Rating Plate Information; Venting - Napoleon BGD42CFN Installation And Operating Instructions Manual

2.4

RATING PLATE INFORMATION

INSTALLER: It is your responsibility to check off the appropriate box on the rating plate according to
the model, venting and gas type of the appliance.
For rating plate location, see “"INSTALLATION OVERVIEW”" section.
This illustration is for reference only. Refer to the rating plate on the appliance for accurate information.
DIRECT VENT GAS FIREPLACE. APPROVED FOR BEDROOM, BATHROOM AND BED-SITTING ROOM
INSTALLATION. SUITABLE FOR MOBILE HOME INSTALLATION IF INSTALLED IN ACCORDANCE WITH
THE CURRENT STANDARD CAN/CSA Z240MH SERIES GAS EQUIPPED MOBILE HOMES, IN
CANADA OR IN THE UNITED STATES THE MANUFACTURED HOME CONSTRUCTION AND
SAFETY STANDARD, TITLE 24 CFR, PART 3280.
APPLICABLE USE THE STANDARD FOR FIRE SAFETY CRITERIA FOR MANUFACTURED HOME
INSTALLATIONS, SITES AND COMMUNITIES, ANSI / NFPA 501A.
SCREEN KIT
REQUIREMENT CR95-006.
NOT FOR USE WITH SOLID FUEL. FOR USE WITH GLASS
DOORS CERTIFIED WITH THIS UNIT ONLY.
WARNING:
REPLACE ONLY WITH A FAST ACTING THERMOCOUPLE SUPPLIED BY WOLF STEEL LTD. DO NOT
ADD ANY MATERIAL TO THE APPLIANCE, WHICH WILL COME IN CONTACT WITH THE FLAMES,
OTHER THAN THAT SUPPLIED BY THE MANUFACTURER WITH THE APPLIANCE.
MINIMUM CLEARANCE TO COMBUSTIBLE MATERIALS /
DEGAGEMENTS MINIMAUX DES MATERIAUX COMBUSTIBLES:
TOP/ DESSUS
FLOOR / PLANCHER
SIDES / COTES
BACK / ARRIERE
MANTEL / MANTEAU
* MAXIMUM HORIZONTAL EXTENSION / L'EXTENSION HORIZONTALE MAXIMALE: 2".
TOP, SIDES & BACK: PER STAND OFF SPACES FOR FRAMING MATERIALS. FOR FINISHING MATERIALS
SEE OWNERS MANUAL. SEE INSTRUCTION MANUAL FOR GREATER EXTENSIONS. REFERER AU MANUEL
D'INSTRUCTION POUR DES EXTENSIONS PLUS GRANDES. SEE OWNER'S INSTRUCTION MANUAL FOR
MINIMUM AND MAXIMUM VENT LENGTHS. REFERER AU MANUEL D'INSTALLATION DE
PROPRIETAIRE POUR LES LONGUEURS L'EVACUATION MINIMALE ET MINIMALE.
WOLF STEEL LTD.
24 NAPOLEON ROAD, BARRIE, ON, L4M 0G8 CANADA
NOTE: The rating plate must remain with the appliance at all times. It must not be removed.

