Gas Heat - York PCG4 Series Installation Manual

Refrigerant Charge and Metering Device
R-410A R-22
TXV Fixed Orifice
TXV# / Orifice size

Gas Heat

Single Stage Two Stage
LP Gas Conversion Kit #
Manifold Pressure at 100% Firing Rate (w.c.")
Manifold Pressure / Low Fire Rate (w.c.")
Burner Flame Inspection - Blue flames extending directly into the primary heat exchanger cells
Clean Up Job Site
Job site has been cleaned, indoor and outdoor debris removed from job site
Tools have been removed from unit
All panels have been installed
Unit Operation and Cycle Test
Operate the unit through continuous fan cycles from the thermostat, noting and correcting any problems
Operate the unit through cooling cycles from the thermostat, noting and correcting any problems
Owner Education
Provide owner with the owner's manual
Explain operation of system to equipment owner
Explain thermostat use and programming (if applicable) to owner
Explain the importance of regular filter replacement and equipment maintenance
Comments and Additional Job Details
Subject to change without notice. Published in U.S.A.
Copyright © 2015 by Johnson Controls, Inc. All rights reserved.
Data plate - lbs / Oz
Discharge line
temperature
Natural Gas Propane LP (Requires LP Conversion Kit)
LP Conversion Kit Installed By
Measured BTU/H (Clock Gas Meter Nat Gas)
Return Air Dry Bulb Temp
York International Corp.
5005 York Drive
Norman, OK 73069
Suction line temperature
Suction pressure
Superheat
Supply Air Dry Bulb Temp
Discharge pressure
Liquid line temperature
Subcooling
Inlet Gas Pressure (w.c.")
Rated BTU/H
Temp Rise
1183746-UIM-B-0215
Supersedes: 1183746-UIM-A-0215