Table of Contents
Advertisement
Quick Links
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
NOTICE: DO NOT discard this manual!
Models:
This appliance may be installed as an OEM
installation in manufactured home (USA
only) or mobile home and must be installed
in accordance with the manufacturer's
instructions and the Manufactured Home
Construction and Safety Standard, Title 24
CFR, Part 3280 in the United States, or the
Standard for Installation in Mobile Homes,
CAN/CSA Z240 MH Series, in Canada.
This appliance is only for use with the type(s)
of gas indicated on the rating plate. This
appliance is not convertible for use with other
gases, unless a certifi ed kit is used.
Owner's Manual
Care and Operation
Heat & Glo • SL-550F, SL-750F Owner's Manual • 2297-981 Rev. E • 4/15
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death, or
property damage.
• DO NOT store or use gasoline or other fl am-
mable vapors and liquids in the vicinity of this
or any other appliance.
• What to do if you smell gas
- DO NOT try to light any appliance.
- DO NOT touch any electrical switch. DO
NOT use any phone in your building.
- Leave the building immediately.
- Immediately call your gas supplier from
a neighbor's phone. Follow the gas sup-
plier's instructions.
- If you cannot reach your gas supplier, call
the fi re department.
• Installation and service must be performed
by a qualifi ed installer, service agency, or the
gas supplier.
DANGER
DO NOT TOUCH GLASS
NEVER ALLOW CHILDREN
A barrier designed to reduce the risk of
burns from the hot viewing glass is provided
with this appliance and shall be installed for
the protection of children and other at-risk
individuals.
In the Commonwealth of Massachusetts installation must be
performed by a licensed plumber or gas fi tter.
See Table of Contents for location of additional Commonwealth
of Massachusetts requirements.
HOT GLASS WILL
CAUSE BURNS.
UNTIL COOLED.
TO TOUCH GLASS.
1
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Heat & Glo SL-550F
Summary of Contents for Heat & Glo SL-550F
-
Page 1: Care And Operation
See Table of Contents for location of additional Commonwealth of Massachusetts requirements. gases, unless a certifi ed kit is used. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 2: Welcome
00,000 00,000 MIN. MIN. INPUT INPUT BTUH: BTUH: 00,000 00,000 00,000 00,000 Serial Serial XXXXXXXX XXXXXXXX ORIFICE ORIFICE SIZE: SIZE: #XXXXX #XXXXX #XXXXX #XXXXX (Serie): (Serie): Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 3: Table Of Contents
C. Contact Information ......23 = Contains updated information. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 4: Limited Lifetime Warranty
Firebox and heat exchanger Lifetime All replacement parts 90 Days beyond warranty period See conditions, exclusions, and limitations on next page. 4021-645G 2/15 Page 1 of 2 Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... - Page 5 THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE EXPRESSED WARRANTY SPECIFIED ABOVE. 4021-645G 2/15 Page 2 of 2 Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15...
-
Page 6: Product Specifi C Information
Some local building codes require the use of tempered glass with permanent marking in such locations. Glass meeting this requirement is available from the factory. Please contact your dealer or distributor to order. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 7: Important Safety And Operating Information
• Install a switch lock or a wall/remote control with child protection lockout feature. • Keep remote controls out of reach of children. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 8: General Operating Parts
WARNING! Risk of Fire or Asphyxiation! DO NOT op- erate fi replace with fi xed glass assembly removed. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 9: For Your Safety Read Before Lighting
Propane Installation code, CSA B149.1. tions accompanying appliance. For additional information on operating your 593-913i Hearth & Home Technologies fi replace, please refer to www.fi replaces.com. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 10: Appliance Break-In
Turn the knob clockwise to increase the fan speed and counterclockwise to decrease the fan speed. VALVE CONTROL CAVITY LOCATION Figure 3.3 Control Cavity/Valve Location Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 11: Operation During A Power Outage
Section 3.G. Detailed instructions are in- backup including remote control, fan, lights, or any other cluded with the fan kit. auxiliary functions that require household 110-120 VAC power. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 12: Maintenance And Service
• Replace the glass door on the appliance. Pull out and latch the four glass assembly latches into the groove on the glass frame. See Figure 4.1. • Reinstall decorative front. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 13: Remote Control
If not using your fi replace for an extended period of time (summer months, vacations/trips, etc), to prevent unin- tended operation: • Remove batteries from remote controls. • Unplug 3 volt adapter plug on IPI models. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 14: Maintenance Tasks - Qualifi Ed Service Technician
Use caution when cleaning these areas. Screw tips that Figure 4.2 IPI Pilot Flame Patterns have penetrated the sheet metal are sharp and should be avoided. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 15: Frequently Asked Questions And Troubleshooting
This appliance can operated on battery power in the event of a power outage. To access Power Outages the battery pack, the decorative front, mesh and glass assembly must be removed. Refer to (battery backup) Section 3 for more details. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 16: Troubleshooting
Verify module is securely grounded to metal chassis of appliance. D. Module voltage output / Valve/Pilot Verify battery voltage is at least 2.7 volts. Replace batteries if volt- solenoid ohms readings. age is below 2.7. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... - Page 17 ON position. If there is no spark at “I” terminal module must be replaced. If there is a spark at “I” terminal, module is fi ne. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15...
-
Page 18: Reference Materials
Media Kits are available for use with the SL-550F and SL- 750F models. Install media according to the instructions included with the kit. WARNING! Choking Hazard! Keep media out of reach of children. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... -
Page 19: Service Parts
Glass Door Assembly GLA-550TR Firescreen Front SRV2355-021 Replacement orders Pre 0023877692 must order SHOW-RIVNUT Junction Box 4021-013 Additional service part numbers appear on following page. 4/15 Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15... - Page 20 Glass Door Assembly GLA-750TR Firescreen Front SRV2118-055 Replacement orders Pre 0023877692 must also order SHOW-RIVNUT Junction Box 4021-013 Additional service part numbers appear on following page. 4/15 Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15...
- Page 21 SL--550F Ori ce LP (1.25 mm) 582-8125 Ori ce NG (#42) 582-842 SL--750F Ori ce LP (#54) 582-854 Additional service part numbers appear on following page. Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15...
- Page 22 LPK-550F Conversion Kit NG NGK-750F SL-750F Conversion Kit LP LPK-750F Pilot Ori ce NG 593-528 Pilot Ori ce LP 593-527 Regulator NG NGK-DXV Regulator LP LPK-DXV Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15...
-
Page 23: Contact Information
5941237, 6006743, 6019099, 6053165, 6145502, 6374822, 6484712, 6601579, 6769426, 6863064, 7077122, 7098269, 7258116, 7470729, 8147240 or other U.S. and foreign patents pending. 2000-945C Printed in U.S.A. - Copyright 2015 Heat & Glo • SL-550F, SL-750F Owner’s Manual • 2297-981 Rev. E • 4/15...