3.0 VENTING

RISK OF FIRE, MAINTAIN SPECIFIED AIR SPACE CLEARANCES TO VENT PIPE AND APPLIANCE.
IF VENTING IS INCLUDED WITH SPACERS THE VENT SYSTEM MUST BE SUPPORTED EVERY 3 FEET
FOR BOTH VERTICAL AND HORIZONTAL RUNS. USE SUPPORTS OR EQUIVALENT
NON-COMBUSTIBLE STRAPPING TO MAINTAIN THE REQUIRED CLEARANCE FROM
COMBUSTIBLES. USE WOLF STEEL LTD. SUPPORT RING ASSEMBLY W010-0370 OR EQUIVALENT
NON-COMBUSTIBLE STRAPPING TO MAINTAIN THE MINIMUM CLEARANCE TO COMBUSTIBLES
FOR BOTH VERTICAL AND HORIZONTAL RUNS. SPACERS ARE ATTACHED TO THE INNER PIPE AT
PREDETERMINED INTERVALS TO MAINTAIN AN EVEN AIR GAP TO THE OUTER PIPE. THIS GAP IS
REQUIRED FOR SAFE OPERATION. A SPACER IS REQUIRED AT THE START, MIDDLE AND END OF
EACH ELBOW TO ENSURE THIS GAP IS MAINTAINED. THESE SPACERS MUST NOT BE REMOVED.
THIS APPLIANCE USES A 5" EXHAUST / 8" AIR INTAKE VENT PIPE SYSTEM.
For safe and proper operation of the appliance follow the venting instruction exactly. Deviation from the
minimum vertical vent length can create dif culty in burner start-up and/or carboning. Under extreme vent
con gurations, allow several minutes (5-15) for the  ame to stabilize after ignition. Provide a means for
visually checking the vent connection to the appliance after the appliance is installed. Use a  restop, vent pipe
shield or attic insulation shield when penetrating interior walls,  oor or ceiling.
NOTE: If for any reason the vent air intake system is disassembled; reinstall per the instructions
provided for the initial installation.
NOTE: This appliance must be installed with a continuous connection of exhaust and air intake vent
pipes. Utilizing alternate constructions such as a chimney as part of the vent system is not permitted.
CERTIFIED UNDER / HOMOLOGUE SELON LES NORMES: CSA 2.22b-2009, ANSI Z21.50b-2009 VENTED GAS FIREPLACE / FOYER AU GAZ AVEC EVACUATION
WHEN THIS US STANDARD IS NOT
WHEN INSTALLED WITH
GD-565KT, THE FIREPLACE COMPLIES WITH
BGD42CFN BCDV42CFN
0-4500FT (0-1370m)
24,000 BTU/h
17,000 BTU/h
MANIFOLD PRESSURE: 3.5" WATER COLUMN
PRESSION AU COLLECTEUR: 3.5" D'UNE COLONNE D'EAU
MINIMUM SUPPLY PRESSURE: 4.5" WATER COLUMN
PRESSION D'ALIMENTATION MINIMALE: 4.5" D'UNE COLONNE D'EAU
MAXIMUM SUPPLY PRESSURE: 7.0" WATER COLUMN
PRESSION D'ALIMENTATION MAXIMALE: 7.0" D'UNE COLONNE D'EAU
E WITH GLASS E WITH GLASS
LY.
THIS FIREPLACE USES AND REQUIRES A FAST ACTING THERMOCOUPLE. ST ACTING THERMOCOUPLE.
UPPLIED UPPLIE BY WOLF STEE
COME COME IN CONTACT WITH THE FLAMES, IN CONTACT WITH THE FLAMES,
URER WITH THE APPLIANCE. R WITH THE APPL
RIALS /
X COMBUSTIBLES: IBLES:
0 RECESSED DEPTH / PROFONDEUR D'ENCASTRE ESSED DEPTH / PROFONDEUR D'ENCASTRE PROFONDEUR D'ENCASTRE
0 VENT SIDES / COTES DE L'EVENT ENT SIDES / COTES DE L'EVENT ENT SIDES / COTES DE L'EVENT
0 VENT TOP / EVENT SUPERIEUR VENT TOP / EVENT SUPERIEUR VENT TOP / EVENT SUPERIEUR
0 VENT BOTTOM / EVENT INFERIEUR VENT BOTTOM / EVENT INFERIEUR VENT BOTTOM / EVENT INFERIEUR
12" * 12" * 2" *
EXTENSION / L'EXTENSION HORIZONTALE MAXIMALE ENSION / L'EXTENSION HORIZONTALE MA
STAND OFF SPACES FOR FRAMING MATERIALS. F ND OFF SPACES FOR FRAMING MATERIAL
E INSTRUCTION MANUAL FOR GREATER EXT NSTRUCTION MANUAL FOR GREATER EX
XTENSIONS PLUS GRANDES. TENSIONS PLUS GRANDES. SEE OW SEE OWN
M VENT LENGTHS. REFERER AU VENT LENGTHS. REFERE
ES LONGUEURS L'EVACUAT GUEURS L'EVACUA
RIE, ON, L4M 0 IE, ON, L4M 0
Refer to the section applicable to your installation.
FOYER A GAZ VENTILE DIRECT. HOMOLOGUE POUR INSTALLATION DANS UNE CHAMBRE A COUCHER,
UNE SALLE DE BAIN ET UN STUDIO. APPROPRIE POUR INSTALLATION DANS UNE MAISON MOBILE SI SON
