Holman QCS-2-1200B Installation And Operation Instructions Manual
Conveyor toaster
Hide thumbs
Also See for QCS-2-1200B:
- Installation and operation instructions manual (24 pages) ,
- Installation and operation instructions manual (24 pages)
Related Manuals for Holman QCS-2-1200B
Summary of Contents for Holman QCS-2-1200B
- Page 1 ® CONVEYOR TOASTER MODEL QCS-2-1200B RCS-2-1200B QCS-3-1600B Installation and Operation Instructions 2M-HG0656 Rev. I 2/11/2011 QCS-2...
-
Page 2: Safety Symbol
SAFETY SYMBOL These symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual ac- companying the appliance. RETAIN THIS MANUAL FOR FUTURE REFERENCE NOTICE Using any part other than genuine Star factory supplied parts relieves the manufacturer of all liability. -
Page 3: General Installation Data
GENERAL INSTALLATION DATA CAUTION This equipment is designed and sold for commercial use only by personnel trained and experienced in its operation and is not sold for consumer use in and around the home nor for use directly by the general public in food service locations. -
Page 4: Daily Operation
WARNING DO NOT CUT OR REMOVE THIS PLUG OR GROUNDING PRONG FROM THE PLUG. WARNING CONNECT/PLUG UNIT INTO DEDICATED A.C. LINE ONLY SPECIFIED ON THE DATA PLATE OF THE UNIT. DAILY OPERATION ROTARY POWER SAVER SWITCH For toasters equipped with a Rotary Power Saver Switch, turn clockwise or counterclockwise to get in the following positions. -
Page 5: Toaster Components
This will cause food particles and grease film to carbonize. CLEANING Preventive maintenance for your Holman toaster consists of the following recommended cleaning procedures. To keep your toaster in its top operating condition, these steps should be performed on a daily or weekly as indicated. -
Page 6: Maintenance Procedures
MAINTENANCE PROCEDURES A. REPLACING HEATER TUBES 1) DISCONNECT UNIT FROM POWER SOURCE. 2) Remove the enclosure, by removing screws. Lift back end of enclosure up then back. 3) Remove heater tube wires from terminal block connection, keeping top and bottom wires separate. 4) Lift heater tube retainers by loosening retaining screws and sliding the retainer plate up. -
Page 7: Troubleshooting Guide
The front edge of the enclosure will slide beneath the toaster front. D. HEAT LIMIT SWITCH (RESET) Your Holman conveyor toaster is equipped with an automatically activated heat limit switch that interrupts the heater tube connections if the ambient temperature in the control box exceeds 190°F (88°C). -
Page 8: Limited Equipment Warranty
Visit our Website at: www.star-mfg.com Email: service@star-mfg.com THOROUGHLY INSPECT YOUR UNIT ON ARRIVAL This unit has been tested for proper operation before leaving our plant to insure delivery of your unit in perfect condition. However, there are instances in which the unit may be damaged in transit. In the event you discover any type of damage to your product upon receipt, you must immediately contact the transportation company who delivered the item to you and initiate your claim with same. - Page 9 NOTE: DRIVE MOTOR, FOR 240V USE BLACK AND BLUE WIRES, FOR 208V USE BLACK & WHITE WIRES. THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED. MODEL: QCS-2-1200B, QCS3-95HNH, QCS-3-1600B 065500 Rev A 04/3/2001...
- Page 10 NOTE: DRIVE MOTOR, FOR 240V USE BLACK AND BLUE WIRES, FOR 208V USE BLACK & WHITE WIRES. THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED. 065021 01-31-05 WIRING DIAGRAM - RCS-2 1200B SERPENTINE WIRE DIAGRAM 208/220/240 VOLT, SIRED SERIES...
-
Page 12: Parts List
PARTS LIST April 4, 2011, Rev. I QCS-2-1200B Conveyor Toasters Number Part Description Number Unit Number HC-101370 ENCLOSURE HF-402449 PANEL, BACK 2E-200574 SWITCH, FAN CERAMIC HG-402144 BRACKET, FAN SWITCH 2U-200561 MOTOR, FAN 2U-200509 MOTOR, DRIVE, FAN NOT INCLUDED 60 Hz... - Page 13 PARTS LIST April 4, 2011, Rev. I QCS-3-1600B Conveyor Toasters Number Part Description Number Unit Number HC-101371 ENCLOSURE HH-402470 PANEL, BACK QCS3 2E-200574 SWITCH, FAN CERAMIC HG-402144 BRACKET, FAN SWITCH 2U-200561 MOTOR, FAN 2U-200509 MOTOR, DRIVE, FAN NOT INCLUDED 60 Hz 2U-200590 MOTOR, DRIVE 3286 BB, LOW, FAN NOT INCL.
- Page 14 PARTS LIST April 4, 2011, Rev. I RCS-2-1200B Conveyor Toasters Number Part Description Number Unit Number HC-101370 ENCLOSURE HF-402449 PANEL, BACK 2E-200574 SWITCH, FAN CERAMIC HG-402144 BRACKET, FAN SWITCH 2U-200561 MOTOR, FAN 2U-200509 MOTOR, DRIVE, FAN NOT INCLUDED 2R-Z8879 FAN BLADE, DRIVE MOTOR 2A-202900 SHAFT, DRIVE HA-112261...
- Page 15 PARTS LIST April 4, 2011, Rev. I RCS Conveyor Toasters HEATER TUBES Number Part Description Number Number Unit HEATER TUBE METAL, TOP 208V 2N-209114 HEATER TUBE METAL, BOTTOM 208V 2N-209198 HEATER TUBE METAL, TOP 220V 2N-209113 HEATER TUBE METAL, BOTTOM 220V 2N-209192 HEATER TUBE METAL, TOP...