Open Top Burners; Oven Burner - Saturn SMDR-36-6 Operation Manual

OPEN TOP BURNERS

1. Before attempting to light the appliance, the cover, if so equipped, shall be
opened.
2. Make sure all valves are closed before turning on the gas supply.
3. Turn on the pilot valve with a screw driver. Light up the pilot with a flame
gun.
4. When the pilot is lit, turn on the main valve by rotating it anticlockwise 90
to the position "ON". The main burner will then be lit up. To turn off the
valve, rotate it clockwise to "OFF". A 5 minute complete shutoff period
should be allowed before the appliance is relighted.
5. To turn off all open burners and pilot:
Turn off the main valves. When all burners go out, turn off the pilot valves
with a screw driver.

OVEN BURNER

WARNING: ENSURE THE PILOT IS ESTABLISHED BEFORE
TURNING ON THE THERMOSTAT. THE PILOT FLAME CAN BE SEEN
THROUGH THE VIEWING HOLE.
1. Before attempting to light the appliance, the cover, if so equipped, shall be
opened.
2. Make sure the thermostat located on the control panel is turned off.
3. Take off the lower panel, press the black button of the safety valve for 15 to
30 seconds. Stick the flame gun through an opening to light up the pilot
(located at about 100 mm behind the opening). Wait for 5 to 10 seconds
before releasing your finger on the black button.
process again if the pilot flame does not stay by now.
4. When the pilot flame is lit, turn the thermostat to the desired temperature
o
(250 – 500 F). You can observe the flame of the oven burner from an
opening behind the lower panel. You may replace the lower panel now.
5. To turn off the oven, rotate the thermostat clockwise to "OFF" position.
The oven burner should go out immediately. A 5 minute complete shutoff
period should be allowed before the appliance is relighted.
Adjustment of main burners
Proper flame setting of main burners is obtained by loosening set screw on air
shutters and to proceed as follows:
Air shutters should first be opened all the way for a sharp blue flame, then
slowly close until the flames turns soft with just a minimum of yellow at the tips.
Gas Range Manual Page 14
o
Repeat the above
Revision: 24 Feb 2011