INSTALLATION CONFORME AUX EXIGENCES DE LA NORME CAN/CSA Z240MH SERIE DE
MAISONS MOBILES EQUIPEES AU GAZ, EN VIGUEUR AU CANADA OU AUX ETATS-UNIS DE LA
NORME DE SECURITE ET DE CONSTRUCTION DE MAISONS MANUFACTUREES, TITRE 24 CFR,
SECTION 3280. DANS LE CAS OU CETTE NORME D'ETATS-UNIS NE PEUT ETRE APPLIQUEE, SE
REFERER A LA NORME RELATIVE AU CRITERE DE MESURES DE SECURITE CONTRE L'INCENDIE
CGA CERTIFICATION POUR LES INSTALLATIONS DANS LES MAISONS MANUFACTURES, LES SITES ET LES
COMMUNAUTES, ANSI/NFPA 501A.
GD-565KT, LE FOYER EST CONFORME A LA NORME DE CERTIFICATION DE L'ACG CR95-006. T, LE FOYER EST CONFORME A LA NORME DE CERTIFIC , LE FOYER EST CONFORME A LA NORME DE CERTIF
9700539 (WSL) 4001657 (NGZ) 4001657 (NGZ) 57 (NGZ)
4001658 (NAC) 4001659 (WUSA) 4001659 (WUSA) 4001659 (WUSA)
MODEL L
ALTITUDE / ELEVATION ELEVATION LEVATION
INPUT / ALIMENTATION ALIMENTATION LIMENTATION
REDUCED INPUT / ALIMENTATION REDUITE UT / ALIMENTATION REDUITE / ALIMENTATION REDUITE
OLU OLUMN MANIFOLD PRESS MANIFOLD PRESSURE: 10" WATER COLUMN MANIFOLD PRESSURE:
NNE D'EAU NNE D'EA PRESSION AU C PRESSION AU COLLECTEUR: PRESSION AU COLLECTEUR: 10" D'UNE COLONNE D'EAU
ATER COLUMN TER COLUMN MINIMUM SUPPLY PRESSURE: MINIMUM SUPPLY PRESSURE: 11" WATER COLUMN MINIMUM SU
COLONNE D'EAU LONNE D'EAU PRESSION D'ALIMENTATION MINIMALE: 11" D'UNE COLONNE D'EAU PRESSION D PRESSION D'ALIMENTATIO
7.0" WATER COLUMN ER COLUMN MAXIMUM SUPPLY PRESSURE: 13" WATER COLUMN MAXIMUM SUPPLY PRE AXIMUM SU
" D'UNE COLONNE D'EAU D'UNE COLONNE D'EAU PRESSION D'ALIMEN PRESSION D'ALIMENTATION MAXIMALE: 13" D'UNE COLONNE D'EAU ESSION D'AL
UN COMBU UN COMBUSTIBLE SOLIDE NE DOIT PAS ETRE UTILISE UN COMBU
AVEC CET APPAREIL. UTILISER AVEC LES PORTES AVEC C AVEC C
VITREES HOMOLOGUEES SEULEMENT AVEC CETTE UNITE. VITR VITR
ERMOCOUPLE.
STEEL L L L L L TD TD. DO NOT DO NOT
A AVERTISSEMENT: A
RAPIDE. REMPLACEZ UNIQUEMENT AVEC UN THERMOCOUPLE À ACTION RAPIDE DE WOLF STEEL
LTÉE. N'AJOUTEZ PAS A CET APPAREIL AUCUN MATERIAU DEVANT ENTRER EN CONTACT AVEC
LES FLAMMES AUTRE QUE CELUI QUI EST FOURNI AVEC CET APPAREIL PAR LE FABRICANT.
THE APPLIANCE MUST BE VENTED USING THE APPROPRIATE WOLF STEEL VENT KITS. SEE
25"
OWNERS INSTALLATION MANUAL FOR VENTING SPECIFICS. PROPER REINSTALLATION AND
1"
2" RESEALING IS NECESSARY AFTER SERVICING THE VENT-AIR INTAKE SYSTEM.
1"
L'APPAREIL DOIT EVACUER SES GAZ EN UTILISANT L'ENSEMBLE D'EVACUATION PROPRE A
NAPOLEON. REFERER AU MANUEL D'INSTALLATION DE PROPRIETAIRE POUR L'EVACUATION
PRECISE. IL EST IMPORTANT DE BIEN REINSTALLER ET RESCELLER L'EVENT APRES AVOIR
ASSURE LE MAINTIEN DU SYSTEME DE PRISE D'AIR.
ELECTRICAL RATING / CLASSIFICATION: 115V 0.82AMP, 60HZ
OPTIONAL FAN KIT / ENSEMBLE DE VENTILATEUR FACULTATIF: GZ550-1KT
SERIAL NUMBER/NO. DE SERIE:
WARNING
!
VE VE
INSTALLAT NSTALLA
POUR INSTALLA OUR INSTALL
GENCES DE LA GENCES DE LA NORM
AU GAZ, EN VIGUEUR AU CA U GAZ, EN VIGUEUR AU C
E CONSTRUCTION DE MAISONS M ONSTRUCTION DE MAISONS
CAS OU CETTE NORME D'ETATS-UNIS U CETTE NORME D'ETATS
ME RELATIVE AU CRITERE DE MESURES DE AU CRITERE DE MESURES DE
ALLATIONS DANS LES MAISONS MANUFACTURES, ES MAISONS MANUFACTURES,
TES, ANSI/NFPA 501A. ES, LORSQU'IL EST INSTALLE AVEC LA TROUSSE POUR ECRAN LORSQU'IL EST INSTALLE AVEC RSQU'IL EST INSTALLE AVEC
BGD42CFP BGD42CFP BGD42C B BCDV42CFP
0-4500FT (0-1370m) 0-4500FT (0-1370m) -4500FT (0-1370m)
24,000 BTU/h 24,000 BTU/h 000 BTU/h
18,000 BTU/h 18,000 BTU/h 18,000 BTU/h
10" WATER CO WATER C
10" 10" D
CE FOYER UTILISE ET REQUIERT UN THERMOCOUPLE À ACTION
BGD42CF
7.2B
7
W385-0343 / G
W415-0779 / D / 08.13.12