tyres 1. Correct pressure.
2. Adequate tread depth.
3. No cracks or cuts.
Mirrors Correct position.
20